This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Rear coil spring is broken. Normal driving conditions and we noticed a significant vibration. Upon inspection of rear suspension we found a broken rear coil spring. I researched this issue and found that VW recalled several other 2015 models for rear coil springs breaking. This is a major safety issue. Currently we cannot use the car due to this safety issue.
Fractured rear coil spring on a 2015 Volkswagen Passat Limited. There is a current recall, 42J5, for various VW's from 2015 to 2019, but not for the Passat. NHTSA Campaign #19V188000 should cover rear coil springs in all VW"s for the years listed. Same defect, same dangers. I have the coil spring and will save it for a reasonable period of time if an inspection of the unit is needed. Contacted VW customer service and was told coil spring would not be covered.
Engine time chain skipped. Fuel rail leak from regulator(dangerous to drive as it can catch on fire). Suspension problem car shakes over 40mph(alignment and balance did not help), problem due to coils or other components. Mechanic shop checked car and they denied to work on it due to fuel recall.
Rear passenger side wheel area started making a lot of noise. After tire was taken off, found rear coil spring broken and dislodged from proper location. Then looked at drivers side rear coil spring and it was still in proper location but broken. Found replacement part which also fit VW Beetle and VW Jetta which are much smaller cars than a Passat. VW does not offer heavier springs.
- Excello, MO, USA
Search CarComplaints.com for these popular complaint phrases...
For about 2 years my vehicle has been vibrating at the steering wheel. I have replaced the tires twice, have done multiple tire balances, rotations, road force tests, alignments, and have requested multiple inspections of all components associated with the steering assembly. All possible solutions have apparently been insufficient or they have been found inconclusive. The technicians at the dealership have been unable to identify the cause of the vibration. Due to this, my steering wheel has continued to vibrate for about 2 years. The vibration occurs around highway speeds as well as when braking. I have recorded multiple videos that show this as well as having testament from multiple people, including dealership staff. The vibration has slowly but surely gotten worse over time and I am afraid that something will break and cause me to have an accident or severe injuries.
At speed of over 65mph. Steering wheel starts to vibrate within 10minutes of driving on the highway. Keep returning to the dealer which says they have done all they can that should have correct the problem. But after they have tried for over 4 times to correct it. The issue still there.
The contact owns a 2015 Volkswagen Passat. While driving approximately 35 mph, the contact heard a lot of unusual noises coming from the rear of the vehicle without warning. The contact stated that the vehicle was leaning towards the driver's side. The vehicle was taken to fox valley Volkswagen schaumburg (847-839-8101, located at 1000 East golf road, schaumburg, il 60173) where it was diagnosed that the rear coil spring was fractured and needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was 17,000.
I recently faced an issue with my Volkswagen Passat 2015 with the suspensions making clanking noise. I had it checked with the dealership and the issue turned out to be broken coil springs on the rear left side. I have own this car for three and a half years, but only have 16K miles on it. I rarely drive in snow as I work from home. A little exposure to snow have caused the coil springs to wear out. I have heard of recalls from Nissan and Honda in the past regarding a similar issue with coil springs. I'm sure other Volkswagen owners are facing the same thing as I heard the service agent whispering that this happens with most of the Volkswagen cars and he's surprised there hasn't been a recall for it yet. As I'm merely over the bumper warranty, I had to pay $800 out of pocket to replace the springs. I wish Volkswagen made more reliable cars.
On the way to the airport pulling out into traffics. I heard a pound noice and my whole car vibrated. It was like a sting loud and tension filled. When we came back to have it looked at and my dealership they say it's a coil spring. Ive found recalls on the VW 2015-2019 but not the Passat. Well. The Passat has the problem too please look into to this. Very disconcerting. I feel it is the same problem
The contact owns a 2015 Volkswagen Passat. While driving 35 mph, an abnormal noise was heard from the rear of the vehicle without warning. The vehicle was taken to maguire Volkswagen of ithica (located at 370 elmira rd, ithaca, NY 14850, (607) 257-1515) where it was diagnosed that the rear passenger side coil spring fractured and needed to be replaced. The contact was also informed that the coil springs installed on the vehicle were not made to support the weight of the vehicle. The vehicle was not repaired. The manufacturer was notified. The approximate failure mileage was 68,000. The VIN was not available.
Excessive inside front tire wear can lead to tire failure. Font end can not be properly aligned because there is no camber adjustment. Tires showed excessive wear at 10,000 miles. Tires were rotated and front end realigned and these tires have the inside about wore out after 16,000 miles. The wear seems to occur when making sharp turns when exiting on the freeway cloverleaf. The inside wear pattern will be a dark black from scuffing on the turn.
Cpsc:purchased kyb 344459 and kyb 335808 (shocks and struts) from autozone and installed on 01/06/2018. Product was purchased according to my VIN for fitment. After installation my car has been operating very unsafe, suspension is extremely hard, bouncy, wavy, ect.
I bought a 2015 Passat wolfsburg edition in February of 2015. Within the first 200 miles vehicle was shimmying when brakes were applied. Dealer refused to replace the brakes under the warranty saying its wear and tear. I called vwa they advised dealer and the rotors were replaced. Not even two weeks after brakes start squealing. I return to dealership and get told its nothing. Brakes continued to squeal until I had them replaced somewhere else at 26350 miles. However while brakes were squealing and even after being replaced..vehicle bas developed a chirp on both hubs when vehicle is turned and or accelerated from a stand still. Vehicle has 27000 miles on it. There's no reason it should be having these issues. I bought the vehicle at valley auto world in fayetteville nc. Also my front suspension is making noise when hitting certain bumps. Steering still has shimmy when driving. I need my repaired and 100% safety guaranteed or I will seek federal legal assistance.
A D V E R T I S E M E N T S
- Valley View, OH, USA