Technical Service Bulletins (TSBs) for the 1999 Jetta are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
VOLKSWAGEN: DUE TO A POSSIBLE FAILURE OF THE OXYGEN SENSOR IN UPPER PART OF EXHAUST SYSTEM, VEHICLE MAY EXCEED FEDERAL AND/OR CALIFORNIA EMISSION STANDARDS OR INCREASED FUEL CONSUMPTION. MODEL 1999-2001 GOLF, JETTA, NEW BEETLE. Read More »
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM software for the catalytic converter monitoring system is too sensitive. Read More »
Emissions Recall Circular (2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor): Volkswagen has found that the oxygen sensor in the upper part of the exhaust system ... Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM software for the catalytic converter monitoring system is too sensitive. Read More »
Emissions Recall Circular (2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor): Volkswagen has found that the oxygen sensor in the upper part of the exhaust system ... Read More »
Tech Tips (Equipped with ALH TDI Engine - Glow Plug Replacement Tip): This document informs that there are 2 suppliers for the TDI glow plugs-Bosch and Beru. When replacing the glow plugs make sure that you do not mix stock. Read More »
EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN. VOLKSWAGEN. *MJ Read More »
EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES (DTC) - HOW TO PERFORM EFFECTIVE DIAGNOSTIC RELATED TO FUEL SYSTEM ADAPTATION SYSTEM TOO RICH/ TOO LEAN. VOLKSWAGEN. *MJ Read More »
Emissions Recall Circular - 1999-2001 Volkswagen Folf/Jetta and New Beetle 2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
VOLKSWAGEN: THE CATALYTIC CONVERTER MONITORING SYSTEM, WITH THE ECM SOFTWARE, IS TOO SENSITIVE AND CAUSES THE MALFUNCTION INDICATOR LAMP (MIL) TO COME ON AND EXCEED EMISSIONS STANDARDS FOR FEDERAL AND/OR CALIFORNIA. Read More »
Emissions Recall Circular - 1999-2001 Volkswagen Folf/Jetta and New Beetle 2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor Read More »
If a customer comments that the key cannot be removed from the ignition when the transmission is in PARK or that the PRND12 is not reading correctly in the MFI, DO NOT replace the ignition switch, lock cylinder, or lock housing assembly. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
If a customer comments that the key cannot be removed from the ignition when the transmission is in PARK or that the PRND12 is not reading correctly in the MFI, DO NOT replace the ignition switch, lock cylinder, or lock housing assembly. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM software for the catalytic converter monitoring system is too sensitive. Read More »
Emissions Recall Circular (2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor): Volkswagen has found that the oxygen sensor in the upper part of the exhaust system ... Read More »
Emissions Recall Circular - 1999-2001 Volkswagen Folf/Jetta and New Beetle 2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor Read More »
Be aware that there are 2 suppliers for the TDI glow plugs-Bosch and Beru. When replacing the glow plugs make sure that you do not mix stock. The vehicle must have all the same supplier or DTC P0380 (Glow Plug Monitoring) may set. Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
SUBJECT REGARDING WIRING DIAGRAM FOR DOOR CONTROL MODULE (DRIVER SIDE), SWITCH FOR REMOTE / FUEL TANK DOOR, MOTOR FOR FUEL TANK LID UNLOCK, POWER MIRROR (DRIVER SIDE), HEATED OUTSIDE MIRROR (DRIVER SIDE). Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. Read More »
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
VOLKSWAGEN: THE CATALYTIC CONVERTER MONITORING SYSTEM, WITH THE ECM SOFTWARE, IS TOO SENSITIVE AND CAUSES THE MALFUNCTION INDICATOR LAMP (MIL) TO COME ON AND EXCEED EMISSIONS STANDARDS FOR FEDERAL AND/OR CALIFORNIA. Read More »
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM software for the catalytic converter monitoring system is too sensitive. Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other ... Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
Technical Bulletin: Rear Quarter Panel Corrosion issues. This document has the Warranty documentation to inquire about coverage. It also has examples of instances calculating the services performed Read More »
Technical Bulletin: Rear Quarter Panel Corrosion issues. This document discusses causes, fault codes for servicing, and example claim forms for the servicing of the vehicle Read More »
DRIVER AND PASSENGER DOOR WINDOW REGULATOR REPAIRING. *MJ ADDITIONAL INFORMATION REGARDING DOOR WINDOW, SEPARATES FROM WINDOW REGULATOR CLAMPS. *TT Read More »
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. Read More »
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts Read More »
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not ... Read More »
SOME VEHICLES MAY EXHIBIT THROTTLE PEDAL VIBRATION AT IDLE AND / OR RAPPING NOISE AGAINST ENGINE COVER HEARD ON VEHICLES WITH SECONDARY AIR INJECTION. *TT Read More »
Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) Read More »
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Rear Quarter Panel Corrosion issues. This document has the Warranty documentation to inquire about coverage. It also has examples of instances calculating the services performed Read More »
Technical Bulletin: Rear Quarter Panel Corrosion issues. This document discusses causes, fault codes for servicing, and example claim forms for the servicing of the vehicle Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Read More »
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Read More »
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th. Read More »
Be aware that there are 2 suppliers for the TDI glow plugs-Bosch and Beru. When replacing the glow plugs make sure that you do not mix stock. The vehicle must have all the same supplier or DTC P0380 (Glow Plug Monitoring) may set. Read More »
A CONDITION MAY EXIST WHERE THE RADIO DOES NOT REGAIN VOLUME CONTROL AND / OR THE SINGLE CD PLAYER LED BLINKS WHEN INTERIOR LIGHTS ARE AT THE LOWEST SETTING. *TT Read More »
INFORMATION ON RADIO SERIAL NUMBER/CODE, STICKER LOCATION ON VEHICLE'S BEGINING WITH VIN #'S: GOLF/ JETTA (1999, 2000, 1H_XM215697), NEW GOLF/ NEW JETTA (1999,2000 ALL), NEW BEETLE (1999-2000-1C_WM024452), CABRIO (1999-2000- 1 H ... Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. Read More »
Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. Read More »
JETTA-JSW Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
JETTA Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Jetta Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has ... Read More »
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. Read More »
Document discusses Electrolytic corrosion around the license plate lights (opening/contact surface, inside and outside) because of water ingress via the seal of the license plate lights. Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
Technical Bulletin (Temperature Output Control Cannot Be Adjusted): Customer states cannot adjust temperature and/or A/C is not cold. The blend door control lever moves freely, but the blend door does not operate. Read More »
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Read More »
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0411 SECONDARY AIR SYSTEM INCORRECT FLOW DETECTED STORED IN DTC MEMORY. *TT Read More »
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0411 - SECONDARY AIR SYSTEM INCORRECT FLOW DETECTED - STORED IN MEMORY. *TT Read More »
