2007 Suzuki XL7
19 Technical Service Bulletins (TSBs)
TSB List for the 2007 Suzuki XL7
Technical Service Bulletins (TSBs) for the 2007 XL7 are official communications between Suzuki & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
ENGINE (PWS)
-
TSB #SI-0012-R
SUZUKI: TIMING CHAIN SERVICE KITS ARE AVAILABLE. THE PURPOSE OF THE KITS ARE TO PROVIDE PARTS NEEDED IN ORDER TO SERVICE TIMING CHAINS THAT HAVE STRETCHED. *JS Read More »
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
-
TSB #1803277
FUEL TANK FILLER NECK (INLET CONTROL VALVE) INSPECTION (CAMPAIGN 99-KIT). *KB Read More »
-
TSB #1803167
FUEL TANK FILLER NECK (INLET CONTROL VALVE) INSPECTION (CAMPAIGN 99-KIT). *KB Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-
TSB #SC-66
SUZUKI: WHERE PLASTIC SUPPLY OR RETURN PORT ON FUEL PUMP MODULE, THERE IS A CRACK THAT CAN CAUSE A FUEL LEAK AND WHILE BEING DRIVEN OR PARKING, FUEL ODOR MAY BE NOTICED AND COULD BECOME LARGER AND DRIP ON THE GROUND. MODEL 2007-2009 XL7. Read More »
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
-
TSB #TSB-TS-27-07313
SUZUKI: WHEN VEHICLE IS EITHER PARKED OR BEEN DRIVEN, CAN SMELL AN ODOR OF FUEL, OR CAN OBSERVED FUEL DRIPPING, AROUND AREA OF FUEL TANK IN REAR OF VEHICLE, DUE TO CRACK IN PLASTIC SUPPLY OR RETURN PORT OF FUEL PUMP MODULE, CAUSING THE ... Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #08-04-21-002
FLUID LEAK AT TRANSFER CASE WEEP HOLE (REPLACE FRONT WHEEL DRIVE INTERMEDIATE (INNER) SHAFT SEAL). *PE Read More »
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
-
TSB #TS 10 04048
AUTOMATIC TRANSMISSION FLUID LEAK FROM TRANSFER CASE. UP TO VIN 2S3DA5179883 (MFG DATE 12/21/07). *NJ Read More »
ELECTRICAL SYSTEM
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #TS-05-12099
SUZUKI: TECHNICIANS MAY ENCOUNTER AN INTERMITTENT OR CURRENT AIR BAG LIGHT ON IN THE INSTRUMENT PANEL WITH DTC(S) B0012, B0013, B0014, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET IN THE SDM (SENSING AND ... Read More »
ELECTRICAL SYSTEM:SOFTWARE
-
TSB #TS24 02118
CHECK ENGINE LIGHT (ON), DTC P0128 (ENGINE COOLANT TEMPERATURE (ECT) BELOW THERMOSTAT REGULATING TEMPERATURE) - OUTSIDE TEMPERATURES BELOW FREEZING. *NJ Read More »
EXTERIOR LIGHTING:TURN SIGNAL
-
TSB #TSB-39-08258
SUZUKI: THE TURN SIGNAL AND LAMPS ON TRAILER STAY ON OR INOPERATIVE DUE TO INCORRECT INSTALLATION OF LAMP RELAYS. MODEL 2007 XL7. *PE Read More »
EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
-
TSB #TSB-39-08258
SUZUKI: THE TURN SIGNAL AND LAMPS ON TRAILER STAY ON OR INOPERATIVE DUE TO INCORRECT INSTALLATION OF LAMP RELAYS. MODEL 2007 XL7. *PE Read More »
AIR BAGS
-
TSB #TS-05-12099
SUZUKI: TECHNICIANS MAY ENCOUNTER AN INTERMITTENT OR CURRENT AIR BAG LIGHT ON IN THE INSTRUMENT PANEL WITH DTC(S) B0012, B0013, B0014, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET IN THE SDM (SENSING AND ... Read More »
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
-
TSB #TS03 01108R
AIR BAG LIGHT ON, WITH DTC B0081 SYMPTOM CODE [OF] (PASSENGER PRESENCE SYSTEM ERRATIC). *NJ Read More »
-
TSB #0312117
AIRBAG LIGHT ON, WITH DTC B0081 SYMPTOM CODE )OF) PASSENGER PRESENCE SYSTEM ERRATIC. *NJ Read More »
WHEELS
-
TSB #PIP-4478A
BUICK/CHEVROLET/GMC/PONTIAC/SATURN/SUZUKI: ALL WHEEL DRIVE SYSTEM INOPERATIVE AND DTC C0550 SET. VARIOUS CONCERNS MAY BE RELATED TO A LOW BATTERY SUCH AS BUT NOT EXCLUSIVE TO A NO CRANK OR SLOW ENGINE CRANK CONCERNS OR MAY HAVE ... Read More »
EQUIPMENT
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #PIP5226A
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. Read More »
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-
TSB #PIP-4478A
BUICK/CHEVROLET/GMC/PONTIAC/SATURN/SUZUKI: ALL WHEEL DRIVE SYSTEM INOPERATIVE AND DTC C0550 SET. VARIOUS CONCERNS MAY BE RELATED TO A LOW BATTERY SUCH AS BUT NOT EXCLUSIVE TO A NO CRANK OR SLOW ENGINE CRANK CONCERNS OR MAY HAVE ... Read More »