This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Another for the list of many, many windshield cracking complaints. My 2019 Outback 2.5i Limited has had 3 replacements since I purchased it new in late 2018. The cost to replace each has certainly increased each time and is very expensive as it has to include the eyesight calibration. I'm told this is not covered in my extended warranty I purchased when the vehicle was new. Subaru needs to take ownership of the quality issue and compensate the countless owners who have had this same issue, multiple times! I've read the glass is too thin, may be intentional because of the eyesight feature. Mileage and date below are from the most recent crack I had to repair. Please let me know if you'd like more details on the first two occurances as well.
Severe windshield cracking requiring replacement. 2 in 6 month period. 1st was November 2023. Extremely cold temperatures. Cracked directly above heater vents on both sides same time. I watched it go from outer lower edges and move all the way to the center, entire length of the shield. I did not see anything hit the windshield, but they were iced and snow covered. I felt the temperature difference outside compared to in the cabin may have caused the crack. 2nd occurred July 12 2024. Extreme heat ( 100 plus) air-conditioning blasting cold air. Low traffic, at least 4 car lengths between mine and the car ahead. I did not see any debris. I did hear a noise, and then watched the windshield crack from the same location (lower outside edge) this time only the passenger side. The crack started approximately 6 inches. The following morning that crack had moved past midway of the windshield. This is not normal for any other vehicle I have driven. I have been driving 45 years. I have had a rock hit the windshield, some large rocks. In only one case I suffered a chip that was fixed with resin. There is a problem (safety) with this windshield. Installation, glass, design flaw?? I don't know the cause, but It is hazardous. The dealer's mechanic that replaced the 1st one told me "it is a KNOWN issue for my model" someone needs to address and correct an issue that is known which could be catastrophic. I was driving 35 mph in November incident, and 70 mph in July. I can provide documentation re: 1st replacement. I did not take pictures of that one. I can provide photos of 2nd one. I have not done 2nd replacement. I may just trade it out. That is how concerning this issue is to me.
Windshield cracked spontaneously while parked, March 29, 2024. Temperature was approx 28?F. This was the second time in 11 months this has happened. Safelite technician said it was caused by faulty windshield heater. The first one I paid for the replacement, the second one was under warranty from Safelite. But was told if it happened again they would not be responsible.
I now have a second windshield that suddenly cracked. I was told that Subaru OEM windshield was installed and their is a Subaru icon on the glass. The first time was when a defrost was turned on. I heard a pop and crack quickly appeared. Crack started on the outside edge about half way up on the passenger side. Within seconds the crack was half way across to the other side. The most recent it was after a hot day on the previous day the next morning open the garage and immediately saw multiple cracks starting from the drivers side this time, about half way up then running almost half across the other side. Both times I had only had the windshield a few months. I took it back to the windshield installer and they are going to replace it because it isn't due to damage to the windshield like a chip. They told me that they are putting Subaru OEM windshields on right now because they have had to replace 20 recently for the same issue. They just suddenly crack no damage. They said there is a lawsuit. I asked the dealership and they told me that haven't heard any issues with windshields. I just wanted to let you know. It is pretty scary and expensive to have the windshield suddenly crack and it is pretty deep. I'm going to take a picture since my Subaru dealership wouldn't record the issue for me.
My windshield has chipped and cracked 4 times in the 5 yrs that I've owned this car, purchased new. In the first three cases, a minor chip started cracking the windshield almost immediately. In the last case, which I haven't had repaired yet, there wasn't even a chip. The windshield seemed to just spontaneously crack. The glass shop for replacement #3 noted that the car is now rusting under the windshield. The car has only 39K miles on it.
- Arcata, CA, USA
Search CarComplaints.com for these popular complaint phrases...
The Windshield of my outback Subaru 2019 has cracked two times since I purchased the vehicle. Not caused by propelled items, accidents or vandalism, instead, these cracks originated from the center bottom part of the windshield suddenly and spread upwards.
My Subaru 2019 Outback has had 5 replacement windshields in 10 months. The windshield seems to crack for no reason and the cracks spread quickly impairing vision and causing worry that any impact of an object would come straight through the windshield and cause harm to driver, passengers and potentially other vehicles. I have talked with Subaru of America, just this last time on the 5th replacement and they had an engineer look at the windshield to determine cause. The report states: -??Subaru field engineer determined caused by chip.-?? As the driver of the vehicle, NOTHING has hit the windshield while driving, nothing of note that is, normal things like rain, sunshine, and wind, which is what a windshield is meant to protect against.The other techs at the dealer could not make out a point of impact. I picked up my vehicle from the dealer at 6pm, drove it a few miles on the freeway, maintaining safe follow distances with my new windshield, and when I got back in the car 2 hours later there were 4 cracks stemmed from the bottom of the windshield that stretched up more than 6 inches. The windshield is currently cracked and I-??m waiting for Subaru of America to get back to me on this issue. There is a problem with the windshields and someone needs to take responsibility for it. One or two cracked windshields can be explained, but now with the most recent one, that-??s 6 cracks in 10 months. It seems there is a defect.
Within a year, my windshield has cracked 4 times with Subaru glass. These cracks are huge coming from either the top or bottom. With the crack, I feel like the eyesight feature is not accurate therefore causing weird serving. So I do not feel safe leaving my lane assist on. I have had 3 Subaru glass and one safelite glass, and this seems to be a reoccurring issue. what is the point of getting it fixed if it'll just keep cracking.
Windshields crack easily. I was using the original windshield and it was cracked on the passenger side. Common error of subaru outback. My car is only 37000miles.
When defroster was turned on, a crack began on the windshield at the bottom, left of middle. As the days went on, the crack continued to spread when heat was on or sun heated up the windshield. In 3 months it went from a 4 inch to a 10 inch crack that obstructed view. We just had it replaced after paying a $500 deductible, with no guarantee it won-??t recur.
We own a 2019 outback, and have had the windshield replaced twice prior this event. The first was a year ago with about 70K miles after the windshield suddenly cracked while going about 70MPH, this happen when no other cares where around. The second time was 2 weeks later when we came outside in the morning and the windshield was cracked while parked in a parking lot. Now for the 3rd time the windshield has cracked while parked in the garage, the windshield has cracked more each night, and has not grown is size while driving. Coincidental all the cracks have started in the same spot, lower portion of the windshield by the wiper, just to the right of the driver. We have been told every time by the dealer that it has been a rock chip, but its hard to get a rock chip when teh vehicle is in the garage and not moving.
My windshield cracked for the 6th time with nothing hitting on this occasion. It immediately shattered and even lost a piece of glass from where it cracked. I believe this to be a safety issue as it could immediately inter with my safety and radar equipment. I am worried if the glass cracks without contact what would happen if something significant hit it. Additionally since this is the 6th time I am concerned that something could be wrong with the design of the vehicle. I have contacted Subaru multiple times without resolve.
Windshield has cracked (large about 10 inches or more) 2 times within a year for no apparent reason. Both times the weather did not have fast shifting changes and the car was sitting in the driveway or in the garage at my residence.
Windshield has been cracked and replaced 3 times and currently has another crack, all within 17 months. Also head unit has internal malfunction and must be replaced at cost of $1700 +/-
As of Today 1-31-24 I have to replace my windshield for the 3rd time. The first windshield was broken when a rock from a semi the rock stuck the windshield (7K miles). I paid for that one b/C that rock would have cracked any windshield. The 2nd windshield cracked for what seemed to me to be no apparent reason (36 K miles). And the fourth Windshield (48K miles) has now cracked in two places for no apparent reason. Subaru paid for the 3rd windshield but Subaru Customer Advocacy says they won't pay for another windshield b/c they paid for the 3rd windshield as a matter of "courtesy". My wife and I have owned 10-13 Subaru's and many other vehicles since the 1980's and have never had any windshield problems like this before. There has to be something wrong with the design or materials in these windshields.
Front windshield cracked without any impact. Was parked in my driveway for previous 3 days. Got in to drive and noticed the large crack right away. It started from the passenger mid lower edge and within a day it cracked halfway across passenger side. There was no divot or impact that caused this.
Cracked windshield (2nd incident in less than 18 months). Windshield cracked without any impact with rocks or other objects. This is an OEM windshield that was installed and calibrated at Sheehy Subaru Springfield, VA. This windshield easily cracks or is damage (impacts blemishes) by minor/small objects, which is unreasonable. This latest incident that I am reporting is a hair line crack, about 14-?? in length that runs from the edge of the windshield to the middle; there was no impact; this appears to be a temperature change like crack. It adversely affects visibility. This is a very expensive repair $1,500 for OEM and calibration.
Subaru outback had been parked in my garage for a few days. When I decided to move it, I backed out of my garage and noticed that my car had this squiggly crack on my windshield. I see this happen to a lot of subaru owners. Called about getting a defective windshield replaced and was told no. After seeing thaf theres been a lot of complaints of the similar issue. Issue happened on 9.28.23
Minor rock strike from road driving on 09/15/23. This resulted in a crack about 8" long on passenger side of window. In 7 days, the crack has grown to about 36" and has fractured in multiple locations. The crack continues to grow even while the vehicle is stationary and not experiencing severe weather events. This is due to a poor bracing of the window on the top frame portion of its mounting location on the vehicle.
A D V E R T I S E M E N T S
- Naperville, IL, USA