Technical Service Bulletins (TSBs) for the 1998 Passat are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
ZF VH RECALL OF THE ZF STEERING PUMP, SUPPLIED TO WD'S FOR REPLACEMENT OF THE AUDI A4 PASSAT P/N 8D0 145 156FX INSTEAD OF THE CORRECT ZF P/N 7691 955 276ZW. 2004 AUDI A4 ALSO INCLUDED. *TT Read More »
For long crank/ difficulty starting with the engine hot: Before replacing any components for this complaint, drain the fuel from the vehicle and replace with known good diesel fuel from a reputable source. Read More »
To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables below. Note that the first table is only applicable to 2.8L V6 equipped vehicles WITHOUT a CAN-Bus. All 1. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Tech Tips (Bosch 5.3 ABS Control Module ? ABS Coding Tables): This document informs To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables in this document. Read More »
To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables below. Note that the first table is only applicable to 2.8L V6 equipped vehicles WITHOUT a CAN-Bus. All 1. Read More »
Tech Tips (Bosch 5.3 ABS Control Module ? ABS Coding Tables): This document informs To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables in this document. Read More »
VOLKSWAGEN: UPDATE TO INFORMATION. PROVIDING CORRECT CODING VALUES FOR ABS CONTROL MODULES ON CERTAIN VEHICLES WITHOUT CAN-BUS. MODELS 1998-2002 PASSAT. *PE Read More »
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
VOLKSWAGEN: ENGINE OIL PRESSURE TOO LOW, LIGHT IS ON, ENGINE FLUSH. THE LOW ENGINE OIL PRESSURE CONDITION MAY BE CAUSED BY A RESTRICTION OF THE OIL PUMP SUCTION LINE STRAINER. *PE Read More »
OIL SLUDGE - WARRANTY EXTENSION FOR 1998-2004 MODEL YEAR VOLKSWAGEN PASSAT WITH 1.8L TURBO ENGINE US AND CANADIAN DEALERS. SERVICE CIRCULAR. *TT Read More »
SUBJECT REGARDING VEHICLE'S EXHIBITING FAILURE OF THE TURBOCHARGER DUE TO LACK OF LUBRICATION ON PASSAT WITH 1.8L 5V TURBO VEHICLES FROM 1998-1999 UP TO VIN #XE000100. *MS Read More »
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
For long crank/ difficulty starting with the engine hot: Before replacing any components for this complaint, drain the fuel from the vehicle and replace with known good diesel fuel from a reputable source. Read More »
For long crank/ difficulty starting with the engine hot: Before replacing any components for this complaint, drain the fuel from the vehicle and replace with known good diesel fuel from a reputable source. Read More »
Tech Tips (Fuel Gauge Inoperative after Instrument Cluster Replacement with Fault 00771 ?Fuel level sensor -G-?): An inoperative fuel gauge after instrument cluster replacement with fault 00771 ?Fuel level sensor -G-? may be caused by ... Read More »
Tech Tips (Fuel Gauge Inoperative after Instrument Cluster Replacement with Fault 00771 ?Fuel level sensor -G-?): An inoperative fuel gauge after instrument cluster replacement with fault 00771 ?Fuel level sensor -G-? may be caused by ... Read More »
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Tech Tips (Bosch 5.3 ABS Control Module ? ABS Coding Tables): This document informs To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables in this document. Read More »
Tech Tips (Fuel Gauge Inoperative after Instrument Cluster Replacement with Fault 00771 ?Fuel level sensor -G-?): An inoperative fuel gauge after instrument cluster replacement with fault 00771 ?Fuel level sensor -G-? may be caused by ... Read More »
INFORMATION IN THIS TECHNICAL BULLETIN SUPLLEMENTS AND UPDATES PREVIOUSLY PUBLISHED WIRING DIAGRAM, TROUBLESHOOTING AND COMPONENT LOCATION INFORMATION. *TTT Read More »
NEW INFORMATION IN THIS TECHNICAL BULLETING SUPPLEMENTS AND UPDATES PREVIOUSLY PUBLISHED WIRING DIAGRAM, TROUBLESHOOTING AND COMPONENT LOCATION INFORMATION. *YC Read More »
NEW INFORMATION IN THIS TECHNICAL BULLETIN SUPPLEMENTS AND UPDATES PREVIOUSLY PUBLISHED WIRING DIAGRAM, TROUBLESHOOTING AND COMPONENT LOCATION INFORMATION. *YC Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other ... Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts Read More »
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not ... Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
A CONDITION MAY EXIST WHERE THE RADIO DOES NOT REGAIN VOLUME CONTROL AND / OR THE SINGLE CD PLAYER LED BLINKS WHEN INTERIOR LIGHTS ARE AT THE LOWEST SETTING. *TT Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
