Technical Service Bulletins (TSBs) for the 2007 Tacoma are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
TOYOTA: STEERING INTERMEDIATE SHAFT RATTLE NOISE. SOME VEHICLES MAY EXHIBIT STEERING RATTLE NOISE WHEN DRIVEN OVER ROUGH ROAD SURFACES. ALSO INCLUDED 2WD TACOMA PRERUNNER. MODEL YEARS 2005-2012. Read More »
Some vehicles may exhibit a vibration felt in the seat, floorboard, and/or steering wheel around 15-25 MPH caused by a second order driveline vibration. Use the following procedure to address this condition. Read More »
TOYOTA: SOME TOYOTA TACOMA VEHICLES MANUFACTURED BETWEEN 2005 AND 2011 MAY HAVE A STEERING RATTLE NOISE WHEN DRIVING ON ROUGH SURFACES. *RM Read More »
Region Email: Toyota has received a number of reports regarding Propeller Shaft Universal Joints on certain 2005 ? 2011 model year Tacoma vehicles. Read More »
TOYOTA: SOME TOYOTA TACOMA VEHICLES MANUFACTURED BETWEEN 2005 AND 2011 MAY HAVE A STEERING RATTLE NOISE WHEN DRIVING ON ROUGH SURFACES. *RM Read More »
Region Email: Toyota has received a number of reports regarding Propeller Shaft Universal Joints on certain 2005 ? 2011 model year Tacoma vehicles. Read More »
Some 2005 ? 2014 model year Tacoma vehicles equipped with automatic transmission may exhibit a vibration felt in the seat, floorboard, and steering wheel between 15 ? 25 mph caused by a second order drivetrain vibration under acceleration. Read More »
Some vehicles may exhibit a vibration felt in the seat, floorboard, and/or steering wheel around 15-25 mph caused by a second order driveline vibration. Use the following procedure to address the condition. Read More »
Some vehicles may exhibit a vibration felt in the seat, floorboard, and/or steering wheel around 15-25 MPH caused by a second order driveline vibration. Use the following procedure to address this condition. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Read More »
RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
Dealer Daily Message: UPDATED Dealer Daily - DO NOT USE BRAKE LINES WITH WHITE MARK Warranty Enhancement Programs ZH6 - Certain 2005 ? 2010 Model Year Tacoma Vehicles Extension of Warranty Coverage for Frame Corrosion. Read More »
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Dealer Daily Message: Warranty Enhancement Programs ZH6 - Certain 2005 ? 2010 Model Year Tacoma Vehicles. Extension of Warranty Coverage for Frame Corrosion. 2005-2008 Tacoma Frame Repair ? Brake Line Update. Read More »
TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Read More »
A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. Read More »
RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Read More »
RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Read More »
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
Dealer Package: 09/14/2018 The note in the ?Parts Ordering Process? section to reference POL17-16 to determine the applicable U-joint kit part # has been removed. T-SB-0302-17 has been updated with this information. Read More »
TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Read More »
TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website. Read More »
TSB: Some 2012 - 2014 model year Tacoma vehicles equipped with 1GR-FE engines may exhibit spark knock (detonation) during light acceleration and/or uphill in hot weather (80?F or higher). Read More »
This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. Read More »
These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. Read More »
TSB: Some 2005 ? 2023 model year Tacoma vehicles equipped with a manual transmission may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0186-12. * Applicability has been updated to include 2018 and 2019 model year Tacoma vehicles. * The entire bulletin has been updated. Read More »
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
Customer Support Program: Toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. Read More »
TSB: REVISION NOTICE June 27, 2018 Rev2: ? The Production Change Information and the Parts Information sections have been updated. March 14, 2018 Rev1: ? The Production Change Information and Repair Procedure sections have been updated. Read More »
Warranty Policy Bulletin: Toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. Read More »
TSB: REVISION NOTICE June 8, 2018 Rev2: ? Applicability has been updated to exclude 2016 ? 2017 model year Tacoma vehicles. ? The Repair Procedure section has been updated. Read More »
TSB: REVISION NOTICE February 21, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2017 model year Tacoma vehicles. ? The Parts Information and Repair Procedure sections have been updated. Read More »
Dealer Daily Message: Customer Support Program ZH2 Certain 2005 ? 2011 Model Year Tacoma Coverage for Propeller Shaft Universal Joints ? If the ZH2 condition is present for an extended period it can lead to damage of the propeller shaft. Read More »
Warranty Policy Bulletin: Toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. Read More »
"DEALER LETTER: SAFETY RECALL COMPLETION IS IMPORTANT NOT ONLY IN SATISFYING GOVERNMENT REQUIREMENTS, BUT ALSO IS AN INTEGRAL PART OF OUR COMMITMENT TO MEET CUSTOMER EXPECTATIONS OF TOYOTA PRODUCTS. Read More »
TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
TSB: Some 2004 - 2015 model year Tacoma, FJ Cruiser, and 4Runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2WD that goes away when operated in 4WD. Read More »
TSB: Some 2005 - 2013 model year Tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 - 60 mph (80 - 97 km/h). Read More »
TSB: Some 2005 - 2013 model year Tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 - 60 mph (80 - 97 km/h). Read More »
REGION LETTER: TOYOTA WILL BE SENDING SAFETY RECALL FOLLOW-UP NOTICES TO REMIND OWNERS WHOSE VEHICLES HAVE NOT YET HAD CAMPAIGN REPAIRS COMPLETED. PLEASE NOTE THE FOLLOWING INFORMATION FOR REGIONAL AND PD ASSOCIATES. Read More »
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Read More »
TSB: Some 2WD 2005 - 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a "bump-from-behind" sensation just before a stop or when accelerating from a stop. Read More »
TSB: Some 4WD 2005 - 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a "bump-from-behind" sensation just before a stop or when accelerating from a stop. Read More »
TSB: Some 2005 ? 2014 model year Tacoma vehicles equipped with 1GR-FE engine (PreRunner and 4WD) and automatic or 6-speed manual transmission may exhibit a vibration felt in the seat, floorboard, and steering wheel between 15 ? 25 mph ... Read More »
TSB: Some 4WD 2005 ? 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. Read More »
TSB: Some 2WD 2005 ? 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. Read More »
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Read More »
Some 2005 ? 2013 model year Tacoma vehicles equipped with a 5-speed manual transmission may exhibit a slipping feeling in all forward gears and reverse. Read More »
Some 2005 ? 2013 model year Tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 ? 60 mph (80 ? 97 km/h). Read More »
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints. Read More »
Some 2WD 2005 ? 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. Read More »
TSB: Some 2005 - 2014 model year Tacoma vehicles may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released. Read More »
Some 2005 ? 2013 model year Tacoma vehicles equipped with a 5-speed manual transmission may exhibit a slipping feeling in all forward gears and reverse. Read More »
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
TSB: Some 2005 - 2014 model year Tacoma vehicles may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released. Read More »
Some 2005 ? 2013 model year Tacoma vehicles equipped with a 5-speed manual transmission may exhibit a slipping feeling in all forward gears and reverse. Read More »
TSB: Some 2005 - 2013 model year Tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 - 60 mph (80 - 97 km/h). Read More »
TSB: Some 2005 - 2013 model year Tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 - 60 mph (80 - 97 km/h). Read More »
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Read More »
TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions. Read More »
TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Read More »
TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions. Read More »
TSB: Some 2WD 2005 - 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a "bump-from-behind" sensation just before a stop or when accelerating from a stop. Read More »
TSB: Some 4WD 2005 - 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a "bump-from-behind" sensation just before a stop or when accelerating from a stop. Read More »
TOYOTA: JUST BEFORE COMING TO A STOP OR ACCELERATING FROM A STOP WOULD EXPERIENCE A BUMP FROM BEHIND SENSATION OR HEAR A THUNKING OR CLUNKING NOISE FROM REAR OF VEHICLE. Read More »
TOYOTA: A SENSATION OF A BUMP FROM BEHIND OR EXHIBITING A CLUNK OR THUNK NOISE COMING FROM REAR JUST AS ACCELERATING OR COMING TO A STOP. MODEL 2005-2013 TACOMA. *PE Read More »
TOYOTA: ON SOME VEHICLES, WITH 5 SPEED AUTOMATIC TRANSMISSION, CAN HEAR A WHINNYING NOISE COMING FROM THE REAR DIFFERENTIAL. MODEL 2005-2013 TACOMA. *PE Read More »
Some 4WD 2005 ? 2012 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. Read More »
TOYOTA: AUTOMATIC TRANSMISSION/TRANSAXLE. SOME VEHICLES MAY EXHIBIT A MIL ON CONDITION WITH DTC P0705 (TRANSMISSION RANGE SENSOR CIRCUIT MALFUNCTION (PRNDL INPUT)) STORED. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Read More »
Warranty Policy Bulletin: Toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. Read More »
TSB: REVISION NOTICE March 14, 2018 Rev1: ? The Production Change Information and Repair Procedure sections have been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: Some 2004 - 2015 model year Tacoma, FJ Cruiser, and 4Runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2WD that goes away when operated in 4WD. Read More »
TSB: Some 2004 - 2015 model year Tacoma, FJ Cruiser, and 4Runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2WD that goes away when operated in 4WD. Read More »
Region Letter: Toyota has received a number of reports regarding Propeller Shaft Universal Joints on certain 2005 ? 2011 model year Tacoma vehicles. Read More »
Dealer Letter: Toyota has received a number of reports regarding Propeller Shaft Universal Joints on certain 2005 ? 2011 model year Tacoma vehicles. Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. Read More »
TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Read More »
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off. Read More »
TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE HEADLAMP ASSEMBLY INNER LENS DISTORTION/BUBBLING, AND POSSIBLE CRACKED OR SEPARATED INNER LENS, HAVE AN EXTENDED WARRANTY COVERAGE. MODEL 2005-2011 TACOMA. Read More »
Region Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Headlamp Assembly on 2005-2011 model year Tacoma vehicles. Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE HEADLAMP ASSEMBLY INNER LENS DISTORTION/BUBBLING, AND POSSIBLE CRACKED OR SEPARATED INNER LENS, HAVE AN EXTENDED WARRANTY COVERAGE. MODEL 2005-2011 TACOMA. Read More »
Dealer Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Headlamp Assembly on 2005-2011 model year Tacoma vehicles. Read More »
Dealer Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Headlamp Assembly on 2005-2011 model year Tacoma vehicles. Read More »
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing. Read More »
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. Read More »
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers ... Read More »
Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. Read More »
"DEALER LETTER: SAFETY RECALL COMPLETION IS IMPORTANT NOT ONLY IN SATISFYING GOVERNMENT REQUIREMENTS, BUT ALSO IS AN INTEGRAL PART OF OUR COMMITMENT TO MEET CUSTOMER EXPECTATIONS OF TOYOTA PRODUCTS. Read More »
REGION LETTER: TOYOTA WILL BE SENDING SAFETY RECALL FOLLOW-UP NOTICES TO REMIND OWNERS WHOSE VEHICLES HAVE NOT YET HAD CAMPAIGN REPAIRS COMPLETED. PLEASE NOTE THE FOLLOWING INFORMATION FOR REGIONAL AND PD ASSOCIATES. Read More »
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
Dealer Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
Dealer Letter: Safety Recall completion is important not only in satisfying government requirements, but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
Dealer Letter: Safety Recall completion is important not only in satisfying government requirements, but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
Dealer Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
Technical Instructions: Updated 06/12/19 TECHNICAL INSTRUCTIONS FOR WARRANTY ENHANCEMENT PROGRAM ZH6 * CERTAIN 2005 THROUGH 2010 MODEL YEAR TACOMA * FRAME REPLACEMENT Read More »
Dealer Daily Message: Limited Service Campaign H0F ? Remedy Notice Certain 2005 ? 2010 Model Year Tacoma Certain 2007 ? 2008 Model Year Tundra Certain 2005 ? 2008 Model Year Sequoia Frame Corrosion Resistant Compound (CRC) Application ? ... Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Dealer Package: Added important note in the Parts section. Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 ... Read More »
Dealer Package: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Dealer Package: Modified warranty claim submission flowchart. See Appendix A. In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for ... Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Dealer Daily Message: Frame Warranty Claim Submission The information below should be referenced to ensure correct warranty claim submissions for frame replacement or spray campaigns (ZH6-9 and H0F). Read More »
Dealer Package: June 25, 2018 Added warranty claim submission flowchart. See Appendix A. Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following ... Read More »
Dealer Daily Message: Frame Programs. Extension of Warranty Coverage for Frame Corrosion/Frame Replacement. Frame Ordering/Repair/Administration Updates Mis-Built. For frames that are suspected to have been mis-built, dealers should: 1. Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Dealer Letter: March 2, 2018. Rental sublet period added for use during repair. ? Primary Coverage expiration date changed. ? Ancillary parts coverage section added. Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Technical Instructions: Update 3-1-18 - Frame part numbers corrected. TECHNICAL INSTRUCTIONS FOR WARRANTY ENHANCEMENT PROGRAM ZH6. CERTAIN 2005 THROUGH 2010 MODEL YEAR TACOMA. FRAME REPLACEMENT. Read More »
Dealer Daily Message: Warranty Enhancement Programs ZH6 - Certain 2005 ? 2010 Model Year Tacoma Vehicles. Extension of Warranty Coverage for Frame Corrosion. 2005-2008 Tacoma Frame Repair ? Brake Line Update. Read More »
Technical Instructions: Technical Instructions for Warranty Enhancement Program ZH6. Certain 2005 through 2010 Model Year Tacoma. UPDATED 2-15-2018. Frame Replacement. Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Region Email: ? 2007-2008 (ZH7) Tundra Frame Replacement and CRC Application is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia ... Read More »
Dealer Email: ? 2007-2008 (ZH7) Tundra Frame Replacement and CRC Application is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia ... Read More »
Region Letter: October 19,2017 Tundra Frame Replacement (ZH7) and CRC Application is now available. ? Added additional op codes for Tundra to cover dealer costs of maintaining vehicles while waiting for frames, if applicable. Read More »
Dealer Letter: October 19, 2018 Tundra (ZH7) Frame Replacement and CRC Application is now available. Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for ... Read More »
Region Email: ? 2005-2007 (ZH8) Sequoia Frame Replacement and CRC Application is now available. ? 2008 (ZH9) Sequoia Frame Replacement and CRC Application is now available. Read More »
Dealer Email: ? 2005-2007 (ZH8) Sequoia Frame Replacement and CRC Application is now available. ? 2008 (ZH9) Sequoia Frame Replacement and CRC Application is now available. Read More »
Region Letter: October 12,2017 Sequoia Frame Replacement (ZH8 and ZH9) is now available. ? Added additional op codes for Sequoia to cover dealer costs of maintaining vehicles while waiting for frames, if applicable. Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Dealer Letter: The attached Dealer Letter has been updated. September 29, 2017 Rental Invoice requirement has been added. ? Estimated Launch Timing has been updated for Tundra and Sequoia models. Read More »
Dealer Letter: September 7, 2017 Tacoma UIO (Units in Operation) has been updated. Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following ... Read More »
Dealer Letter: Extension of Warranty Coverage for Frame Corrosion. Technician Training Requirements have been updated to reflect amendments to the post-repair sign off and validation procedure. Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Region Email: 2005-2010 Tacoma Frame Replacement is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia vehicles regarding frame ... Read More »
Region Letter: 2005-2010 Tacoma Frame Replacement is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia vehicles regarding frame ... Read More »
Dealer Letter: 2005-2010 Tacoma Frame Replacement is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia vehicles regarding frame ... Read More »
Dealer Letter: Frame Corrosion Resistant Compound (CRC) Application. As with prior CRC campaigns, the H0F Corrosion Resistant Compound (CRC) campaign is subject to state and local air emissions and permitting requirements. Read More »
Dealer Letter: Frame Corrosion Resistant Compound (CRC) Application. As part of the H0F Corrosion Resistant Compound (CRC) program, your dealership will receive a new set of the Vaupel HSDR 3300 spray guns to replace the old set of spray ... Read More »
Region Email: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Region Letter: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Dealer Email: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Dealer Letter: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Region Letter Email: On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia vehicles regarding frame corrosion was approved. Read More »
Dealer Packet Email: On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia vehicles regarding frame corrosion was approved. Read More »
Dealer Package: On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma vehicles regarding frame corrosion was approved. Read More »
Dealer Daily: ? Toyota has received reports that certain 2005 through 2008 model year Tacoma vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion to the ... Read More »
Dealer Letter: The dealer letter has been updated to include details of the frame registration and credit program that has been added to Limited Service Campaigns E0D and ESD. Read More »
Dealer Daily: ? Toyota has received reports that certain 2005 through 2008 model year Tacoma vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion to the ... Read More »
Dealer Daily: The dealer letter has been updated to include details of the frame registration and credit program that has been added to Limited Service Campaigns E0D and ESD. Read More »
"DEALER LETTER: FRAME REPLACEMENT CUSTOMER VEHICLES THAT QUALIFY FOR FRAME REPLACEMENT UNDER E0D/ESD MUST HAVE THEIR VEHICLE INSPECTED ON OR BEFORE MARCH 31, 2016. Read More »
Dealer Letter: FRAME REPLACEMENT Customer vehicles that qualify for frame replacement under E0D/ESD must have their vehicle inspected on or before March 31, 2016. Read More »
"QUICK REFERENCE GUIDE: FRAME REPLACEMENT ALL FRAMES MUST BE INSPECTED ON OR BEFORE MARCH 31, 2016 IN ORDER TO QUALIFY FOR FRAME REPLACEMENT. VEHICLES INSPECTED AFTER THIS DATE WILL NOT BE COVERED UNDER THE LIMITED SERVICE CAMPAIGN. Read More »
Quick Reference Guide: Frame Replacement All frames must be inspected on or before March 31, 2016 in order to qualify for frame replacement. Vehicles inspected after this date will not be covered under the Limited Service Campaign. Read More »
"DEALER LETTER: FRAME REPLACEMENT CUSTOMER VEHICLES THAT QUALIFY FOR FRAME REPLACEMENT UNDER E0D/ESD MUST HAVE THEIR VEHICLE INSPECTED ON OR BEFORE MARCH 31, 2016. Read More »
Dealer Letter: FRAME REPLACEMENT Customer vehicles that qualify for frame replacement under E0D/ESD must have their vehicle inspected on or before March 31, 2016. Read More »
RL: TOYOTA WILL BE SENDING LIMITED SERVICE CAMPAIGN FOLLOW-UP NOTICES TO REMIND OWNERS WHOSE VEHICLES HAVE NOT YET HAD CAMPAIGN REPAIRS COMPLETED. Read More »
DL: LIMITED SERVICE CAMPAIGN COMPLETION IS IMPORTANT AND IS AN INTEGRAL PART OF OUR COMMITMENT TO MEET CUSTOMER EXPECTATIONS OF TOYOTA PRODUCTS. Read More »
RL: Toyota will be sending Limited Service Campaign Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
EC: Rental vehicle opcodes have been updated for Limited Service Campaigns E0D and ESD. Refer to the updated dealer letter that has been posted to TIS. Read More »
Region Letter: In 2014, Toyota announced and rolled out a Limited Service Campaign (LSC E0D) for certain 2005-2008 model year Toyota Tacoma vehicles currently registered in specific cold climate areas with high road salt usage (Cold ... Read More »
Region Letter: In 2014, Toyota announced and rolled out a Limited Service Campaign (LSC E0D) for certain 2005-2008 model year Toyota Tacoma vehicles currently registered in specific cold climate areas with high road salt usage (Cold ... Read More »
Dealer Letter: In 2014, Toyota announced and rolled out a Limited Service Campaign (LSC E0D) for certain 2005-2008 model year Toyota Tacoma vehicles currently registered in specific cold climate areas with high road salt usage (Cold ... Read More »
Dealer Letter: In 2014, Toyota announced and rolled out a Limited Service Campaign (LSC E0D) for certain 2005-2008 model year Toyota Tacoma vehicles currently registered in specific cold climate areas with high road salt usage (Cold ... Read More »
Dealer Daily: Due to limited availability of 05 - 08 Tacoma frame activity parts, Toyota will be implementing a new ordering process for all future frame and ancillary part orders. Read More »
Dealer Daily: Due to limited availability of 05 - 08 Tacoma frame activity parts, Toyota will be implementing a new ordering process for all future frame and ancillary part orders. Read More »
Dealer Letter: Condition-? Toyota has received reports that certain 2005 through 2008 model year Tacoma vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal ... Read More »
Region Letter: Condition-? Toyota has received reports that certain 2005 through 2008 model year Tacoma vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal ... Read More »
Region Letter: October 19,2017 Tundra Frame Replacement (ZH7) and CRC Application is now available. ? Added additional op codes for Tundra to cover dealer costs of maintaining vehicles while waiting for frames, if applicable. Read More »
Dealer Letter: The attached Dealer Letter has been updated. September 29, 2017 Rental Invoice requirement has been added. ? Estimated Launch Timing has been updated for Tundra and Sequoia models. Read More »
Region Email: 2005-2010 Tacoma Frame Replacement is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia vehicles regarding frame ... Read More »
Region Letter: 2005-2010 Tacoma Frame Replacement is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia vehicles regarding frame ... Read More »
Dealer Letter: 2005-2010 Tacoma Frame Replacement is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia vehicles regarding frame ... Read More »
Dealer Package: On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma vehicles regarding frame corrosion was approved. Read More »
EC: Rental vehicle opcodes have been updated for Limited Service Campaigns E0D and ESD. Refer to the updated dealer letter that has been posted to TIS. Read More »
Dealer Daily: Due to limited availability of 05 - 08 Tacoma frame activity parts, Toyota will be implementing a new ordering process for all future frame and ancillary part orders. Read More »
Dealer Daily: Due to limited availability of 05 - 08 Tacoma frame activity parts, Toyota will be implementing a new ordering process for all future frame and ancillary part orders. Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO SIGNIFICANT RUST, FROM ROAD SALT, A LIMITED SERVICE CAMPAIGN HAS BEEN ISSUED REGARDING CORROSION RESISTANT COMPOUNDS (CRC) APPLICATION, TO KEY AREAS OF FRAME ASSEMBLY. Read More »
TOYOTA TACOMA 2005-2008: CORROSION- RESISTANT COMPOUND TO FRAME OF SOME TRUCKS TOREVENT RUST. SEE DOCUMENT SEARCH BUTTON FOR OWNERS LETTER. *LJ Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO SIGNIFICANT RUST PERFORATION AND BASED UPON INSPECTION CRITERIA, A LIMITED SERVICE CAMPAIGN HAS BEEN ISSUED REGARDING THE APPLICATION OF CORROSION RESISTANT COMPOUNDS (CRC) TO ... Read More »
TOYOTA: THIS TSB CONTAINS AN OWNER NOTIFICATION LETTER. TACOMA 2005-2008 REPORTS SHOWING 2005-2008 MODELS THAT OPERATED IN COLD CLIMATE MAY HAVE MORE THAN NORMAL CORROSION VEHICLES TO FRAME. Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PROVIDED REGARDING THE CORROSION RESISTANT COMPOUND (CRC) APPLICATION FOR SOME VEHICLES FRAMES DUE TO USAGE OF HIGH ROAD SALT, IN CERTAIN STATES. MODEL 2005-2008 TACOMA. Read More »
Dealer Email: ? 2007-2008 (ZH7) Tundra Frame Replacement and CRC Application is now available. On May 21, 2017, a settlement of claims in a class action lawsuit involving 2005 ? 2010 Toyota Tacoma, 2007-2008 Tundra, and 2005-2008 Sequoia ... Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
THIS TSB CONTAINS DOCUMENT OWNER LETTER. SEE DOCUMENT SEARCH BUTTON. TOYOTA TACOMA 2005-2008: BULLETIN INFORMATION REGARDING CUSTOMER COMPLAINTS OF VEHICLES OPERATING IN COLD WEATHER WITH HIGH ROAD SALT USAGE MAY EXPERIENCE CORROSION ... Read More »
TOYOTA 2005-2008 TACOMA: THIS CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. CERTAIN REPORTS RECEIVED REGARDING CORROSION TO VEHICLES FRAME DUE TO COLD CLIMATE. *LJ Read More »
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INFORMATION PROVIDED REGARDING THE CORROSION RESISTANT COMPOUND (CRC) APPLICATION FOR SOME VEHICLES FRAMES DUE TO USAGE OF HIGH ROAD SALT, IN CERTAIN STATES. MODEL 2005-2008 TACOMA. Read More »
EC: Rental vehicle opcodes have been updated for Limited Service Campaigns E0D and ESD. Refer to the updated dealer letter that has been posted to TIS. Read More »
TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. Read More »
TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. Read More »
Dealer Letter: Condition-? Toyota has received reports that certain 2005 through 2008 model year Tacoma vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal ... Read More »
Region Letter: Condition-? Toyota has received reports that certain 2005 through 2008 model year Tacoma vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal ... Read More »
Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. Read More »
TSB: Referencing this Service Bulletin provides best practice procedures when reassembling and installing the front shock absorber with coil spring. Read More »
TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria ... Read More »
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
TSB: Some 2005 ? 2014 model year Tacoma vehicles equipped with 1GR-FE engine (PreRunner and 4WD) and automatic or 6-speed manual transmission may exhibit a vibration felt in the seat, floorboard, and steering wheel between 15 ? 25 mph ... Read More »
Some 2005 ? 2014 model year Tacoma vehicles equipped with automatic transmission may exhibit a vibration felt in the seat, floorboard, and steering wheel between 15 ? 25 mph caused by a second order drivetrain vibration under acceleration. Read More »
TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Read More »
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Read More »
TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Read More »
Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. Read More »
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Read More »
RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Read More »
RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Read More »
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers ... Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
TSB: Some 4WD 2005 ? 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. Read More »
TSB: Some 2WD 2005 ? 2013 model year Tacoma vehicles equipped with an automatic transmission may exhibit a clunk/thunk noise from the rear of the vehicle or a ?bump-from-behind? sensation just before a stop or when accelerating from a stop. Read More »
Some 2005 ? 2013 model year Tacoma vehicles equipped with a 5-speed automatic transmission may exhibit a whine noise from the rear differential between 50 ? 60 mph (80 ? 97 km/h). Read More »
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield ... Read More »
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
TSB: Some 2005 ? 2023 model year Tacoma vehicles equipped with a manual transmission may exhibit a squeak or creak noise from the clutch pedal when it is depressed or released. Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the ... Read More »
TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. Read More »
TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Read More »
Technical Instructions: TECHNICAL INSTRUCTIONS FOR CORROSION-RESISTANT COMPOUND CAMPAIGN H0F CERTAIN 2005 THROUGH 2010 MODEL YEAR TACOMA CORROSION-RESISTANT COMPOUND APPLICATION Read More »
Dealer Package: Added important note in the Parts section. Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 ... Read More »
Dealer Package: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Dealer Package: Modified warranty claim submission flowchart. See Appendix A. In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for ... Read More »
Customer Support Program: Toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. Read More »
TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0043-14. ? Applicability has been updated to include 2017 ? 2018 model year Toyota vehicles. Service Bulletin No. Read More »
TSB: REVISION NOTICE June 27, 2018 Rev2: ? The Production Change Information and the Parts Information sections have been updated. March 14, 2018 Rev1: ? The Production Change Information and Repair Procedure sections have been updated. Read More »
Dealer Package: June 25, 2018 Added warranty claim submission flowchart. See Appendix A. Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following ... Read More »
Mis-Built For frames that are suspected to have been mis-built, dealers should: 1. Contact the Parts Technical Support Group (PTSG) at prasupport@toyota.com with information on the condition and status of repair. a. Read More »
Dealer Daily Message: Certain U-joint kits (campaign part # 04007-13204) used in Customer Support Program ZH2 may have been produced without the appropriate amount of grease. These parts should not be installed on vehicles. Read More »
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. Read More »
Technical Instructions: Corrosion-Resistant Compound Campaign H0F Certain 2005- 2010 Model Year Tacoma. CORROSION-RESISTANT COMPOUND APPLICATION. Read More »
Dealer Letter: Extension of Warranty Coverage for Frame Corrosion. Technician Training Requirements have been updated to reflect amendments to the post-repair sign off and validation procedure. Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Dealer Letter: Frame Corrosion Resistant Compound (CRC) Application. As with prior CRC campaigns, the H0F Corrosion Resistant Compound (CRC) campaign is subject to state and local air emissions and permitting requirements. Read More »
Dealer Letter: Frame Corrosion Resistant Compound (CRC) Application. As part of the H0F Corrosion Resistant Compound (CRC) program, your dealership will receive a new set of the Vaupel HSDR 3300 spray guns to replace the old set of spray ... Read More »
Region Email: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Region Letter: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Dealer Email: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
Dealer Letter: Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for the following vehicles located in the 20 Cold Climate States1: ? Certain 2005 to 2010 ... Read More »
"DEALER LETTER: FRAME REPLACEMENT CUSTOMER VEHICLES THAT QUALIFY FOR FRAME REPLACEMENT UNDER E0D/ESD MUST HAVE THEIR VEHICLE INSPECTED ON OR BEFORE MARCH 31, 2016. Read More »
"QUICK REFERENCE GUIDE: FRAME REPLACEMENT ALL FRAMES MUST BE INSPECTED ON OR BEFORE MARCH 31, 2016 IN ORDER TO QUALIFY FOR FRAME REPLACEMENT. VEHICLES INSPECTED AFTER THIS DATE WILL NOT BE COVERED UNDER THE LIMITED SERVICE CAMPAIGN. Read More »
"DEALER LETTER: FRAME REPLACEMENT CUSTOMER VEHICLES THAT QUALIFY FOR FRAME REPLACEMENT UNDER E0D/ESD MUST HAVE THEIR VEHICLE INSPECTED ON OR BEFORE MARCH 31, 2016. Read More »
RL: TOYOTA WILL BE SENDING LIMITED SERVICE CAMPAIGN FOLLOW-UP NOTICES TO REMIND OWNERS WHOSE VEHICLES HAVE NOT YET HAD CAMPAIGN REPAIRS COMPLETED. Read More »
DL: LIMITED SERVICE CAMPAIGN COMPLETION IS IMPORTANT AND IS AN INTEGRAL PART OF OUR COMMITMENT TO MEET CUSTOMER EXPECTATIONS OF TOYOTA PRODUCTS. Read More »
RL: Toyota will be sending Limited Service Campaign Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
DL: Limited Service Campaign completion is important and is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
TSB: Some 2004 - 2015 model year Tacoma, FJ Cruiser, and 4Runner vehicles may exhibit a cyclical grinding or groaning noise coming from the front differential in 2WD that goes away when operated in 4WD. Read More »
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
Dealer Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
TSB: Some 2005 ? 2014 model year Tacoma vehicles used in severe off-road service conditions may exhibit a cracked Horn Mounting Bracket. Use the procedure in this bulletin to address this condition. Read More »
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. Read More »
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers ... Read More »
A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. Read More »
California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
TSB: Some 2012 - 2014 model year Tacoma vehicles equipped with 1GR-FE engines may exhibit spark knock (detonation) during light acceleration and/or uphill in hot weather (80?F or higher). Read More »
Some 2005 ? 2011 model year Tacoma vehicles may experience a condition where the inner Daytime Running Light (DRL)/turn signal lens becomes distorted and bubbled in appearance. In addition, the inner lens may appear cracked or separated. Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
Dealer Daily Message: Limited Service Campaign H0F ? Remedy Notice Certain 2005 ? 2010 Model Year Tacoma Certain 2007 ? 2008 Model Year Tundra Certain 2005 ? 2008 Model Year Sequoia Frame Corrosion Resistant Compound (CRC) Application ? ... Read More »
Customer Support Program: Toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. Read More »
TSB: REVISION NOTICE June 27, 2018 Rev2: ? The Production Change Information and the Parts Information sections have been updated. March 14, 2018 Rev1: ? The Production Change Information and Repair Procedure sections have been updated. Read More »
Warranty Policy Bulletin: Toyota has received reports in which customers have indicated that there is a drivetrain vibration and/or drivetrain noise. Read More »
TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Read More »
Dealer Letter: October 19, 2018 Tundra (ZH7) Frame Replacement and CRC Application is now available. Toyota will initiate a Limited Service Campaign (LSC H0F) to apply Corrosion Resistant Compound to key areas of the vehicle?s frame for ... Read More »
Dealer Letter: This communication only applies to dealerships located in Pennsylvania. As discussed in our August 28, 2017 Dealer Daily message, dealers in Pennsylvania were required to wait to commence CRC application for the H0F ... Read More »
Dealer Letter: Toyota has received a letter dated September 8, 2017 from the West Virginia Department of Environmental Protection (WVDAQ), confirming that the H0F campaign is exempt from air permit requirements as long as Toyota dealers ... Read More »
Warranty Policy Bulletin: Toyota has received reports of customer concerns in which the vehicles operated in specific cold climate areas (Cold Climate States) with high road salt usage may exhibit more-than-normal corrosion with the ... Read More »
Region Notice: Due to the expiration of LSC E0D, on April 1, 2016 all VINs were marked expired in TIS. As a result claims submitted after this date will automatically be placed in ?Not Approved? status in the CPS warranty system. Read More »
Region Notice: Due to the expiration of LSC ESD, on April 1, 2016 all VINs were marked expired in TIS. As a result claims submitted after this date will automatically be placed in ?Not Approved? status in the CPS warranty system. Read More »
Toyota will be sending Safety Recall Follow Up Notices to remind owners whose vehicles have not yet had campaign repair completed. Please note the following information for Regional and PD associates. Read More »
Toyota will be sending Safety Recall Follow Up Notices to remind owners whose vehicles have not yet had campaign repair completed. Please note the following information for Regional and PD associates. Read More »
TOYOTA: VEHICLE INTERIOR: INTERIOR PANELS/TRIM TO IMPROVE SERVICEABILITY OF THE FLOOR CARPET GROMMET (FLOOR CLAMP RETAINER), A NEW SERVICE PART HAS BEEN DEVELOPED WHICH ALLOWS THE FLOOR CARPET GROMMET TO BE REPLACED SEPARATELY FROM THE ... Read More »
Dealer Daily Message: Customer Support Program ZH2 Certain 2005 ? 2011 Model Year Tacoma Coverage for Propeller Shaft Universal Joints ? Customer Support Program ZH2 Dealer Letter now available on TIS. Read More »
Dealer Email: Toyota has received a number of reports regarding Propeller Shaft Universal Joints on certain 2005 ? 2011 model year Tacoma vehicles. Read More »
Dealer Letter: Toyota has received a letter dated September 5, 2017 from the Massachusetts Department of Environmental Protection (MADEP), confirming that the H0F campaign is exempt from air permit requirements as long as Toyota dealers ... Read More »
RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Read More »
RL: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
DL: Safety Recall completion is important not only in satisfying government requirements but also as an integral part of our commitment to meet customer expectations of Toyota products. Read More »
TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Read More »
TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Read More »
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
Dealer Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield ... Read More »
