Technical Service Bulletins (TSBs) for the 2010 Prius are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
TSB: REVISION NOTICE AUGUST 11, 2016 REV1: APPLICABILITY HAS BEEN UPDATED TO INCLUDE 2016 MODEL YEAR PRIUS V VEHICLES. ANY PREVIOUS PRINTED VERSIONS OF THIS BULLETIN SHOULD BE DISCARDED. Read More »
TSB: SOME 2010 ? 2015 MODEL YEAR PRIUS (2ZR-FXE EQUIPPED) VEHICLES AND 2012 ? 2015 MODEL YEAR PRIUS PHV AND PRIUS V (2ZR-FXE EQUIPPED) VEHICLES MAY EXHIBIT A ?RUNS ROUGH? AND/OR MIL ?ON? CONDITION WITH DTC(S) P030# (MISFIRE) DURING LIGHT ... Read More »
TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Read More »
TOYOTA: DIAGNOSTIC TROUBLE CODE (DTC) POAOF ENGINE FAILS TO START, WITH MALFUNCTION INDICATOR LAMP (MIL) ON DUE TO PURGE VSV/PCV LINE SEPARATION OF THROTTLE BODY HOUSING. MODEL 2010-13 PRIUS, PRIUS V. Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TOYOTA: TO ADDRESS THE CONDITION OF DIAGNOSTIC TROUBLE CODES (DTCS) THAT SOME VEHICLES ARE EXHIBITING (P0A0F, P3190, AND P3191), ENGINE CONTROL MODULE/ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM) LOGIC WAS REVISED. Read More »
TOYOTA: COOLANT LEAK FROM TRANSAXLE DRAIN PLUG. ENGINE/HYBRID SYSTEM. SOME VEHICLES MAY EXHIBIT A CONDITION WHERE COOLANT IS LEAKING FROM THE TRANSAXLE COOLANT DRAIN PLUG. USE THE REPAIR PROCEDURE TO ADDRESS THIS CONDITION. Read More »
TOYOTA: ENGINE/HYBRID SYSTEM. ENGINE CONTROL. SOME VEHICLES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0456 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM:POWERTRAIN CONTROL MODULE/PCM). Read More »
TOYOTA: COOLANT LEAK FROM TRANSAXLE DRAIN PLUG. ENGINE/HYBRID SYSTEM. SOME VEHICLES MAY EXHIBIT A CONDITION WHERE COOLANT IS LEAKING FROM THE TRANSAXLE COOLANT DRAIN PLUG. USE THE REPAIR PROCEDURE TO ADDRESS THIS CONDITION. Read More »
TOYOTA: BULLETIN PROVIDING INFORMATION ON THE MAINTENANCE AND CLEANING OF EXCESSIVE DUST, LINT, AND/OR OTHER DEBRIS THAT COULD BUILDUP ON HV BATTERY COOLING FAN THAT REDUCES EFFICIENCY OF THE SYSTEM. *PE MODEL 2010-2013 PRIUS. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
WARRANTY POLICY BULLETIN (POL14-05): TOYOTA HAS RECEIVED SOME REPORTS INDICATING THE INTELLIGENT POWER MODULE (IPM) LOCATED INSIDE THE INVERTER ASSEMBLY OF THE HYBRID SYSTEM MAY FAIL. Read More »
DEALER LETTER: IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE INTELLIGENT POWER MODULE (IPM) LOCATED INSIDE THE INVERTER ASSEMBLY OF THE HYBRID SYSTEM MAY FAIL. Read More »
TSB: SOME 2010 ? 2014 PRIUS AND 2012 ? 2014 PRIUS V MODEL VEHICLES MAY EXHIBIT A MIL ?ON? CONDITION WITH DTCS P0A94, P324E, P0A1A, OR P3004, INDICATING A MALFUNCTION HAS OCCURRED IN THE HYBRID INVERTER ASSEMBLY. Read More »
TSB: SOME 2010 ? 2014 PRIUS AND 2012 ? 2014 PRIUS V MODEL VEHICLES MAY EXHIBIT A MIL ?ON? CONDITION WITH DTCS P0A94, P324E, P0A1A, OR P3004, INDICATING A MALFUNCTION HAS OCCURRED IN THE HYBRID INVERTER ASSEMBLY. Read More »
TSB: REVISION NOTICE AUGUST 11, 2016 REV1: APPLICABILITY HAS BEEN UPDATED TO INCLUDE 2016 MODEL YEAR PRIUS V VEHICLES. ANY PREVIOUS PRINTED VERSIONS OF THIS BULLETIN SHOULD BE DISCARDED. Read More »
TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. Read More »
TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
TOYOTA: TO ADDRESS THE CONDITION OF DIAGNOSTIC TROUBLE CODES (DTCS) THAT SOME VEHICLES ARE EXHIBITING (P0A0F, P3190, AND P3191), ENGINE CONTROL MODULE/ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM) LOGIC WAS REVISED. Read More »
TOYOTA: ENGINE/HYBRID SYSTEM. ENGINE CONTROL. SOME VEHICLES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0456 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM:POWERTRAIN CONTROL MODULE/PCM). Read More »
TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. Read More »
WARRANTY POLICY BULLETIN (POL14-05): TOYOTA HAS RECEIVED SOME REPORTS INDICATING THE INTELLIGENT POWER MODULE (IPM) LOCATED INSIDE THE INVERTER ASSEMBLY OF THE HYBRID SYSTEM MAY FAIL. Read More »
DEALER LETTER: IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE INTELLIGENT POWER MODULE (IPM) LOCATED INSIDE THE INVERTER ASSEMBLY OF THE HYBRID SYSTEM MAY FAIL. Read More »
TSB: SOME 2010 ? 2014 PRIUS AND 2012 ? 2014 PRIUS V MODEL VEHICLES MAY EXHIBIT A MIL ?ON? CONDITION WITH DTCS P0A94, P324E, P0A1A, OR P3004, INDICATING A MALFUNCTION HAS OCCURRED IN THE HYBRID INVERTER ASSEMBLY. Read More »
TSB: SOME 2010 ? 2014 PRIUS AND 2012 ? 2014 PRIUS V MODEL VEHICLES MAY EXHIBIT A MIL ?ON? CONDITION WITH DTCS P0A94, P324E, P0A1A, OR P3004, INDICATING A MALFUNCTION HAS OCCURRED IN THE HYBRID INVERTER ASSEMBLY. Read More »
TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC. Read More »
TSB: THIS BULLETIN INCLUDES BASIC PROCEDURES FOR PERFORMING A RESCUE CHARGE ON NI-MH HIGH VOLTAGE (HV) BATTERIES. THIS BULLETIN SHOULD BE USED IN CONJUNCTION WITH THE REPAIR MANUAL WHILE PERFORMING RESCUE CHARGE. Read More »
TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. Read More »
TSB: THIS BULLETIN INCLUDES BASIC PROCEDURES FOR PERFORMING A RESCUE CHARGE ON NI-MH HIGH VOLTAGE (HV) BATTERIES. THIS BULLETIN SHOULD BE USED IN CONJUNCTION WITH THE REPAIR MANUAL WHILE PERFORMING RESCUE CHARGE. Read More »
TT: A VEHICLE MAY ARRIVE TO THE DEALER WITH A MIL ?ON? CONDITION AND P0A80 STORED IN THE MEMORY. SOME CASES HAVE BEEN IDENTIFIED WITH INTERNAL MODIFICATION DONE TO THE HV BATTERY. MODIFIED OR ALTERED PARTS ARE NOT COVERED UNDER WARRANTY. Read More »
TOYOTA: BULLETIN PROVIDING INFORMATION ON THE MAINTENANCE AND CLEANING OF EXCESSIVE DUST, LINT, AND/OR OTHER DEBRIS THAT COULD BUILDUP ON HV BATTERY COOLING FAN THAT REDUCES EFFICIENCY OF THE SYSTEM. *PE MODEL 2010-2013 PRIUS. Read More »
TOYOTA: TO ADDRESS THE ISSUE OF HALOGEN LOW BEAM HEADLAMP BULB SHORTAGE OF LIFE, THE WIRING HARNESS WAS MODIFIED AND IS AVAILABLE. MODELS 2010-2011 PRIUS. *PE Read More »
TOYOTA: LIGHTING (EXT). SOME VEHICLES MAY EXHIBIT EXCESSIVE CONDENSATION OR MOISTURE ON THE INTERIOR OF THE HEADLAMP(S). APPLIES TO VEHICLES PRODUCED BEFORE PRODUCTION CHANGE. *PE Read More »
TOYOTA: LIGHTING (EXT). SOME VEHICLES MAY EXHIBIT EXCESSIVE CONDENSATION OR MOISTURE ON THE INTERIOR OF THE HEADLAMP(S). APPLIES TO VEHICLES PRODUCED BEFORE PRODUCTION CHANGE. *PE Read More »
TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Read More »
TSB: ON SOME VEHICLES, WHEN RAPGARD? IS REMOVED, THE PAINT MAY HAVE A STAINED APPEARANCE. THESE STAINS APPEAR TO BE UNDER THE CLEAR COAT (REPAINTING THIS AREA IS NOT NECESSARY). Read More »
TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC. Read More »
"TT: SOME CUSTOMERS MAY ENCOUNTER BLUETOOTH CONNECTIVITY CONCERNS SUCH AS: ? DIFFICULTY PAIRING THE PHONE. ? INTERMITTENT BLUETOOTH FAILURE TO CONNECT WHEN FIRST TURNING ON THE VEHICLE. Read More »
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
TOYOTA: PRIUS HYBRID 2010-2014 WARRANTY HAS BEEN EXTENDED FOR INTELLIGENT POWER MODULE(IPM) FOR THE FOLLOWING VEHICLES. SEE DOCUMENT SEARCH BUTTON FOR OWNERS LETTER. *LJ Read More »
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
TOYOTA: VEHICLE INTERIOR: INTERIOR PANELS/TRIM TO IMPROVE SERVICEABILITY OF THE FLOOR CARPET GROMMET (FLOOR CLAMP RETAINER), A NEW SERVICE PART HAS BEEN DEVELOPED WHICH ALLOWS THE FLOOR CARPET GROMMET TO BE REPLACED SEPARATELY FROM THE ... Read More »
