Technical Service Bulletins (TSBs) for the 2018 1500 are official communications between Ram & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
UAS and UCS Radio Enhancements Customers may experience one or more of the following: **Wi-Fi hotspot connection failure. Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
UAS and UCS Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.6 Customers may experience one or more of the following: Intermittent, black radio display screen. Read More »
Title 68245351AB: Switch - Steering Wheel Lt Start Date: 10/27/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
If replacing the steering linkage or drag link inner tie rod assembly at the pitman arm on a vehicle built before Febuary 14 th, 2008, verify that the pitman arm part number is 68039930AA. The part number is embossed on the pitman arm. Read More »
Title 68245351AB: Switch - Steering Wheel Lt Start Date: 10/27/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. Read More »
Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Read More »
If replacing the steering linkage or drag link inner tie rod assembly at the pitman arm on a vehicle built before Febuary 14 th, 2008, verify that the pitman arm part number is 68039930AA. The part number is embossed on the pitman arm. Read More »
PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for ... Read More »
PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for ... Read More »
Customer may complain of a MIL lamp on. Upon further investigation there could be a fault code in the PCM for P1524 ? Oil Pressure Out of Range ? Camshaft Advance/Retard Disabled. Read More »
A/C Pressure Transducer A/C inoperative and diagnosis leads to pressure transducer. Call Steve Rice at cell (248) 867-0061 before replacing the pressure transducer. If no response in 15 minutes, please proceed with repair. Read More »
Title Inspection and Return: Hydro-Booster, - Power Brake. Start Date: 10/27/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
CALIPER ASSEMBLY, Disc Brake, Front For an issue with drift ONLY when braking, please replace the complete front caliper assemblies including adapters and pads as a unit, unbolting them from the knuckle. Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
CALIPER ASSEMBLY, Disc Brake, Front For an issue with drift ONLY when braking, please replace the complete front caliper assemblies including adapters and pads as a unit, unbolting them from the knuckle. Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
CONDENSER, Air Conditioning If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair ... Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) Engineering is seeking information regarding OFA leaks. Questions/info can be directed to: Bob Jackson (248) 944-0466 - bob.jackson@fcagroup.com Ron Dallison (248-292-9510) ron. Read More »
04627694AA Purge Control - Valve You have been identified as either having stock, or have stock in transit to your dealership. Suspect stock of part number: 04627694AA must be returned. See attached for identifying suspect stock. Read More »
05187880AC - Inspect and Return: Relay Assy - Heater Intake Air You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05187880AC. Read More »
Title Filter - Engine Oil Start Date: 10/23/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part number: 68109834AA. Read More »
Camshaft Position Sensor If replacing a camshaft position sensor for P0340 and/or P0344 fault codes, please review information below and contact Andrew Action on his cell phone: (248) 421- 4130. Read More »
Camshaft Position Sensor If replacing a camshaft position sensor for P0340, P0344, P0345, P0349, P0365, P0369, P0390 or P0394 fault codes, please review information below and contact Tom Nies on his cell phone: (248) 494-0187. Read More »
COOLER Engine Oil Please be aware that the oil cooler seal is serviceable as a standalone part and should be considered for replacement as a remedy for fluid leak. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) All vehicles equipped with a 3.2L or 3.6L except for model year 2014 vehicles with leak concern: 1) Ensure the Oil Filter Adapter (OFA) Cap O-ring is seated in the proper groove in the cap and ... Read More »
Customer may complain of a MIL lamp on. Upon further investigation there could be a fault code in the PCM for P1524 ? Oil Pressure Out of Range ? Camshaft Advance/Retard Disabled. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
3.0L Oil Filter Cartridge Identification Differences And Oil Filter Element Servicing Procedure This bulletin outlines the correct procedure for changing an oil filter on a 3.0L diesel to prevent engine damage. Read More »
GEN-2 and GEN-3 - 3.0L Oil Filter Cartridge Identification Differences This bulletin highlights the design differences in the oil filter cartridges used in the GEN-2, and GEN-3 3.0L diesel. Read More »
CONDENSER, Air Conditioning If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair ... Read More »
04627694AA Purge Control - Valve You have been identified as either having stock, or have stock in transit to your dealership. Suspect stock of part number: 04627694AA must be returned. See attached for identifying suspect stock. Read More »
P/N 04573460 - Inspect &Return: Rocker Assy - Intake Valve RT You have been identified as either having stock, or have stock in transit to your dealership. Please return part number 04573460 which have a packaging date of 2016-06-13. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that ... Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
FAN MODULE, Radiator Cooling For radiator fan concerns, please contact Sam Zarnegar at 248-944-5703 prior to replacement. If no response in 15 minutes, proceed with repair. Read More »
Radiator If vehicle comes in for transmission fluid leaking from trans-oil cooler fittings on the radiator, please check the following before replacing the radiator/cooler:~ 1. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Improperly Installed Exhaust Gas Recirculation (EGR) Valve This bulletin involves removing and inspecting the vacuum tube, EGR tube gaskets, tube flange mounting bolts and possibly replacing the EGR tube gaskets and torquing the flange ... Read More »
Evaporative System Integrity Monitor switch (ESIM) Prior to replacing this component on a 2015 Dodge Journey (JC), please call Bob Bruni at cell (248) 736-8958. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
Crankshaft Position Sensor Before replacing this part due to a P0335 fault code, please contact Andrew Acton at cell (248) 421-4130. Engineering is interested in the condition(s) present when the fault occurs. Read More »
Camshaft Position Sensor If replacing a camshaft position sensor for P0340, P0344, P0345, P0349, P0365, P0369, P0390 or P0394 fault codes, please review information below and contact Tom Nies on his cell phone: (248) 494-0187. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Improperly Installed Exhaust Gas Recirculation (EGR) Valve This bulletin involves removing and inspecting the vacuum tube, EGR tube gaskets, tube flange mounting bolts and possibly replacing the EGR tube gaskets and torquing the flange ... Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
68085119AE,Inspect and Return: Exhaust Pipe Assy - Frt W/Catalytic Converter You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68085119AE. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
05187880AC - Inspect and Return: Relay Assy - Heater Intake Air You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05187880AC. Read More »
Hard To Fill With Fuel This bulletin involves replacing the fuel tank. Customers may experience one or more of the following:Hard, difficult, or unable to fill the fuel tank. Fuel nozzle shuts off prematurely before the fuel tank is full. Read More »
Customer concern includes Mil-On/Check Engine Lamp-On. There also may or may not be driveability-related concerns that accompany the Mil-On condition. Read More »
3.0L Diesel Crankshaft Tone Wheel Loss of Signal - X94 Warranty Extension This bulletin involves replacing the crankshaft tone wheel. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Dual EVAP System Extreme Duty Vapor Canister Filter Kit This informational bulletin is to make technicians aware that an EVAP dual vapor canister filter kit(Mopar part #68478013AA)is available in place of the OEM single vapor canister ... Read More »
Dual EVAP System Extreme Duty Vapor Canister Filter Kit This informational bulletin is to make technicians aware that an EVAP dual vapor canister filter kit(Mopar part #68478013AA)is available in place of the OEM single vapor canister ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Power Distribution Center If the PDC is being replaced due to a failed internal fuel pump relay, the relay can now be serviced as a separate component. Please use relay replacement KIT part number: 68510768A$. Read More »
Intelligent Power Distribution Center If the PDC requires replacement due to a failed internal fuel pump relay, the relay can now be serviced as a separate component. Please use relay replacement KIT part number: 68510768A$. Read More »
Power Distribution Center If the PDC is being replaced due to a failed internal fuel pump relay, the relay can now be serviced as a separate component. Please use relay replacement KIT part number: 68510768A$. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
3.0L Oil Filter Cartridge Identification Differences And Oil Filter Element Servicing Procedure This bulletin outlines the correct procedure for changing an oil filter on a 3.0L diesel to prevent engine damage. Read More »
3.0L Oil Filter Cartridge Identification Differences And Oil Filter Element Servicing Procedure This bulletin outlines the correct procedure for changing an oil filter on a 3.0L diesel to prevent engine damage. Read More »
Title 68146401AA: Tube - Fuel Filler Start Date: 10/19/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Fuel tank Before replacing this part, please call Keith Kerby on his Cell (248) 420-5540 OR Manuel Gandara on cell (248) 622 8109 ~ Mexican Dealers please call Ricardo Lozada at cell +52 1 55 1370 3187. Read More »
3.0L Diesel Crankshaft Tone Wheel Loss of Signal - X94 Warranty Extension This bulletin involves replacing the crankshaft tone wheel. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
3.0L Oil Filter Cartridge Identification Differences And Oil Filter Element Servicing Procedure This bulletin outlines the correct procedure for changing an oil filter on a 3.0L diesel to prevent engine damage. Read More »
3.0L Oil Filter Cartridge Identification Differences And Oil Filter Element Servicing Procedure This bulletin outlines the correct procedure for changing an oil filter on a 3.0L diesel to prevent engine damage. Read More »
Title Inspection and return of PN 68210332AA - FUEL PRESSURE SENSOR Start Date: 10/6/2015 7:00 AM End Date Message You are receiving this email as you have been identified to have stock on hand or have stock in transit to your dealership. Read More »
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time ... Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
CABLE ASSY, Power Sliding Backlite For concern of power sliding backlight will not close or window binding and replacing cable, please call FCA Redacted Content and send pictures to FCA Redacted Content prior to replacing the part. Read More »
Job aid - If you have a suspected TC shudder/vibration, check the Interactive Network for Service Bulletins for the vehicle you are working on. A test-drive snap shot may help you isolate the source of the issue. Read More »
Power Distribution Center For 2018 DS, prior to replacing the Power Distribution Center (PDC), you MUST contact the STAR Center (800) 850-7827 for diagnostic assistance and preauthorization. Read More »
2014 KL 9-Speed service transaxle with 2015 common hardware This 9-speed transaxle must be ordered thru Mopar?s Powertrain Service Center (PSC) for a specific VIN and must be installed in that vehicle or the correct calibration will ... Read More »
Power Transfer Unit Prior to replacing the PTU, please review the following .~ Check if the service 4WD light is intermittent by driving under heavy throttle will produce a C1494-92 DTC, if yes, please call FCA axle engineering and do ... Read More »
Shifter - Automatic Trans Before this part is replaced for any issue please call John Grzecki on cell (248) 379- 0969. If you do not receive a return call within 15 minutes, proceed with the repair. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Power Transfer Unit Prior to replacing the PTU, please review the following .~ Check if the service 4WD light is intermittent by driving under heavy throttle will produce a C1494-92 DTC, if yes, please call FCA axle engineering and do ... Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
Ambient Air Temperature Missing, Malfunction Indicator Lamp (MIL) Lamp On, Diagnostic Trouble Code (DTC) P0070-15 Ambient Air Temperature Sensor Circuit-Circuit Short to Battery or Open, P0073 Ambient Air Temperature Sensor Circuit ... Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
UAS and UCS Radio Enhancements Customers may experience one or more of the following: **Wi-Fi hotspot connection failure. Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
ENGINE, Complete Due to a shortage of wiring harnesses, this service engine assembly is temporarily being shipped without an engine wiring harness. Read More »
UAS and UCS Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.6 Customers may experience one or more of the following: Intermittent, black radio display screen. Read More »
Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection, Radio Stuck When IPhone Is Connected Read More »
UAS, UAQ, UCS, UAV, UCV and UCQ Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
UAS, UAQ, UCS, UAV, UCV and UCQ Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
UAS, UAQ, UCS, UAV, UCV and UCQ Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
Dual EVAP System Extreme Duty Vapor Canister Filter Kit This informational bulletin is to make technicians aware that an EVAP dual vapor canister filter kit(Mopar part #68478013AA)is available in place of the OEM single vapor canister ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes P0407 ? EGR Sensor B Circuit Low, or P0408 ? EGR Sensor B Circuit High Set Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
CABLE ASSY, Power Sliding Backlite For concern of power sliding backlight will not close or window binding and replacing cable, please call FCA Redacted Content and send pictures to FCA Redacted Content prior to replacing the part. Read More »
UAS, UAQ, UCS and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to:22.6 - DS, D2, DP, DD, DF and DJ vehicle with UAS, UCQ and UAQ radio. 22. Read More »
UAS, UAQ, UCS and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to:22.6 - DS, D2, DP, DD, DF and DJ vehicle with UAS, UCQ and UAQ radio. 22. Read More »
CONDENSER, Air Conditioning If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair ... Read More »
Power Distribution Center For 2018 DS, prior to replacing the Power Distribution Center (PDC), you MUST contact the STAR Center (800) 850-7827 for diagnostic assistance and preauthorization. Read More »
R4801865AC Alternator Assy - 220 Amp You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of part number R4801865AC. Read More »
Hands Free Module - CTM ? Peiker For RT, JK and MK bodies only; Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset ... Read More »
Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold vehicle and contact:~ Contact one of the following:~ Daniel Acciacca CELL (586) 709-1537~ Michael Savich CELL (248) 214-7270~ ... Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Battery - Transmitter For vehicles within 12 Months in Service which have a "FOB Battery Low" message within Cluster or DTC B1A10 or B1A11 Active or Stored. Read More »
Battery Please call Bob Horn at cell (248) 231-3315 prior to replacing any battery. Please identify battery with the last 8 VIN digits along with the 15 digit Medtronic code from the GR-8 tester. Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Read More »
CONNECTOR Trailer Tow,WIRING Trailer Tow,CONNECTOR 7 Way,WIRING Rear Bumper If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in ... Read More »
ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS:ACCESORY POWER OUTLET/JACK/PORT/USB/SAE/CIGARETTE LIGHTER
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 04685719AI. See attachments for identifying suspect stock. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 04685719AI. See attachments for identifying suspect stock. Read More »
Radio Over The Air Software Version Update to 22.66 This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
UAQ and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to: 39.6.The repair procedure must be followed step by step. Read More »
3.0L Diesel Crankshaft Tone Wheel Loss of Signal - X94 Warranty Extension This bulletin involves replacing the crankshaft tone wheel. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Dual EVAP System Extreme Duty Vapor Canister Filter Kit This informational bulletin is to make technicians aware that an EVAP dual vapor canister filter kit(Mopar part #68478013AA)is available in place of the OEM single vapor canister ... Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Inspect and Return: Lamp Assy - Tail Light Rt/L You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68174065AE. See attachments for identifying suspect stock. Read More »
Headlamp Assembly If the headlamp assembly is being replaced, please also replace the harness attached to the headlamp. Engineering would like to have both parts returned for analysis. Read More »
Inspect and Return: Lamp Assy - Tail Light Rt/L You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Handle, Swivel Release and Grommet, Pivot Joint The box bed divider swivel release handle and pivot joint grommet are intended for DS only, and not to be used on DJ or DT. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
GLASS, Backlite, Sliding, Assembly Before replacing this part, please call Lori Millen at (248) 379-1888. If no response in 15 minutes, proceed with repair. Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Read More »
55395241AG Weatherseal - Windshield to Cowl Please return allstock of following part numbers:55395241AG,55395241AE.Replacement ispart number 55395241AH which isin stock and available. Read More »
CABLE ASSY, Power Sliding Backlite For concern of power sliding backlight will not close or window binding and replacing cable, please call FCA Redacted Content and send pictures to FCA Redacted Content prior to replacing the part. Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
A/C Pressure Transducer A/C inoperative and diagnosis leads to pressure transducer. Call Steve Rice at cell (248) 867-0061 before replacing the pressure transducer. If no response in 15 minutes, please proceed with repair. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Title Control Module - Air Bag Electronic Control w/side Capability Start Date: 10/19/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Title Control Module - Air Bag Electronic Control w/side Capability Start Date: 10/19/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
SEAT BELT, Front (RT / LT) Prior to replacing this part take pictures of the conector area at the harness and send to carmen.gonzalez@fcagroup.com. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. Read More »
Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
GLASS, Backlite, Sliding, Assembly Before replacing this part, please call Lori Millen at (248) 379-1888. If no response in 15 minutes, proceed with repair. Read More »
68160775AB: Inspect and Return: Switch - Outside Door Handle You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68160775AB. Read More »
CONNECTOR Trailer Tow,WIRING Trailer Tow,CONNECTOR 7 Way,WIRING Rear Bumper If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in ... Read More »
Nameplate - Ram 1500 2018 RAM 1500 ONLY; Prior to removing/replacing the RAM 1500 badge on either door, please take a picture of the badge if it is crooked only. Please send the pictures to sachin.junagade@fcagroup.com. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair. Read More »
68160775AB: Inspect and Return: Switch - Outside Door Handle You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68160775AB. Read More »
Title 05182600AC: Molding Assy - RR Door LWR RT Start Date: 10/23/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Read More »
Tailgate Cable Has Excessive Slack or is Loose This bulletin involves replacing one of the tailgate cables with a new tailgate service cable. Read More »
Tailgate Cable Has Excessive Slack or is Loose This bulletin involves replacing one of the tailgate cables with a new tailgate service cable. Read More »
04589131AG, 04589243AG - Inspect and Return: Liftgate - Latch Assy You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 04589131AG, 04589243AG . Read More »
Cover - Roof Rack Youhave been identified aseither having stock,or have stock in transit toyour dealership. Please return allsuspect stock of part numbers:68212041AC,68141170AC,55112738AA.See attachmentsfor identifying suspect material. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Inspect and Return: Latch Seat, and Latch Seat Back You have been identified as either having stock, or have stock in transit to your dealership. Read More »
68160775AB: Inspect and Return: Switch - Outside Door Handle You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68160775AB. Read More »
04589131AG, 04589243AG - Inspect and Return: Liftgate - Latch Assy You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 04589131AG, 04589243AG . Read More »
Title Latch Assy. Hood W/AJAR Switch Start Date: 10/6/2015 7:00 AM End Date Message You have been identified as either having stock,or have stock in transit to your dealership. Read More »
P/N 68111384AB: Inspect &Return: Switch - Speed Control You have been identified as either having stock, or have stock in transit to your dealership. Please return parts which have a pacakging date code of July 20th 2016. Read More »
Cruise Control Switch Before ordering or replacing this part please contact Dennis Gauthier at cell (248) 613-9756. If no response is received within 15 minutes, then proceed with required repair. Read More »
Spare Tire Kit For vehicles with Alloy Wheels, an adapter is required (not included) to connect the alloy wheel to the spare tire winch cable when storing under the vehicle. Read More »
Tire pressure monitoring module Prior to replacing tire pressure monitoring module, for DTC's C151D, C1581, please contact Michael Wang at cell (248) 701-5351. Read More »
UAS and UCS Radio Enhancements Customers may experience one or more of the following: **Wi-Fi hotspot connection failure. Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
3.0L Diesel Crankshaft Tone Wheel Loss of Signal - X94 Warranty Extension This bulletin involves replacing the crankshaft tone wheel. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
UAS and UCS Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.6 Customers may experience one or more of the following: Intermittent, black radio display screen. Read More »
CONNECTOR Trailer Tow,WIRING Trailer Tow,CONNECTOR 7 Way,WIRING Rear Bumper If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in ... Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Common portion of a presentation provided to mutiple OEM customers concerning a potential issue and investigation involving a seat adjustment recliner mechanism. Read More »
Recliner - Stow and Go: Return Youhave been identified aseither having stock,or have stock in transit toyour dealership. Please return allstock of following part numbers:68241568AB,68241568AC,68241569AB,68241569AC, 68241570AB,68241571A. Read More »
Inspect and Return: Latch Seat, and Latch Seat Back You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Replacement Seat Covers And Seat Cover Repairs This bulletin involves FCA US LLC position in regard to replacement seat covers and seat cover repairs. Read More »
Element Assy- Heated Seat If any of the Front Heated Seats are Inoperable. Call Mike Wicker at cell (248) 821- 9350 with the Fault Code, so we can determine true root cause. Read More »
Seat belt retractor - rear seat center Prior to ordering this part, call Gary Gebski at (248) 807-5874. If no response in 15 minutes, proceed with ordering the part Read More »
Element Assy- Heated Seat If any of the Front Heated Seats are Inoperable. Call Mike Wicker at cell (248) 821- 9350 with the Fault Code, so we can determine true root cause. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
UAS and UCS Radio Enhancements Customers may experience one or more of the following: **Wi-Fi hotspot connection failure. Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
3.0L Diesel Crankshaft Tone Wheel Loss of Signal - X94 Warranty Extension This bulletin involves replacing the crankshaft tone wheel. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
UAS and UCS Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.6 Customers may experience one or more of the following: Intermittent, black radio display screen. Read More »
UAS, UAQ, UCS, UAV, UCV and UCQ Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer ... Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Molding Assy ?Frt door day light opening Rt/Lt: Return You have been identified as either having stock, or have stock in transit to your dealership. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
UAS and UCS Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.6 Customers may experience one or more of the following: Intermittent, black radio display screen. Read More »
Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection, Radio Stuck When IPhone Is Connected Read More »
PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for ... Read More »
Tailgate Cable Has Excessive Slack or is Loose This bulletin involves replacing one of the tailgate cables with a new tailgate service cable. Read More »
(Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR ... Read More »
Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Improperly Installed Exhaust Gas Recirculation (EGR) Valve This bulletin involves removing and inspecting the vacuum tube, EGR tube gaskets, tube flange mounting bolts and possibly replacing the EGR tube gaskets and torquing the flange ... Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
APPLIQUE, Storage Bin (Rambox) For concern of Rambox applique fading, do not replace the applique. This is due to wax or other chemical substance being used on a grain in molded color part. Read More »
Tonneau Cover - Hard Folding For Replacement Parts and Service Information, please contact the tonneau cover manufacturer Fold-a-Cover at 1-800-322-0522. Read More »
Tonneau Cover - Hard Folding For Replacement Parts and Service Information, please contact the tonneau cover manufacturer Fold-a-Cover at 1-800-322-0522. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
UAS, UAQ, UCS and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to:22.6 - DS, D2, DP, DD, DF and DJ vehicle with UAS, UCQ and UAQ radio. 22. Read More »
BOX, Pickup (assembly) This service part has additional brackets used in manufacturing that will need to be removed by cutting them off prior to installation. This backet is on the front crossmember. Read More »
UAS, UAQ, UCS and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to:28.3 - WD and WK vehicle with UAQ and UCQ radio. 22. Read More »
UAS, UAQ, UCS and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to:22.6 - DS, D2, DP, DD, DF and DJ vehicle with UAS, UCQ and UAQ radio. 22. Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) Engineering is seeking information regarding OFA leaks. Questions/info can be directed to: Bob Jackson (248) 944-0466 - bob.jackson@fcagroup.com Ron Dallison (248-292-9510) ron. Read More »
Job aid - If you have a suspected TC shudder/vibration, check the Interactive Network for Service Bulletins for the vehicle you are working on. A test-drive snap shot may help you isolate the source of the issue. Read More »
Power Distribution Center For 2018 DS, prior to replacing the Power Distribution Center (PDC), you MUST contact the STAR Center (800) 850-7827 for diagnostic assistance and preauthorization. Read More »
Recliner - Stow and Go: Return Youhave been identified aseither having stock,or have stock in transit toyour dealership. Please return allstock of following part numbers:68241568AB,68241568AC,68241569AB,68241569AC, 68241570AB,68241571A. Read More »
Cover - Roof Rack Youhave been identified aseither having stock,or have stock in transit toyour dealership. Please return allsuspect stock of part numbers:68212041AC,68141170AC,55112738AA.See attachmentsfor identifying suspect material. Read More »
Molding Assy ?Frt door day light opening Rt/Lt: Return You have been identified as either having stock, or have stock in transit to your dealership. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 04685719AI. See attachments for identifying suspect stock. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68174065AE. See attachments for identifying suspect stock. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 68143886AA. See attachments for identifying suspect stock. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part number: 68188889AE and replacement part number is 68188889AF which isin stockand available. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part numbers: 1YG06JSCAC, 1YG06KEPAC, 1YG 06KFSAC, 1YG 06KGZAC, 1YG 06KBUAC and replacement part numbers ... Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part number: 05278632AF and replacement part number is 52030379AA which isin stockand available. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of following part numbers: 68141880AH, 68141881AH, 68145625AI, 68145626AI, 68189480AF and replacement part numbers are ... Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of following part numbers: 68036213AA, 68036230AF, 68158196AC, 68158197AD, & 68158454AD. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. As per regulatory compliance: Please return follow ing stock of part numbers: 82214711, 82214712, 82214713, 82214714, 82214715, 82214716, ... Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of part number 68288760AA. Replacement part number is 68288760AB. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1PE001W 7AB, 1PE011W 7AB. See attachments for identifying suspect stock. Read More »
You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 68003062AB, 68003083AB, 68003085AB. See attachments for identifying suspect stock. Read More »
Title 68260866AB: Module Kit - Occupant Classification Start Date: 10/22/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Title MasterShield Products Start Date: 10/28/2015 7:00 AM End Date Message You have been identified as either having MasterShield Products in stock, or have stock in transit to your dealership. Read More »
Title Win Kit - Transmitters and Win Start Date: 10/12/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Message You have been identified as either having stock, or have stock in transit to your dealership. Please return all suspect stock of following part number: 05026886AJ. See the attached file for identifying suspect material. Read More »
Compressor HVAC compressor is inoperative. Before replacing the compressor call FCA Release Engineer Mark Briolat at cell (248) 345-0127. If no response in 15 minutes, continue with the repair. Read More »
Bumper Step Pad Customer may notice the center section of the step pad is not sitting flat. It will appear raised either left or right of center. Please photograph the condition, measure the gap between the bumper and step pad. Read More »
Evaporative System Integrity Monitor switch (ESIM) Prior to replacing this component on a 2015 Dodge Journey (JC), please call Bob Bruni at cell (248) 736-8958. Read More »
STAR receives on average 1,000 contacts per day ? that?s 300,000 annual contacts for technical assistance. This same month last year we had over 40,000 open aged > 5 days tickets. Read More »
ENGINE, Complete Due to a shortage of wiring harnesses, this service engine assembly is temporarily being shipped without an engine wiring harness. Read More »
ENGINE, Complete Due to a shortage of wiring harnesses, this service engine assembly is temporarily being shipped without an engine wiring harness. Read More »
ENGINE, Complete Due to a shortage of wiring harnesses, this service engine assembly is temporarily being shipped without an engine wiring harness. Read More »
UAQ and UCQ Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to: 39.6.The repair procedure must be followed step by step. Read More »
Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection, Radio Stuck When IPhone Is Connected Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
Title Win Kit - Transmitters and Win Start Date: 10/12/2015 7:00 AM End Date Message You have been identified as either having stock, or have stock in transit to your dealership. Read More »
Radio Over The Air Software Version Update to 22.66 This bulletin provides information regarding the latest Firmware Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to ... Read More »
UAS and UCS Radio Enhancements This bulletin involves inspecting and if required, updating the radio software level to 39.6 Customers may experience one or more of the following: Intermittent, black radio display screen. Read More »
Apple CarPlay Malfunctioning, Does Not Launch Or Is Cutting In An Out On Wired And Wireless Connection, Radio Stuck When IPhone Is Connected Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? **Wi-Fi hotspot connection failure. ? Speaker popping, crackle noise during Voice Recognition (VR) response and navigation guidance. Read More »
USB PORT, Media Hub For Android Auto and Apple Carplay issues, do not replace this part. Android Auto and Apple Carplay applications may not operate with the vehicle if an aftermarket cable is being used. Read More »
Title Inspection and return of PN 68210332AA - FUEL PRESSURE SENSOR Start Date: 10/6/2015 7:00 AM End Date Message You are receiving this email as you have been identified to have stock on hand or have stock in transit to your dealership. Read More »
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used Read More »
Tonneau Cover - Hard Folding For Replacement Parts and Service Information, please contact the tonneau cover manufacturer Fold-a-Cover at 1-800-322-0522. Read More »
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington ... Read More »
PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for ... Read More »
Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. Read More »
Improperly Installed Exhaust Gas Recirculation (EGR) Valve This bulletin involves removing and inspecting the vacuum tube, EGR tube gaskets, tube flange mounting bolts and possibly replacing the EGR tube gaskets and torquing the flange ... Read More »
Job aid - If you have a suspected TC shudder/vibration, check the Interactive Network for Service Bulletins for the vehicle you are working on. A test-drive snap shot may help you isolate the source of the issue. Read More »
Bumper Step Pad Customer may notice the center section of the step pad is not sitting flat. It will appear raised either left or right of center. Please photograph the condition, measure the gap between the bumper and step pad. Read More »
CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow ... Read More »
A/C Pressure Transducer A/C inoperative and diagnosis leads to pressure transducer. Call Steve Rice at cell (248) 867-0061 before replacing the pressure transducer. If no response in 15 minutes, please proceed with repair. Read More »
68103256AGReturn: Line Assy - A/C Suction and Liquid You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number 68103256AG packaged before 2016/08/01. Read More »
A/C Compressor This applies to 2015 and 2016 UF and PF. Before replacing the AC compressor for noise, leaks , or in-op:~ After these questions have been answered please call one of the individuals below. Read More »
HVAC Blower and Wheel HVAC blower motor is inoperative. Before replacing the blower motor please call one of these individuals:~ First call Brad Bartkowicz at cell (586) 808-4114~ If no answer, then call Vince Celli at cell (586) ... Read More »
HVAC blower assembly Blower Motor either making noise or is inoperative (even intermittently). Before replacing any of the part numbers listed above, please call any of the following people for each vehicle type. Read More »
Compressor HVAC compressor is inoperative. Before replacing the compressor call FCA Release Engineer Mark Briolat at cell (248) 345-0127. If no response in 15 minutes, continue with the repair. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. When performing diagnosis, an internal engine concern may be suspected. Read More »
