This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
I was driving on the interstate at 70 mph when the lower control arm came apart from my ball joint on the driver side. My wife and I spun uncontrollably with sparks shooting everywhere. We were able to come to a stop once the vehicle dug itself into the dirt of the median. It was such an embarrassment for myself as I have held the name "Toyota" to the highest standard before all other auto maker. After the incident, I am now doing research and there had been a similar recall in 2005. I moved to a different state during this time and did not receive or know of a recall notice. I service all of my vehicles myself and very seldom take them into the dealership.
The contact owns a 2002 Toyota Tundra. The contact stated while driving approximately 65 mph, the front driver's side strut sheared off. The vehicle was taken to an independent mechanic. The manufacturer had not been made aware of the problem. The VIN was not available.the approximate mileage at the time of failure was 118,000.
The contact owns a 2002 Toyota Tundra. The contact stated that while driving 5 mph, the vehicle suddenly dropped to the ground. The vehicle was towed to dealer where it was stated that the lower ball joint was fractured and the cv joint was damaged. The manufacturer was alerted of the failure and stated that the contact's VIN was not included in NHTSA campaign number: 05V225000 (suspension). The driver and passenger suffered mild back pain from the incident. The vehicle was repaired. The failure mileage was 53,000.
The contact owns a 2002 Toyota Tundra. The contact stated that while driving approximately 15 mph, the front driver's side of the vehicle leaned over the front driver's side tire. The vehicle was towed to the contacts residence, where the contact inspected the vehicle and noticed that the front driver's side lower ball joint nut was sheered. The vehicle was repaired. The manufacturer was made aware of the failure. The vehicle was previously included in and repaired under NHTSA campaign number: 05V225000 (suspension). The approximate failure mileage was 135,000.
The contact owns a 2002 Toyota Tundra. The contact stated that while driving various speeds, the front passenger's side tire became detached unexpectedly from the vehicle. There was a loss of steering control and the vehicle began to skid 35-40 feet before proceeding to stop. The vehicle then collapsed to the ground. The vehicle was towed to an independent mechanic and an authorized dealer, in which both informed the contact that the brake lines and the frame was corroded. In addition, the front passenger's side ball joint was defective. The contact referenced NHTSA campaign id numbers: 09V444000 (structure) and 05V225000 (suspension) however, the vehicle was not included in either. The manufacturer was notified of the failure. The approximate failure mileage was 250,000. The VIN was unavailable.
- Monroe, CT, USA
Search CarComplaints.com for these popular complaint phrases...
The contact owns a 2002 Toyota Tundra. The contact stated that while driving 65 mph, a loud noise dragging noise was heard. After inspecting the vehicle, the contact noticed that the fuel tank was dragging on the ground. The vehicle was towed to a dealer and diagnosed that the universal joint had become fractured and as result, the drive shaft and fuel tank were dropped. The contact decided to take the vehicle to a second dealer for and the technician stated that the frame was cracked. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure and current mileage was 170,000.
Vehicle inspected by dealer leak in rack and pinion. Very early at 72,500 miles. Loose lower ball joints. Lower ball joints replaced under recall 10/11/2005 at 28,000 miles. If they are going bad again at 72,500 miles, there is a major problem.
The contact owns a 2002 Toyota Tundra. The contact stated that the vehicle was taken to an authorized dealer for a repair associated with NHTSA campaign id number 09V444000 (structure: Frame and members: Underbody shields). While the technician performed the repair, he noticed both stabilizer links and the parking brake rear wheel mechanism were fractured as a result of excessive rust corrosion. In addition, the rack and pinion was corroded. The vehicle had not been repaired. The manufacturer was not notified of the problem. The approximate failure mileage was 74,000. Updated 4/3/12 the consumer stated the front stabilizer links broke off, due to them being rusted. The driver side emergency brake seized. The steering shaft U-joint was badly rusted. Updated 05/17/12
The contact owns a 2002 Toyota Tundra. The contact stated that while driving 50 mph, the front passenger wheel detached front the vehicle. The vehicle was towed to a local mechanic who diagnosed that the upper and lower bolt joints separated and as a result, the bolt joints and steering assembly needed to be replaced. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure and the current mileage was 240,000.
The contact owns a 2002 Toyota Tundra. The contact stated that while driving 30 mph, the front driver side bolt joint broke off. The vehicle was taken to a dealer who verified the failure and stated that it needed to be replaced. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure and the current mileage was 170,000.
I have owned a 2002 Toyota Tundra 4X4 since 2002. In July of this year I experienced a near wreck when I hydroplaned and was unable to regain control. When I tried to gain control I felt as if the truck was going to roll and I was forced to drive off the highway. Although I did not collide with anything I did have some damage to the rear axel with noises coming from it. The next day I took the truck to a local garage to inspect the vehicle and they found nothing. Not stopping there I crawled under and I found a broken link bolt on the right front sway bar. Upon inspection of the link bolt I found that the link had rusted to less than half of it's original diameter which lead to its failure. Taking this issue up with a Toyota dealer I had them repair both sides of the sway bar links. When the left link was removed it too was found to be broken. The design of the links are such that water and road salt can settle in the bushings causing them to rust. The broken links are likely why I was unable to regain control of my vehicle and caused damage to the rear end gears and axle. I have had this vehicle in for safety inspections on numerous occasions and nothing was found to be wrong. If professional technicians can't detect this problem than how can an owner and how can these owner's feel safe with these undetectable problems. I have saved these parts and feel that they are worthy of closer inspections.
Upper ball joints, rear springs, brakes front & back, and manual transmission, and O2 sensors too! this is what I have been repairing and was not aware of all of the recalls on my truck! so far I have just repairing it until today, after hearing about the newest recall! I will be calling my dealer Monday....
Yesterday, had $1300 work done on my 2002 Toyota Tundra. Mechanic advised me that my springs need replacement as they are completely rusted. This evening, susan wornick of channel 5 investigative team, did a report on Toyota Tundra rusting out. Specifically springs and frame. Ms. Wornick informed any owners of Tundra (2000-2001 and possibly 2002) to file complaint with NHTSA. Hence this email.
The drivers side front suspension ball joints gave way as I was driving at 75mph on interstate 40 West in Texas at mile marker 14. The entire wheel, break, and axle assembly detatched at hi speed. The break line was severed. The assembly folded under the truck and I skidded on the wheel with little control until I could maneuver off of the interstate and maintain an upright position with the vehicle. The twisted tie rod kept the tire and wheel assembly from completely separating from the vehicle. The weather was light snow with a temperature of about 34 degrees. Time was appx 9.50 am. The truck was repaired without comment by street Toyota of amarillo, Texas at a cost of appx. $ 2,200. The dealer said there was an inordinate amount of wear on the front end steering components. The truck is in good condition with a good documented service record. The truck had been steering "loosely" and I had a mechanic examine the steering the previous week. He said it looked and drove ok, but he couldn't really tell. The truck has never been involoved in an accident or insurance claim.
While driving 70 mph, the transmission stalled. The vehicle was towed. Dealership repaired the problem. The driver heard and felt a loud bump in the rear of the vehicle. The engine continued to run but the vehicle would not move when the consumer applied the gas pedal. There was rear end grease leaking from the right side rear showing on the wheel and tire. The mechanic stated that there was no connection between the rear brake, rear end leaking grease, the drive shaft and the failure of the transmission. The brakes were a major problem, the cruise control never kept speed or smooth, the left lower front ball joint had a catastrophic failure that caused the entire wheel, brake line and all essential components on the left side of the vehicle to come loose. The consumer requested reimbursement. The brakes were a problem on the vehicle, and the drums were replaced.
While driving 5 mph driver's front side collapsed. Vehicle was towed to a dealer for inspection, and mechanic determined that both upper and lower ball joints snapped, and needed to be replaced.
While driving 60 mph the ball joints failed. It came completely from under the truck. There was no warning. There was no accidents. Consumer contacted the dealer. There were no recalls.
While driving at 65 mph, the vehicle suddenly jerked. The consumer could not control the vehicle while crossing into oncoming traffic lanes and coming to a stop on the shoulder. The consumer noticed that the lower ball joint had separated and the tire (wheel assembly) had folded under the passenger side of the vehicle.
I have a 2002 Toyota Tundra with 39,000 miles on it. I was going 15-20 mph and aproaching a on ramp to the highway when my front drivers side ball joint snapped. I had my 4 month old son in the car with me. Luckily I was able to stop without getting into a accident but wonder what would have happened if we were on the highway. Toyota said I must have hit something in order for it to fail and refused to contact the NHTSA and refused to cover the expense of having it fixed. $1900.
While driving 25 mph without hitting anything, the front passenger tire collapsed under the vehicle without warning. The consumer had the vehicle towed to the dealership. The dealership replaced the ball joints but blamed the driver hitting something to cause them to break. Pe04040_cat
A D V E R T I S E M E N T S
- Ratcliff, AR, USA