This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
2019 RAV4 with 50120 miles engine maintenance light. It is a very common problem with Rav4s. coolant bypass valve...... My brother has same model same problem. Spent $600 to replace it. Toyota is charging $600-$1000 to replace defective part.
2019 rav4 at 59,000 miles engine maintenance required popped up. Went to the dealer, service advisor knew exactly that coolant control valve needed to be replaced because it being so common. I looked it up and coolant bypass valves in the 2019-?"2023 RAV4 and Corolla models. Some owners have reported that this defect could affect the vehicle's performance and longevity. Now I have to spend almost 1,000 for a repair I didn-??t even cause because Toyota built a faulty valve.
Engine error message showed up after extended warranty expired by 600 miles. To fix the error message Toyota charge $871 total combined diagnostic, part and labor. The problem was coolant by pass valve shorted.
- Plainview, NY, USA
Search CarComplaints.com for these popular complaint phrases...
Toyota Rav4 2019 XLE - Engine Coolant Pump Performance/Stuck Off Error code P26CB milage 56,920 Toyota says this is NOT covered by the 5 year power train warranty. For years Toyota has manufactured this water pump that freezes up due to manufacturing defect that allows the magnetic base housing to rupture. Dealers want to replace entire pump (or at least charge for it) verses replacing the frozen plastic rotor. Dealer claims this is not covered under 5 year power train warranty. Why not? My car temp started climbing and took me hours to get home (10 miles) as I kept stopping for hours waiting for engine cool and sprinkling water from bottles over the engine and trans housing where it butts against the engine (silver brading). (This was late in weekend night - repair shops not open. I do see a recall investigation started (no recall yet) and just wanted to add my complaint to the issue. At first the temp gauge read normal but later started climbing. The engine light did come on the the DB2 said P26CB.
Upon reaching 50k miles, vehicle prompted a "engine maintenance required, please contact dealer" message. Upon inspection at the dealer, I was told this is a common issue in newer Toyota RAV4/Corollas and employees have been seeing this issue continuously. There is no way to bypass this message without getting the part replaced and the replacement runs anywhere ~$800 -$1000. How are so many people dealing with the same issue and Toyota has yet to issue a recall?
Coolant bypass valve failure The issue has been confirmed by a service center and was told a very common failure in my make & model of car. Warning light came on dash board and immediately had checked at service center. The fix is $900, which is frustrating because a class action lawsuit is being gathered for this same defect in my same model of car.
Hi there. As of June 17, 2024, there is a class action lawsuit against Toyota regarding issues with the coolant bypass valves in the 2019-?"2023 RAV4 and Corolla models. Some owners have reported that this defect could affect the vehicle's performance and longevity, potentially leading to expensive repairs. The plaintiffs allege that Toyota has violated the Magnuson-Moss Warranty Act, the Florida Deceptive and Unfair Trade Practices Act, and California's Unfair Competition Law, Consumers Legal Remedies Act, and Song-Beverly Consumer Warranty Act. They are seeking a jury trial, declaratory and injunctive relief, and punitive damages. I encountered the same issue on July 3, 2024, and visited Toyota Scott Clark (Charlotte), where I was charged $129 for diagnostics and $835.60 for further service to fix the problem. I am not willing to pay for this service, and Toyota has refused to cover the cost. I am joining the class action lawsuit against Toyota.
My engine maintenance light will not shut off due to a engine coolant bypass valve circuit short to battery. I also have warm fluid dripping on my feet when ac is on. The dealer says water under the dash is from from recalled roof rails. There has been a recall for code that pops up on my mechanic Toyota number20TA04. Dealer says he does haven't code so toyota hasnt issued any issues or re all for engine bypass valve. Toyota now has a class action law suit for this part. I can't afford $700 repair, can't see the messages or my speed due to the engine maintenance required on my screen which can't be reset. This is dangerous and can cause the need to have engine replaced, start engine fires. Toyota has known this issue for 5 yrs and needs to be held accountable.
Coolant Bypass Valve Failure Engine Maintenance Required: See Dealer message appears on the drive screen when driving and you can't remove it- which means you can't see your digital speed or what you are setting your cruise at. The failure of this valve will cause the car to overheat which will lead to radiator/engine damage if not taken care of immediately. This part needs to be recalled!!!! RECALL THE TOYOTA COOLANT BYPASS VALVE! It is a faulty part that is failing in all 2019-2020 Toyota models. Mine is a 2019 RAV4. The part is plastic and is failing across the board. It Is costing $996 to have this problem diagnosed and fixed so I can drive my car again. I am a teacher and this is a substantial amount of money for a plastic part that should have never been used in the first place. Toyota needs to be held responsible for its cheap and faulty parts. I didn't know if I was going to make it to the dealership or not.
Engine maintenance required per dealership it is the coolant bypass valve. Reason for failed per Toyota -??bad luck-?? appears to be a class action suit filed for this issue current mileage 72,384
Known issue and reported by many others. Coolant bypass valve needs to be replaced around 30,000 to 50,000 miles. Occurs when turning on AC. Engine maintenance required sign pops up and cannot remove which does not allow driver to see speedometer leading to unsafe driving speeds.
Coolant Bypass Valve Defect. Toyota sold me a 2019 RAV 4 knowing there are problems with coolant bypass valve. Toyota RAV4s and Corollas is -??insufficiently manufactured and/or designed-?? as it can crack and leak coolant. Once a leak begins, the coolant comes into contact with an electrical connector near the valve and corrodes and damages the component, the filing says. Once this occurs, a vehicle-??s engine can no longer communicate with the coolant bypass valve during operation, the suit states.
A -??Engine Maintenance Required-?? notification came up on dash boards. When car was taken to dealership and a diagnosis was made they stated that the engine coolant bypass valve was damaged and needed to be replaced. Upon research online it appears that Toyota would be recalling over 44,000 vehicles of the makes RAV4 and Corolla ranging from the manufacturer years 2019-2023. The issue with these vehicles states that potential of a crack forming in the engine, a result of a manufacturing error. Coolant or oil could leak from the crack, leading to the engine stalling, overheating, or possibly catching fire. This issue can be found within several articles. The dealership is wanting me to pay $787+ tax for an issue that appears to be a manufactured issue which later I may not be refunded.
A message popped up on my dash "Engine Maintenance Required - See Dealer". After further research this is a known issue with the Toyota Rav4s. The coolant bypass valve gets stuck open/closed. I took it into Toyota and before they even looked under my hood, he read the message on the dash and said "I know what it is". After paying $742.16, it was fixed. My local mechanic was not aware of this issue, so I had to go through Toyota directly. If someone cannot afford $700-$1,000 repair, they risk their engine overheating. Toyota is aware of this issue and they have not recalled this part in their vehicles that is consistently failing.
A D V E R T I S E M E N T S
- Knoxville , TN, USA