Technical Service Bulletins (TSBs) for the 2015 Golf SportWagen are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
Technical Bulletin (Brake Disc Pulsation or Vibration issues): When applying brakes at highway speeds the following symptoms may occur: - Brake pedal pulsation - Vibration felt in vehicle body - Steering wheel shakes For brake ... Read More »
Technical Bulletin (Squeaking Noises From Front Of Vehicle): Squeaking/creaking noise from front of vehicle while fully turning steering wheel. Read More »
Tech Tips: This Tech Tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel off ... Read More »
Technical Bulletin informing that When applying brakes at highway speeds the following symptoms may occur: - Brake pedal pulsation - Vibration felt in vehicle body - Steering wheel shakes It informs how to inspect brakes. Read More »
This service xpress document give information on the various fluids a vehicle can hold, how to check the fluids and when the vehicle should be serviced for maintenance Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin informing that When applying brakes at highway speeds the following symptoms may occur: - Brake pedal pulsation - Vibration felt in vehicle body - Steering wheel shakes It informs how to inspect brakes. Read More »
Technical Bulletin on how to service Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. Read More »
Addressess Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. Read More »
Tech Tips: This Tech Tip provides an overview of vehicle four wheel alignment, and important steps that should be followed when performing four wheel alignments Read More »
Technical Bulletin (Brake Disc Pulsation or Vibration): When applying brakes at highway speeds the following symptoms may occur: ? Brake pedal pulsation ? Vibration felt in vehicle body ? Steering wheel shakes For brake vibration or ... Read More »
Technical Bulletin (Vibration or Noise When Braking): Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. Read More »
Tech Tips (Suspension blocks): This document Recommends inspecting both front struts (including the protective sleeves / dust covers), for suspension blocks that might not have been completely removed during PDI. Read More »
Tech Tips (Rear Washer Jet Leaks / Drips After Use): For the A7 Golf with a rear washer nozzle leaking after use (Installed in the high mount brake lamp housing). An updated washer nozzle is now available. Read More »
Technical Bulletin (Vibration or Noise When Braking): Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. Read More »
Technical Bulletin (Vibration or Noise When Braking): Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. Read More »
Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. Read More »
Technical Bulletin informing that When applying brakes at highway speeds the following symptoms may occur: - Brake pedal pulsation - Vibration felt in vehicle body - Steering wheel shakes It informs how to inspect brakes. Read More »
Technical Bulletin (Brake Disc Pulsation or Vibration issues): When applying brakes at highway speeds the following symptoms may occur: - Brake pedal pulsation - Vibration felt in vehicle body - Steering wheel shakes For brake ... Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation completely. Read More »
Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation completely. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
To add model year 2016 and 2017 applicability and reminder about Programming Activation of Oil Pressure Regulation/Retraction on all models with 1.8L CPKA and CPRA engines after engine assembly, cylinder head or turbocharger replacement. Read More »
MIL-ON, FAULT P013E IN THE ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE RATTLE CLUTCH PEDAL SQUEAL/SQUEAK WHEN OPERATING CLUTCH PEDAL MIL-ON P0299 MIL-ON ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin (Washer Level Sensor issues): The sensitivity of the washer solvent level sensor (G33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Technical Bulletin (Ad Blue Leakage at Reductant Injector): Welding process issues of the reductant line connector to the supply line may cause Ad Blue leakage at the reductant injector. Read More »
Technical Bulletin (The camshaft adjuster control valve may stick causing camshaft position faults.): This document contains the fault codes needed to diagnose, and service the issue. Read More »
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. Read More »
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality ... Read More »
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. Read More »
Technical Bulletin (Engine Oil Level): Technicians may find during PDI that the oil level is below the full mark, but still within the hash marks on the engine oil dip stick. Read More »
Update to model year applicability. Generator Replacement Charging System inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing. Read More »
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Read More »
Technical Bulletin (Air Conditioning Does Not Cool and or Compressor is Noisy): The condition may be caused by a faulty A/C compressor regulator valve (N280). Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Maintenance Information (Volkswagen Carefree Maintenance Program - Gasoline Engines Model Year 2015 and Newer): This communication contains important information and SAGA claim entry requirements for the Volkswagen Carefree Maintenance ... Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
All Volkswagen engines are filled to a specific volume before leaving the factory. This level may vary depending on the testing conditions, but will always be within the allowable specification for engine protection. Read More »
Volkswagen of America is requesting your cooperation in supplying us with technical information related to the repair process for vehicles on which the TDI Generation 3, 2. Read More »
This special notice is to inform dealers to return all part numbers listed in the document. Only superseded part numbers to be ordered going forward. Read More »
This Document informs dealers that 2.0L TDI Gen 1, Gen 2 and Gen 3 Customer Vehicles are no longer eligible for the Pre-existing MIL-On Condition. Read More »
This Document informs dealers that 2.0L TDI Gen 1 and Gen 3 Customer Vehicles are no longer eligible for the Pre-existing MIL-On Condition. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
This document informs of Volkswagen AG and Audi AG received notice from the US Environmental Protection Agency, US Department of Justice and the California Air Resources Board of an investigation related to emissions compliance matters. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
Technical Bulletin: This document refers to direction on DTC P2014 Intake Manifold Position Sensor -G336- Replacement, and its fault codes. Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Technical Bulletin (Ad Blue Leakage at Reductant Injector): Welding process issues of the reductant line connector to the supply line may cause Ad Blue leakage at the reductant injector. Read More »
Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends), customers with certain 2009-2015 MY Volkswagen TDI? Clean Diesel Engine vehicles registered in the State of Minnesota only will ... Read More »
Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI? Clean Diesel Engine Vehicles Registered in the State of Minnesota Only (US Dealers Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
MIL-ON, FAULT P013E IN THE ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE RATTLE CLUTCH PEDAL SQUEAL/SQUEAK WHEN OPERATING CLUTCH PEDAL MIL-ON P0299 MIL-ON ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE ... Read More »
Technical Bulletin for Welding process issues of the reductant line connector to the supply line which may cause AdBlue leakage at the reductant injector. Read More »
This document informs dealers of a revision to the claim coding for the "Extended Emissions Warranty" Limited Warranty Extension for certain 2.0L TDI GEN 3 vehicles. Added clarification on totaled vehicles and loaners. Read More »
This communication contains important information and SAGA claim entry requirements for interim AdBlue refills under the Carefree Maintenance and VW Care Maintenance plans for Model Year 2015 and newer VW models with Diesel Engines. Read More »
Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends), customers with certain 2009-2015 MY Volkswagen TDI? Clean Diesel Engine vehicles registered in the State of Minnesota only will ... Read More »
Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI? Clean Diesel Engine Vehicles Registered in the State of Minnesota Only (US Dealers Read More »
MIL-ON, FAULT P013E IN THE ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE RATTLE CLUTCH PEDAL SQUEAL/SQUEAK WHEN OPERATING CLUTCH PEDAL MIL-ON P0299 MIL-ON ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. Read More »
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
MIL-ON, FAULT P013E IN THE ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE RATTLE CLUTCH PEDAL SQUEAL/SQUEAK WHEN OPERATING CLUTCH PEDAL MIL-ON P0299 MIL-ON ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE ... Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. Read More »
Glow Plug Pressure Sensor Faults Stored in ECM Fault Memory: When diagnosing MIL ON with glow plug pressure sensor DTC?s it important to perform diagnosis prior to replacing the glow plug. Read More »
Technical Bulletin (Car-Net Unresponsive - Verizon Telematics Service Interruptions and Outages): When beginning diagnosis for customer concerns related to functionality of the Car-Net system, it is important to understand that the ... Read More »
Technical Bulletin (Engine, Misfire Diagnostic Aid): This document informs that Multiple components SHOULD NOT be replaced for 1 misfiring cylinder. Repeat repairs must be carefully addressed to identify the root cause of the concern. Read More »
Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. Read More »
Technical Bulletin (Modular Infotainment System (MIB) Radio Switches to FM Station 87.7): The customer may complain that, intermittently, the FM radio station will have switched to the station 87.7 upon start up. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
Technical Bulletin (DTC P2014 Intake Manifold Position Sensor -G336- Replacement): Direction on proper part replacement when diagnosing fault code P2014 in the ECM Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ... Read More »
Technical Bulletin (Glow Plug Pressure Sensor Faults): When diagnosing MIL ON with glow plug pressure sensor DTC?s it is important to perform a diagnosis prior to replacing the glow plug. Read More »
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. Read More »
Update to model year applicability. Generator Replacement Charging System inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing. Read More »
Tech Tips (Entertainment Center MDI Cables ? 2015 (A7) Golf/GTI): For the A7 Golf/GTI the MDI cables are not the same as the ones used in the A6 Platform. This document informs how to tell the difference. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster. Read More »
Information for additional diagnosis should the Driver Assistance Systems Front Camera not calibrate, complete calibration or set a limit exceeded fault. Read More »
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. Read More »
Trouble shooting assistance should programming and/or reporting fail during campaign 23Q3 on vehicles equipped with KESSY antitheft system. Read More »
Repair direction to address fault code B201A that sets after replacement of the J794 infotainment module. Include model year 2017 for all models with MIB2 radios Read More »
Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (Modular Infotainment System Software): This document informs of Customer complaints of infotainment-related symptoms.. The corrective action taken for this issue is a software update. Read More »
Technical Bulletin (Modular Infotainment System (MIB) Radio Switches to FM Station 87.7): The customer may complain that, intermittently, the FM radio station will have switched to the station 87.7 upon start up. Read More »
UPDATE Technical Bulletin (2.0L TDI ECM Software Update): This update has been proactively released to prevent a MIL on condition. Updated ECM software is available to bring the vehicle up to the most current factory specifications. Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming Update 23O9 ? 2.0L TDI ECM Software Update with 2.0L TDI engine): This document is a notice to dealships that an software update will be avaliable for vehicles with the 2.0L TDI engine. Read More »
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
Tech Tips (Rear Washer Jet Leaks - Drips After Use): For the A7 Golf with a rear washer nozzle leaking after use (Installed in the high mount brake lamp housing). An updated washer nozzle is now available. Read More »
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
THIS COMMUNICATION IS THE CLOSURE OF A PREVIOUS REQUEST FROM VWOA PRODUCT SUPPORT TO VW PROFI DEALERS TO INVESTIGATE ANY COMPLAINTS OF WATER LEAKS FROM SUNROOF DRAIN TUBES. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. Read More »
In some sunroof-equipped vehicles, the front sunroof drains can become blocked with moist debris. If this happens, water could leak into the passenger compartment. Expiration date announcement Read More »
In some sunroof-equipped vehicles, the front sunroof drains can become blocked with moist debris. If this happens, water could leak into the passenger compartment. Updated expiration date. Read More »
In some sunroof-equipped vehicles, the front sunroof drains can become blocked with moist debris. If this happens, water could leak into the passenger compartment. Updated expiration date. Read More »
This Document informs dealers on the Sunroof Class Action Limited Warranty Extension revision. Revised to include info on how to proceed with vehicles not applicable to the 60E2/60E5. Read More »
This Document informs dealers on the Sunroof Class Action Limited Warranty Extension FAQ for commonly asked questions. Revised to include info on how to proceed with vehicles not applicable to the 60E2/60E5. Read More »
In some sunroof-equipped vehicles, the front sunroof drains can become blocked with moist debris. If this happens, water could leak into the passenger compartment. Golf Alltrack and Sportwagen added to the campaign. Read More »
In some sunroof-equipped vehicles, the front sunroof drains can become blocked with moist debris. If this happens, water could leak into the passenger compartment. Golf Alltrack and Sportwagen added to the campaign. Read More »
THIS COMMUNICATION IS THE CLOSURE OF A PREVIOUS REQUEST FROM VWOA PRODUCT SUPPORT TO VW PROFI DEALERS TO INVESTIGATE ANY COMPLAINTS OF WATER LEAKS FROM SUNROOF DRAIN TUBES. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Reporting procedure for A/C compressor replacement regardless of the reason for failure. Update to model year applicability and new warranty GFF labor operation number Read More »
Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and cost of cleaning solution in warranty table. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
In some sunroof-equipped vehicles, the front sunroof drains can become blocked with moist debris. If this happens, water could leak into the passenger compartment. Expiration date announcement Read More »
Technical Bulletin (Paint Defect - Water Migration Under the RAPGARD): Water migration under the RAPGARD? can be mistaken as a paint defect when in fact it is only moisture trapped in the clear coat of the paint. This document discusses. Read More »
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document refers to a pre check inspection on the quality of a vehicle such as - Inspecting vehicle for damage (to be completed within 48 hours of ... Read More »
Tech Tips (Rear Bumper Cover ? Paint Peeling): There have been cases identified where the paint is chipping/peeling on the rear bumper cover. Read More »
Tech Tips (Rear Washer Jet Leaks - Drips After Use): For the A7 Golf with a rear washer nozzle leaking after use (Installed in the high mount brake lamp housing). An updated washer nozzle is now available. Read More »
Tech Tips (Golf-Rear Washer Jet Leaks / Drips After Use): This document informs for the A7 Golf with a rear washer nozzle leaking after use (Installed in the high mount brake lamp housing). An updated washer nozzle is now available. Read More »
Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint. Read More »
Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) Read More »
Tech Tips: This Tech Tip provides an overview of vehicle four wheel alignment, and important steps that should be followed when performing four wheel alignments Read More »
Tech Tips (Suspension blocks): This document Recommends inspecting both front struts (including the protective sleeves / dust covers), for suspension blocks that might not have been completely removed during PDI. Read More »
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Information for additional diagnosis should the Driver Assistance Systems Front Camera not calibrate, complete calibration or set a limit exceeded fault. Read More »
MIL-ON, FAULT P013E IN THE ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE RATTLE CLUTCH PEDAL SQUEAL/SQUEAK WHEN OPERATING CLUTCH PEDAL MIL-ON P0299 MIL-ON ... Read More »
Elsa2Go campaign information is now 100% aligned with ElsaPro. This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time ... Read More »
In some sunroof-equipped vehicles, the front sunroof drains can become blocked with moist debris. If this happens, water could leak into the passenger compartment. Model code chart updated to include 2017 Golf Alltrack. Read More »
REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. Read More »
Update to model year applicability. Generator Replacement Charging System inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing. Read More »
This Document informs dealers that 2.0L TDI Gen 1, Gen 2 and Gen 3 Customer Vehicles are no longer eligible for the Pre-existing MIL-On Condition. Read More »
Volkswagen of America is requesting your cooperation in supplying us with technical information related to the repair process for vehicles on which the TDI Generation 3, 2. Read More »
Volkswagen of America is requesting your cooperation in supplying us with technical information related to the repair process for vehicles on which the TDI Generation 3, 2. Read More »
Update to MIB2 information to include 2015 and 2017 model year. On cars with a single USB port, the Apple authentication chip is in the USB port. Read More »
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Read More »
Repair direction to address fault code B201A that sets after replacement of the J794 infotainment module. Include model year 2017 for all models with MIB2 radios Read More »
Document informs meaning of service numbers to discribe issuse with If the customer is experiencing clutch related issues and the concern is found to be within the clutch components If the customer is experiencing manual gearbox ... Read More »
This document gives answers to frequently ask questions concerning the current owners and lessees of TDI vehicles affected by the emissions issue eligiblality options and issues. Read More »
Technical Bulletin (The camshaft adjuster control valve may stick causing camshaft position faults.): This document contains the fault codes needed to diagnose, and service the issue. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Technical Bulletin (Modular Infotainment System (MIB) Radio Switches to FM Station 87.7): The customer may complain that, intermittently, the FM radio station will have switched to the station 87.7 upon start up. Read More »
Service Information( Temporary Warranty Process and Parts Return Program): During the Market Introduction of the all-new Golf SportWagen, Volkswagen will collect all warranty repair information to ensure prompt analysis and resolution of ... Read More »
Tech Tips (Towing Eye/Hook): 2015 Make Year Golf applications have standard threads for the towing eye/hook. Previous model years were reverse threaded. Read More »
Technical Bulletin (Paint Defect - Water Migration Under the RAPGARD): Water migration under the RAPGARD? can be mistaken as a paint defect when in fact it is only moisture trapped in the clear coat of the paint. This document discusses. Read More »
Technical Bulletin (Modular Infotainment System (MIB) Radio Switches to FM Station 87.7): The customer may complain that, intermittently, the FM radio station will have switched to the station 87.7 upon start up. Read More »
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document refers to a pre check inspection on the quality of a vehicle such as - Inspecting vehicle for damage (to be completed within 48 hours of ... Read More »
Tech Tips: Car Net Equipped Vehicles-Vehicle Health Report Received by Customer Indicating a Concern, but Cannot Verify any Conditions or DTC?s to Facilitate Diagnosis Read More »
Tech Tips (Rear Bumper Cover ? Paint Peeling): There have been cases identified where the paint is chipping/peeling on the rear bumper cover. Read More »
Tech Tips: Vehicle Health Report Received by Customer Indicating a Concern, but Cannot Verify any Conditions or DTC?s to Facilitate Diagnosis Read More »
Service Information: This document refers to Temporary Warranty Process and Parts Return Program. Volkswagen collected all warranty repair information to ensure prompt analysis and resolution of any emerging ... Read More »
Technical Bulletin: This document concerns the sensitivity of the washer solvent level sensor (G33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint. Read More »
Technical Bulletin (Infotainment Worksheet): This bulletin provides instructions and information for completing and submitting the updated web version of the Infotainment Worksheet. Read More »
Technical Bulletin (By-Pack At Delivery): Components may be missing from the by-pack at delivery. Components missing from the by-pack should be claimed in one of two ways. Read More »
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Read More »
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Immobilizer Key/Key Remote Adaptation Test Plan. To adapt keys to a 2015-2016 Golf, GTI, Golf R or Sportwagen (MQB chassis,) it is necessary to complete the ?Adapt Immobilizer? test plan. Read More »
Technical Bulletin (Car-Net Unresponsive - Verizon Telematics Service Interruptions and Outages): This document informs how to service potiential Interruptions and Outages. Read More »
Technical Bulletin (Modular Infotainment System (MIB) Radio Switches to FM Station 87.7): The customer may complain that, intermittently, the FM radio station will have switched to the station 87.7 upon start up. Read More »
Technical Bulletin (Modular Infotainment System (MIB) Radio Switches to FM Station 87.7): The customer may complain that, intermittently, the FM radio station will have switched to the station 87.7 upon start up. Read More »
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Read More »
A how to guide for The camshaft adjuster control valve which may stick causing camshaft position faults. The document also has warranty examples over what service is covered can be found Read More »
Volkswagen of America is requesting your cooperation in supplying us with technical information related to the repair process for vehicles on which the TDI Generation 3, 2. Read More »
This document informs dealers of a sales preparation program for new, unused, unsold model year 2015 Volkswagen 2.0L TDI vehicles in dealer stock with less than 1,000 miles. Read More »
Reminder that ODIS Service V3.0.0 is now available for installation, and that it is mandatory on all diagnostic devices used on vehicles covered by the new vehicle warranty. With the release of V3.0.0. Installation DVDs are no longer used. Read More »
A reminder that ODIS Service V3.0.0 is now available for installation, and that it is mandatory on all diagnostic devices used on vehicles covered by the new vehicle warranty. Read More »
This document gives answers to frequently ask questions concerning the current owners and lessees of TDI vehicles affected by the emissions issue eligiblality options and issues. Read More »
Technical Bulletin: Listed in the table in this document are the time units used in the calculation of the Prepaid PDI (PPDI) payment through model year 2016. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Read More »
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, ... Read More »
Service Information( Temporary Warranty Process and Parts Return Program): During the Market Introduction of the all-new Golf SportWagen, Volkswagen will collect all warranty repair information to ensure prompt analysis and resolution of ... Read More »
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document refers to a pre check inspection on the quality of a vehicle such as - Inspecting vehicle for damage (to be completed within 48 hours of ... Read More »
VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming Update 23O9 ? 2.0L TDI ECM Software Update with 2.0L TDI engine): This document is a notice to dealships that an software update will be avaliable for vehicles with the 2.0L TDI engine. Read More »
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Read More »
Service Information: This document refers to Temporary Warranty Process and Parts Return Program. Volkswagen collected all warranty repair information to ensure prompt analysis and resolution of any emerging ... Read More »
Technical Bulletin (Infotainment Worksheet): This bulletin provides instructions and information for completing and submitting the updated web version of the Infotainment Worksheet. Read More »
Technical Bulletin (Components may be missing from the by-pack at delivery): Components missing from the by-pack should be claimed in one of two ways. Read More »
Technical Bulletin (By-Pack At Delivery): Components missing from the by-pack should be claimed in one of two ways. (Warranty or Transportation) Understanding when to claim one versus the other is very important. Read More »
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document informs on the service a vehicle shouold received when it has successfully reached a dealership. Read More »
This communication contains important information and SAGA claim entry requirements for the Volkswagen Carefree Maintenance Program for all Model Year 2015 and newer VW models with Gasoline Engines. Read More »
Information for additional diagnosis should the Driver Assistance Systems Front Camera not calibrate, complete calibration or set a limit exceeded fault. Read More »
This document informs dealers of revised FAQ's for the sales preparation program for new, unused, unsold model year 2015 Volkswagen 2.0L TDI vehicles in dealer stock with less than 1,000 miles. Read More »
This document informs dealers of revised FAQ's for the sales preparation program for new, unused, unsold model year 2015 Volkswagen 2.0L TDI vehicles in dealer stock with less than 1,000 miles. Read More »
This document informs dealers of the in-service date processing for new, unsold model year 2015 Volkswagen 2.0L TDI vehicles in dealer stock with over 1,000 miles. Read More »
Technical Bulletin: A notification that Components may be missing from the by-pack at delivery. It also informs that Components missing from the by-pack should be claimed in one of two ways. Read More »
Service Information (Temporary Warranty Process and Parts Return Program): During the Market Introduction of the all-new Golf SportWagen, Volkswagen collected all warranty repair information to ensure prompt analysis and resolution of ... Read More »
Tech Tips (Test Plan to Calibrate Adaptive Cruise Control Sensors Will Not Begin notice): Notification that If the test plan to calibrate the Adaptive Cruise Control Sensors will not begin, turn off the overhead lights in the shop. Read More »
Tech Tips (Rear Washer Jet Leaks / Drips After Use): For the A7 Golf with a rear washer nozzle leaking after use (Installed in the high mount brake lamp housing). An updated washer nozzle is now available. Read More »
Tech Tips (Rear Washer Jet Leaks / Drips After Use): For the A7 Golf/GTI with a rear washer nozzle leaking after use (Installed in the high mount brake lamp housing). An updated washer nozzle is now available. Read More »
Statement referring to TB 2043893 removed. To include additional models and model year applicability. A.C. Compressor Replacement, GFF Required Regardless of Concern and Flush Requirement Read More »
Diagnostic information in a more concise form to address the specific concern of loss of air flow from the vents. Update on 9/26/2019 to denote tech bulletins that will further assist and update model and model year applicability. Read More »
Diagnostic information in a more concise form to address the specific concern of loss of air flow from the vents. Updated to denote tech bulletins that will further assist. Read More »
UPDATE PRODUCTION SOLUTION DATE AND ADD A STATEMENT ABOUT REQUIRING THE SUBMITTAL OF A GUIDED FAULT FINDING AIR CONDITIONING PERFORMANCE TEST FOR WARRANTY PURPOSES BEFORE REPLACING COMPONENTS. Read More »
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, ... Read More »
Technical Bulletin 9Air Conditioning Does Not Cool and or Compressor is Noisy): The condition may be caused by a faulty A/C compressor regulator valve N280 (Sanden). Read More »
Technical Bulletin (Air Conditioning Does Not Cool and or Compressor is Noisy): The condition may be caused by a faulty A/C compressor regulator valve (N280). Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or ... Read More »
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is ... Read More »
Tech Tips (AC Compressor Replacement, Refrigerant Circuit Flushing Requirement): This document informs when replacing the Air Conditioning compressor it is necessary to flush the entire system to remove all the PAG oil. Read More »
Inspect front window regulator assembly for any loose components. Verify regulator cables are properly secured and window regulator mounting nuts are properly torqued. Read More »
All Volkswagen engines are filled to a specific volume before leaving the factory. This level may vary depending on the testing conditions, but will always be within the allowable specification for engine protection. Read More »
