Technical Service Bulletins (TSBs) for the 2010 Golf are official communications between Volkswagen & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
VOLKSWAGEN: SOME VEHICLES MAY EXHIBIT POOR POWER STEERING ASSISTANCE. DTCS MAY BE STORED IN POWER STEERING CONTROL MODULE J500. ALSOINCLUDED MODEL JETTA SPORTWAGEN MODEL YEAR 2010-2012. *JS UPDATED 12/4/13. Read More »
VOLKSWAGEN: WHEN THE WARNING LIGHTS ARE USED FOR AN EXTENDED TIME THERE MAY BE MULTIPLE PROBLEMS DUE TO A SOFTWARE CONCERN: WARNING LIGHT SYMBOL STAYS ON AFTER THEY ARE TURNED OFF. Read More »
VOLKSWAGEN: ACTIVATED CHARCOAL FILTER SYSTEM, SOLENOID VALVE AND PERFORMING GFF FUNCTION TEST A VACUUM CHECK ON CANISTER PURGE VALVE N80 ARE ESSENTIAL TO DIAGNOSE PROPER OPERATION. MODEL 2009-14 ALL BUT ROUTAN. Read More »
VOLKSWAGEN: ALL MODELS EXPERIENCE THE TIMING CHAIN SLIPPING, RATTLING NOISES OF THE ENGINE AFTER STARTING, AND ENGINE FAILS TO START. 2008-13 ALL MODELS. *PE Read More »
VOLKSWAGEN: DURING COLD WEATHER, ENGINE FAILS TO START, AFTER STANDING, AND IF MOISTURE, FROM INTAKE AIR, CONDENSES, WOULD FREEZE AND BLOCK INTAKE AIR SYSTEM, IN CHARGE AIR COOLER. *PE Read More »
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES ARE EXPERIENCING ENGINE NOT STARTING, MAKING A RATTLING NOISE WHEN ENGINE HAS STARTED, TIMING CHAIN KEEPS SLIPPING AND EXHAUST LIGHT COMES ON. *PE Read More »
VOLKSWAGEN: MALFUNCTION LIGHT IS ON AND THERE IS NOISE WITH THE ENGINE RUNNING ROUGH. MULTIPLE TROUBLE CODES POSSIBLY STORED. ALL MODELS 2008-2012. *RM Read More »
VOLKSWAGEN: MIL ON; NO START OR ROUGH RUNNING (DTC P0087-RAIL FUEL PRESSURE TOO LOW). CONTAMINATED OR INCORRECT FUEL CAN CAUSE PERFORMANCE, DRIVABILITY, AND/OR FUEL DELIVERY PROBLEMS. *PE Read More »
TO UPDATE GOLF (EXCHANGE PARTS) TIME UNITS DUE TO SAGA/ELSA UPDATES 6/13/16. MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be accompanied with Fault P2463 DPF Soot Accumulation. Read More »
VOLKSWAGEN: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TO ENSURE EMISSIONS OF TAILPIPE IS OPTIMIZED AND EFFICIENTLY OPERATING, THE ENGINE MANAGEMENT SOFTWARE WAS IMPROVE DUE TO AN UPDATED ECM ... Read More »
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS. REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS Read More »
VOLKSWAGEN: THERE IS A WARRANTY EXTENSION ON HARD START CONDITIONS FOR CUSTOMERS WHO HAD AN EARLIER CAMPAIGN ADDRESSED ON THEIR VEHICLES. *RM Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
TO UPDATE GOLF (EXCHANGE PARTS) TIME UNITS DUE TO SAGA/ELSA UPDATES 6/13/16. MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be accompanied with Fault P2463 DPF Soot Accumulation. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
VOLKSWAGEN: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TO ENSURE EMISSIONS OF TAILPIPE IS OPTIMIZED AND EFFICIENTLY OPERATING, THE ENGINE MANAGEMENT SOFTWARE WAS IMPROVE DUE TO AN UPDATED ECM ... Read More »
VOLKSWAGEN: VEHICLE IS ROUGH RUNNING, FAILS TO START AND MALFUNCTION INDICATOR LAMP (MIL) BE ON AND AFTER CHECKING COMPONENTS AND NO ROOT CAUSE IS FOUND, NEED TO CHECK HIGH PRESSURE FUEL PUMP FOR METALLIC PARTICLES. Read More »
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE Read More »
VOLKSWAGEN: VEHICLE IS ROUGH RUNNING, FAILS TO START AND MALFUNCTION INDICATOR LAMP (MIL) BE ON AND AFTER CHECKING COMPONENTS AND NO ROOT CAUSE IS FOUND, NEED TO CHECK HIGH PRESSURE FUEL PUMP FOR METALLIC PARTICLES. Read More »
VOLKSWAGEN: MIL ON; DTC P0087 AND/OR P0192 STORED IN ECM FAULT MEMORY. ONE OR MORE OF THE FOLLOWING CODES MAY BE STORED IN THE ECM FAULT MEMORY-LOW FUEL RAIL PRESSURE DETECTED; FUEL RAIL PRESSURE SENSOR CIRCUIT LOW. Read More »
VOLKSWAGEN: MIL ON; NO START OR ROUGH RUNNING (DTC P0087-RAIL FUEL PRESSURE TOO LOW). CONTAMINATED OR INCORRECT FUEL CAN CAUSE PERFORMANCE, DRIVABILITY, AND/OR FUEL DELIVERY PROBLEMS. *PE Read More »
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE Read More »
VOLKSWAGEN: DUE TO A LOOSE OR UNFASTENED CONNECTOR FOR PASSENGER AIR BAG, THE AIRBAG WARNING LAMP MAY ILLUMINATE IN INSTRUMENT PANEL. MODELS 2010-2013 GOLF, GTI, JETTA SPORTWAGEN, JETTA SEDAN. Read More »
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY). FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. Read More »
VOLKSWAGEN: THERE IS A WARRANTY EXTENSION ON HARD START CONDITIONS FOR CUSTOMERS WHO HAD AN EARLIER CAMPAIGN ADDRESSED ON THEIR VEHICLES. *RM Read More »
VOLKSWAGEN: IMPROVED ECM SOFTWARE CALIBRATION TO STABILIZE 02 SENSOR DIAGNOSIS. 02 SENSOR DIAGNOSIS TOO SENSITIVE AND CONTAMINATION OF THE 02 SENSOR CAUSING MIL ON WITH DTCS P0136, P0139, P2271, P013B AND/OR P320C. Read More »
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. Read More »
VOLKSWAGEN: AIRBAG WARNING LIGHT WAS ILLUMINATED INDICATING A FRONT SIDE AIRBAG PRESSURE SENSOR INTERRUPTION/SHORT TO B+. THE DTCS B101715 AND B103615. *JS Read More »
VOLKSWAGEN: AIRBAG WARNING LAMP ILLUMINATED IN INSTRUMENT CLUSTER, DTC B101614 STORED IN AIRBAG CONTROL MODULE. AIRBAG LAM IN INSTRUMENT CLUSTER MAY ILLUMINATE DUE TO UNFASTENED CONNECTOR FOR PASSENGER AIRBAG WARNING LAMP. Read More »
VOLKSWAGEN: DUE TO A LOOSE OR UNFASTENED CONNECTOR FOR PASSENGER AIR BAG, THE AIRBAG WARNING LAMP MAY ILLUMINATE IN INSTRUMENT PANEL. MODELS 2010-2013 GOLF, GTI, JETTA SPORTWAGEN, JETTA SEDAN. Read More »
VOLKSWAGEN: AIRBAG WARNING LAMP ILLUMINATED IN INSTRUMENT CLUSTER, DTC B101614 STORED IN AIRBAG CONTROL MODULE. AIRBAG LAM IN INSTRUMENT CLUSTER MAY ILLUMINATE DUE TO UNFASTENED CONNECTOR FOR PASSENGER AIRBAG WARNING LAMP. Read More »
TO UPDATE CLAIM PROCESS STATEMENT. Rocker Panel - Front Fender ? Corrosion Corrosion on contact surfaces of the front fender to rocker panel (side member). Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL ... Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Read More »
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL ... Read More »
VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY). FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. Read More »
