My rack and pinion was replaced under warranty 8/2010 at 30,000 it was making a zipping noise. A year later at 47,000 the same problem has happened and Suzuki refuses to cover the $1000 repair. I have called numerous times with no help. I am outraged because this problem is known to Suzuki and they dont care! even the dealership has told me that they have repaired this many times in other Suzuki XL7 with the same issue. Suzuki claims the car is still safe and it is only a noise issue but I dont feel safe, its the steering!! I guess they expect us to keep dishing out money for something that is known faulty and obviously keeps reoccuring.it is also obvious the repairs are being done with the same faulty part the car was manufactured. Suzuki needs to step up to the plate and take responsibility for there mistake.

- Winston Salem, NC, USA

The contact owns a 2008 Suzuki XL7 limited. The contact stated that while driving at low speeds and making a turn, he would hear a winding noise from the steering. The vehicle was then taken to a dealer and the contact was informed that the steering rack had failed and needed to be replaced. The vehicle was repaired. Approximately one year later the failure recurred. The failure mileage was approximately 30,300. The VIN was unavailable.

- Woodstock, GA, USA

I have a problem with my Suzuki XL7 2008 VIN/serial [xxx]. the power steering is leaking fluid and have to refill it continuously. The wheel makes noise when I make turns and also is becoming hard to maneuver. I took my vehicle to the South deerfoot Suzuki dealer at 7220 railway St SE calgary, ab T2H 3A8 (1-888-284-1809), Canada once I noticed this problem. At that time I had 62,000 km (38520 miles) on the vehicle. They could not find any problems. After I got tired of refueling the power steering fluid, I took it to the dealer again. This time I had 65,000 km (43390 miles). They found this time about three possible problems, but since the warranty of this vehicle had expired, I was told that I would be responsible for the repairs. Now, the leaking, the noise, and the maneuver have become more critical. I took the vehicle to a private mechanic shop. They found that the problem could be a seal damaged which connects to front side tire (the driver side)and recommended me that since the vehicle still new (2008) I should contact chacon Suzuki about the warranty. I also had contacted nicholas rockwell, fixed operations manager South deerfoot Suzuki about a possible power steering recall with Suzuki XL7 2006 that could be applicable to my Suzuki 2008. I have filed a recall complain with NHTSA and I have contacted Suzuki Canada in Ontario. I have been recommended to contact the chacon Suzuki dealer at 3566 I-35 S, new braunfels, tx 78132 phone: 830-624-7000 and the South deerfoot Suzuki dealer david baker dealer principal mdbaker@shaw.ca. Information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Okotoks, 00, USA

Power steering wheel hard to control. Power steering wheel makes noise. Power steering fluid gets very low. Needs to be refilled very often. I have been informed on the NHTSA website that there is a recall for the vehicle Suzuki XL7 2006. The recall is #10V250000 steering hydraulic power assist-pump potential unit affected #46549. My vehicle is Suzuki XL7 2008. I had this vehicle inspected and confirmed the same problem as the Suzuki XL7 2006 and agreed that driving this vehicle is unsafe and potential danger.

- Austin, TX, USA