Technical Service Bulletins (TSBs) for the 2015 Highlander are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
TT: SPARE TIRE CARRIER WILL BIND/SEIZE WHEN LOWERING OR RAISING SPARE TIRE OR CABLE WILL NOT FULLY EXTEND WHEN ATTEMPTING TO LOWER SPARE TIRE, THEREFORE MAKING IT DIFFICULT TO REMOVE FROM THE CABLE. Read More »
TSB: SOME 2014 ? 2015 MODEL YEAR HIGHLANDER VEHICLES MAY EXHIBIT A MIL ?ON? CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P2610 (ECM/PCM ENGINE OFF TIMER PERFORMANCE) PRESENT. Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TSB: SOME 2014 ? 2015 MODEL YEAR HIGHLANDER VEHICLES MAY EXHIBIT A CONDITION WHEN THE A/C SYSTEM IS TURNED ON, IT MAY TAKE A LONGER THAN EXPECTED AMOUNT OF TIME UNTIL IT BEGINS TO BLOW COOL AIR. Read More »
TSB: SOME 2014 ? 2015 MODEL YEAR HIGHLANDER VEHICLES MAY EXHIBIT A MIL ?ON? CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P2610 (ECM/PCM ENGINE OFF TIMER PERFORMANCE) PRESENT. Read More »
TSB: SOME 2014 ? 2015 MODEL YEAR HIGHLANDER VEHICLES MAY EXHIBIT A MIL ?ON? CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P2610 (ECM/PCM ENGINE OFF TIMER PERFORMANCE) PRESENT. Read More »
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
TSB: SOME 2015 MODEL YEAR HIGHLANDER AND HIGHLANDER HV VEHICLES EQUIPPED WITH DUAL FRONT AIR CONDITIONING SYSTEMS MAY EXHIBIT AN INTERMITTENT BUZZING NOISE CONDITION COMING FROM THE CENTER OF THE INSTRUMENT PANEL DURING HVAC OPERATION. Read More »
"TSB: REVISION NOTICE AUGUST 3, 2016 REV1: WARRANTY INFORMATION SECTION HAS BEEN UPDATED WITH A NEW OP CODE. SUPERSESSION NOTICE THE INFORMATION CONTAINED IN THIS BULLETIN SUPERSEDES SB NO. T-SB-0027-15. Read More »
TSB: SOME 2014 ? 2015 MODEL YEAR HIGHLANDER AND HIGHLANDER HV VEHICLES MAY EXHIBIT A CONDITION IN WHICH THE POWER BACK DOOR IS INOPERATIVE OR STOPS DURING OPERATION. IN SOME CASES THIS CONDITION MAY BE ASSOCIATED WITH COLD WEATHER. Read More »
"TSB: DURING THE MANUFACTURING PROCESS TIRES ARE MOUNTED ON THE VEHICLE AS MATCHED SETS TO HELP REDUCE CONDITIONS SUCH AS PULLING OR DRIFTING. Read More »
TT: SPARE TIRE CARRIER WILL BIND/SEIZE WHEN LOWERING OR RAISING SPARE TIRE OR CABLE WILL NOT FULLY EXTEND WHEN ATTEMPTING TO LOWER SPARE TIRE, THEREFORE MAKING IT DIFFICULT TO REMOVE FROM THE CABLE. Read More »
"TT: CHROMETEC (PLASTIC CLAD) WHEELS ARE BEING DAMAGED DURING MOUNTING AND DISMOUNTING OF TIRES. REFER TO PHOTOS BELOW FOR IDENTIFYING PLASTIC AND ALUMINUM PORTIONS OF WHEEL:" Read More »
"TSB: REVISION NOTICE AUGUST 3, 2016 REV1: WARRANTY INFORMATION SECTION HAS BEEN UPDATED WITH A NEW OP CODE. SUPERSESSION NOTICE THE INFORMATION CONTAINED IN THIS BULLETIN SUPERSEDES SB NO. T-SB-0027-15. Read More »
TSB: ON SOME VEHICLES, WHEN RAPGARD? IS REMOVED, THE PAINT MAY HAVE A STAINED APPEARANCE. THESE STAINS APPEAR TO BE UNDER THE CLEAR COAT (REPAINTING THIS AREA IS NOT NECESSARY). Read More »
TSB: SOME 2014 MODEL YEAR APPLICABLE VEHICLES EQUIPPED WITH ENTUNE? AUDIO (VERSION 010169) / ENTUNE? AUDIO PLUS (VERSION 010171) / ENTUNE? PREMIUM AUDIO (VERSION 010185) MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS. Read More »
TSB: SOME 2014 ? 2015 MODEL YEAR HIGHLANDER AND HIGHLANDER HV VEHICLES MAY EXHIBIT A CONDITION IN WHICH THE POWER BACK DOOR IS INOPERATIVE OR STOPS DURING OPERATION. IN SOME CASES THIS CONDITION MAY BE ASSOCIATED WITH COLD WEATHER. Read More »
TT: SOME VEHICLES MAY EXHIBIT AN ERROR MESSAGE WHEN TRYING TO PERFORM A RADIO SOFTWARE UPDATE: "UNABLE TO UPDATE THE SOFTWARE. PLEASE TRY AGAIN LATER." IF THE FOLLOWING SCREEN IS SEEN, FOLLOW THE DIRECTIONS BELOW. Read More »
"TT: SOME CUSTOMERS MAY ENCOUNTER BLUETOOTH CONNECTIVITY CONCERNS SUCH AS: ? DIFFICULTY PAIRING THE PHONE. ? INTERMITTENT BLUETOOTH FAILURE TO CONNECT WHEN FIRST TURNING ON THE VEHICLE. Read More »
TT: FOR CUSTOMER CONCERNS OF NO OR POOR OUTGOING SOUND FROM THE BLUETOOTH SYSTEMS THERE ARE DIAGNOSTICS IN THE REPAIR MANUAL WHICH CAN BE PERFORMED TO DIAGNOSE THE CONDITION. Read More »
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
TT: SOME CUSTOMERS MAY EXPERIENCE BLUETOOTH DISCONNECTIONS OR LOSS OF SMS TEXT MESSAGE FUNCTIONALITY ON THE NAVIGATION/AUDIO SYSTEM WITH ANDROID PHONES RUNNING OS 4.4 OR LATER. Read More »
TSB: SOME 2014 MODEL YEAR APPLICABLE VEHICLES EQUIPPED WITH ENTUNE? AUDIO (VERSION 010169) / ENTUNE? AUDIO PLUS (VERSION 010171) / ENTUNE? PREMIUM AUDIO (VERSION 010185) MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS. Read More »
TT: SOME VEHICLES MAY EXHIBIT AN ERROR MESSAGE WHEN TRYING TO PERFORM A RADIO SOFTWARE UPDATE: "UNABLE TO UPDATE THE SOFTWARE. PLEASE TRY AGAIN LATER." IF THE FOLLOWING SCREEN IS SEEN, FOLLOW THE DIRECTIONS BELOW. Read More »
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
TSB: SOME 2014 ? 2015 MODEL YEAR HIGHLANDER VEHICLES MAY EXHIBIT A CONDITION WHEN THE A/C SYSTEM IS TURNED ON, IT MAY TAKE A LONGER THAN EXPECTED AMOUNT OF TIME UNTIL IT BEGINS TO BLOW COOL AIR. Read More »
TSB: SOME 2014 ? 2015 MODEL YEAR HIGHLANDER VEHICLES MAY EXHIBIT A CONDITION WHEN THE A/C SYSTEM IS TURNED ON, IT MAY TAKE A LONGER THAN EXPECTED AMOUNT OF TIME UNTIL IT BEGINS TO BLOW COOL AIR. Read More »
TSB: SOME 2015 MODEL YEAR HIGHLANDER AND HIGHLANDER HV VEHICLES EQUIPPED WITH DUAL FRONT AIR CONDITIONING SYSTEMS MAY EXHIBIT AN INTERMITTENT BUZZING NOISE CONDITION COMING FROM THE CENTER OF THE INSTRUMENT PANEL DURING HVAC OPERATION. Read More »
