Technical Service Bulletins (TSBs) for the 2001 Jetta are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
For concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Tech Tips (Models with 1.8T Engine - Pressure Loss issues): Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. Read More »
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Tech Tips (Coolant fan control module J293 pinout): 1.8L and 2.0L (Except Engine Code BBW), Fan Module J293 Pinout Chart which informs of the terminal types, the inputs, and outputs, the signal purpose, and the signal ... Read More »
VOLKSWAGEN: DUE TO A POSSIBLE FAILURE OF THE OXYGEN SENSOR IN UPPER PART OF EXHAUST SYSTEM, VEHICLE MAY EXCEED FEDERAL AND/OR CALIFORNIA EMISSION STANDARDS OR INCREASED FUEL CONSUMPTION. MODEL 1999-2001 GOLF, JETTA, NEW BEETLE. Read More »
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM software for the catalytic converter monitoring system is too sensitive. Read More »
Emissions Recall Circular (2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor): Volkswagen has found that the oxygen sensor in the upper part of the exhaust system ... Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Tech Tips (Coolant fan control module J293 pinout): 1.8L and 2.0L (Except Engine Code BBW), Fan Module J293 Pinout Chart which informs of the terminal types, the inputs, and outputs, the signal purpose, and the signal ... Read More »
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM software for the catalytic converter monitoring system is too sensitive. Read More »
Emissions Recall Circular (2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor): Volkswagen has found that the oxygen sensor in the upper part of the exhaust system ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Tech Tips (Equipped with ALH TDI Engine - Glow Plug Replacement Tip): This document informs that there are 2 suppliers for the TDI glow plugs-Bosch and Beru. When replacing the glow plugs make sure that you do not mix stock. Read More »
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN ... Read More »
EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN. VOLKSWAGEN. *MJ Read More »
EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES (DTC) - HOW TO PERFORM EFFECTIVE DIAGNOSTIC RELATED TO FUEL SYSTEM ADAPTATION SYSTEM TOO RICH/ TOO LEAN. VOLKSWAGEN. *MJ Read More »
Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. Read More »
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Read More »
Emissions Recall Circular - 1999-2001 Volkswagen Folf/Jetta and New Beetle 2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
Tech Tips (Coolant fan control module J293 pinout): 1.8L and 2.0L (Except Engine Code BBW), Fan Module J293 Pinout Chart which informs of the terminal types, the inputs, and outputs, the signal purpose, and the signal ... Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
VOLKSWAGEN: THE CATALYTIC CONVERTER MONITORING SYSTEM, WITH THE ECM SOFTWARE, IS TOO SENSITIVE AND CAUSES THE MALFUNCTION INDICATOR LAMP (MIL) TO COME ON AND EXCEED EMISSIONS STANDARDS FOR FEDERAL AND/OR CALIFORNIA. Read More »
Emissions Recall Circular - 1999-2001 Volkswagen Folf/Jetta and New Beetle 2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor Read More »
Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. Read More »
If a customer comments that the key cannot be removed from the ignition when the transmission is in PARK or that the PRND12 is not reading correctly in the MFI, DO NOT replace the ignition switch, lock cylinder, or lock housing assembly. Read More »
Tech Tips (Vehicles with 09G or 09A Transmission -- Replacing Transmission): This document informs If you replace one of these transmissions, check ETKA to see if you must also replace the Transmission Control Module (TCM) at the same ... Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Tech Tips (Vehicles with 09G or 09A Transmission -- Replacing Transmission): This document informs If you replace one of these transmissions, check ETKA to see if you must also replace the Transmission Control Module (TCM) at the same ... Read More »
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
The DLC is intended for use with diagnostic scan tools and by emissions testing stations. However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
If a customer comments that the key cannot be removed from the ignition when the transmission is in PARK or that the PRND12 is not reading correctly in the MFI, DO NOT replace the ignition switch, lock cylinder, or lock housing assembly. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Tech Tips (Coolant fan control module J293 pinout): 1.8L and 2.0L (Except Engine Code BBW), Fan Module J293 Pinout Chart which informs of the terminal types, the inputs, and outputs, the signal purpose, and the signal ... Read More »
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM software for the catalytic converter monitoring system is too sensitive. Read More »
Emissions Recall Circular (2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor): Volkswagen has found that the oxygen sensor in the upper part of the exhaust system ... Read More »
Emissions Recall Circular - 1999-2001 Volkswagen Folf/Jetta and New Beetle 2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor Read More »
Be aware that there are 2 suppliers for the TDI glow plugs-Bosch and Beru. When replacing the glow plugs make sure that you do not mix stock. The vehicle must have all the same supplier or DTC P0380 (Glow Plug Monitoring) may set. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
For concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. Read More »
A CONDITION MAY EXIST WHERE DIAGNOSTIC TROUBLE CODES P1297 OR P1557 ARE STORED IN DIAGNOSTIC TROUBLE CODE MEMORY. MAY BE CAUSED BY INTAKE HOSES LEAKING DUE TO CLAMPS INCORRECTLY TORQUED OR IMPROPERLY PLACED, WORN / TORN INTAKE HOSES ETC. Read More »
Tech Tips (Rear Lid Does Not Open After Handle Replacement): If the rear lid handle is replaced with part number 1J0 827 566L, the microswitch from the original handle must be transferred to the new handle. Read More »
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. Read More »
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN ... Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
VOLKSWAGEN: THE CATALYTIC CONVERTER MONITORING SYSTEM, WITH THE ECM SOFTWARE, IS TOO SENSITIVE AND CAUSES THE MALFUNCTION INDICATOR LAMP (MIL) TO COME ON AND EXCEED EMISSIONS STANDARDS FOR FEDERAL AND/OR CALIFORNIA. Read More »
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM software for the catalytic converter monitoring system is too sensitive. Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other ... Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSPECT, CLEAN AND MODIFY SUNROOF DRAINS FOR CERTAIN VOLKSWAGEN VEHICLES AND REVISED MAINTENANCE SCHEDULE; SUNROOF DRAIN INSPECTION AND CLEANING. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Technical Bulletin (Corrosion on the Fold of the Front Inner Door): Corrosion under the door fold in the area of the extra seal and the Poly Vinyl Chloride (PVC) foil. Read More »
Technical Bulletin: Rear Quarter Panel Corrosion issues. This document has the Warranty documentation to inquire about coverage. It also has examples of instances calculating the services performed Read More »
Technical Bulletin: Rear Quarter Panel Corrosion issues. This document discusses causes, fault codes for servicing, and example claim forms for the servicing of the vehicle Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
DRIVER AND PASSENGER DOOR WINDOW REGULATOR REPAIRING. *MJ ADDITIONAL INFORMATION REGARDING DOOR WINDOW, SEPARATES FROM WINDOW REGULATOR CLAMPS. *TT Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
Technical Bulletin (Corrosion on the Fold of the Front Inner Door): This document informs of the method to repair Corrosion under the door fold in the area of the extra seal and the Poly Vinyl Chloride (PVC) foil. Read More »
The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts Read More »
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not ... Read More »
Tech Tips (Rear Lid Does Not Open After Handle Replacement): If the rear lid handle is replaced with part number 1J0 827 566L, the microswitch from the original handle must be transferred to the new handle. Read More »
VEHICLE SPEED CONTROL:THROTTLE:THROTTLE POSITION SENSOR (TPS)
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) Read More »
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. Read More »
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
Technical Bulletin (Corrosion on the Fold of the Front Inner Door): Corrosion under the door fold in the area of the extra seal and the Poly Vinyl Chloride (PVC) foil. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Rear Quarter Panel Corrosion issues. This document has the Warranty documentation to inquire about coverage. It also has examples of instances calculating the services performed Read More »
Technical Bulletin: Rear Quarter Panel Corrosion issues. This document discusses causes, fault codes for servicing, and example claim forms for the servicing of the vehicle Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
Be aware that there are 2 suppliers for the TDI glow plugs-Bosch and Beru. When replacing the glow plugs make sure that you do not mix stock. The vehicle must have all the same supplier or DTC P0380 (Glow Plug Monitoring) may set. Read More »
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. Read More »
Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. Read More »
JETTA-JSW Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
JETTA Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Jetta Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, ... Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Document discusses Electrolytic corrosion around the license plate lights (opening/contact surface, inside and outside) because of water ingress via the seal of the license plate lights. Read More »
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
Technical Bulletin (Temperature Output Control Cannot Be Adjusted): Customer states cannot adjust temperature and/or A/C is not cold. The blend door control lever moves freely, but the blend door does not operate. Read More »
Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear. Read More »
