This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Happen to notice something hanging under my truck while in a parking lot. Looked under and the front of my fuel tank was almost touching the ground. After further inspection the front strap had pulled out of the frame that was suppose to be holding it. The frame was completely rusted out and can no longer hold the fuel tank strap. I never received a letter regarding the extended warranty so was unaware of that this issues could occur. Now not covered because the extended warranty expired 20 days ago. First time while owning any vehicle where I though the vehicle was putting me in danger because of a failed component. This should be a safety recall not a extended warranty. I had over 22 gallons of fuel in the tank when it failed.
Went to drive my truck to the store this morning and heard metal scraping against pavement. I immediately pulled over and looked under truck and noticed my fuel tank was hanging down and the front bracket came undone. Luckily was only a couple blocks from the house slowly drove back home so I could more in depth diagnose the issue. I noticed the strap to hold fuel tank up seemed fine but the bracket it sits in, in the frame rusted out causing the strap to come out and the tank to drop. Now no options to fix and without a vehicle until I can get it figured out-?? I did some research and noticed that there was a recall for this and the year of my truck was included so typed my vin on NHTSA and showed my truck has 0 unrepaired recalls but this is a recall and unsafe if I would not have noticed so soon could have been very bad.
The Totally Integrated Power Module (TIPM) system installed in 2009-2012 Ram vehicles is prone to premature failure, resulting in the sudden cessation of the fuel pump while the vehicle is in operation. This critical malfunction poses significant safety hazards, including the potential for collisions with other vehicles, pedestrians, or stationary objects. Despite the persistence of this issue over several years, no official recall has been initiated to address it. Furthermore, in an attempt to mitigate the TIPM's failure and maintain continuous fuel pump operation, some individuals have resorted to unauthorized modifications, commonly referred to as "Jerry rigging, " by bypassing the system with improvised wiring to maintain a constant "hot status." However, this makeshift solution introduces additional risks, including the heightened potential for serious fires due to the bypassed safety mechanisms. Given the severity of these safety concerns and the absence of a comprehensive recall, there is a pressing need for the manufacturer to take decisive action to rectify the TIPM system's deficiencies and ensure the safety of affected vehicles and their occupants.
Gas tank strap is not connected I see a recall on the year of my truck but when I look up my VIN # it dont show my truck having the problem but it says in the recall my truck on it what is the deal with that
The TIPM is failing in several areas... Starter, fuel pump and passenger compartment heater. This seems to be a common problem and Ram has never been held accountable... This plastic box and wires that should cost under a hundred dollars to replace is being sold on line between $500 and $1500 The manufacturer also has a built in design flaw where the electrical auto start function is disabled if the consumer has to replace the battery. They must pay a dealer to reprogram the truck to auto start... Seems like Dodge new they would be robbing the public on both of these items...
- Dutton, VA, USA
Search CarComplaints.com for these popular complaint phrases...
Vehicle i cranks but doesn't always start. I did notice even after it started it seemed to run normally.But when I turn the key off I can still hear fuel pump running. It never shut off. I had to pull the relay fuse. After doing some research. I found that there was or is a safety recall on the fuel pump relay on other Chrysler vehicles having the same issue.Safety recall P54/NHTSA 14V-530. The vehicles that were recalled uses the same tipm as my vehicle. Just wanting to know if you can tell me if my vehicle falls under the same recall if so how can I get it repaired. And if it doesn't fall under the same recall why not. It doesn't seem to be very safe for a fuel pump to be running constantly. I do not have the best of hearing. My wife was the one that noticed that it was still running.
In having my vehicle serviced, my mechanic noticed that one of the straps on my gas tank was corroded and needed to be replaced. He advised me that a safety recall was issued (TSB- 14-002-18) covering this issue. I was never issued a recall notice. I contacted the RAM recall # to raise the issue. I was told by 2 separate agents that the recall was VIN specific and that my RAM was not part of the recall. The vehicle was purchased and registered in CT as new in early 2013. I have been the owner since. When I questioned why the same model having the same issue would not be covered, I was told that is not covered since it was inspected when manufactured. This makes no sense since the issue and notice of recall happened years later. I was told I need to remediate this safety issue at my own expense. Again....this is totally unsatisfactory.
Van shuts off while driving on the highway When attempting to restart no fuel is provided to the fuel rail Engine cranks but remains with a no start condition Negative battery terminal must be disconnected to reset the PCM. After reconnection and reset of PCM vehicle will start. No diagnostic trouble codes are provided through OBD port. No check engine light eliminates Issue has happened numerous times and is documented on the internet through various chat boards
The fuel strap frame bracket failure has occured on my vehicle and i'm wondering why it was not covered under the recall? ref: Safety Recall U04 / NHTSA 18V-160 Frame Bracket
The component affected on my 2012 dodge ram is the front fuel tank strap frame "T slot" bracket that has corroded with water mix with road salt, making the fuel tank to dangle and possibly causing it to drop and make contact with the ground. I know other ram truck have this recall but unfortunately this recall doesn't show up on my vin. The problem has been confirmed by a dealer but unfortunately they cant not fix it unless the recall shows on my vin or i pay out of pocket.
I just received this truck, 2012 RAM 1500, from my uncle. Worked great for a couple of months but then started having issues with the engine stalling and losing power while driving. Then I would have issues getting it to start again. The last time I was stranded was at a friend's house and wasn't able to get it to start again. His cousin that works on cars initially determined it was a fuel pump issue because he could get it to start by spraying ethanol in the engine but wouldn't stay started. Then another friend of his inquired about the truck and he told him the issue. He knew of the known issue with the TIPM in this year/model truck which was a fuel pump relay issue. He was able to clean some contacts and got it to start again which allowed me to get it home. I did some research and it is widely known of this issue with the TIPM. There are even bypass cables you can get for a work around. I do consider this a safety issue since at any time it will stall while driving down the road including once on a highway.
While operating the vehicle at highway speed the vehicle shut off causing total loss of power. This happened on a road with speeds at 55 mph. It also occured while pulling into my driveway at a low speed, and i have had 3 occurences of the vehicle power "surging" at varied speeds. I had the fuel pump replaced, which did not remedy the problem. After hearing my fuel pump running with the vehicle shut off, i did some further research and found that the TIPM (toatally integrated power module) is the culprit and has been found to cause several other electrical system issues. Loss of power in a low speed scenario, such as turning left from one roadway to an intersecting road can cause the vehicle to be stranded in the middle of the road and place the stranded vehicle in the line of incoming traffic posing a serious risk for injury or death from a "T-Bone" motor vehicle crash.
The fuel tank strap frame T -slot bracket corroded and the fuel tank fell upon the ground while traveling on roadway. there is a recall for this but it doesn't look like my vehicle was included.
Failure of fuel pump relay on above listed 2012 Ram 1500 at 69,999 miles. Current repair requires replacement of entire TIPM module (at a cost of $1,000 to 2,000) as this relay is soldered to the circuit board deep inside the module, making it nearly impossible to cost effectively replace this critical $10 part. Of note, the TIPM installed in this vehicle has 10 slots (9 relays installed and 1 open slots) for "replaceable" relays under the cover. Of these replaceable relays at least 2 (blower motor and park lamp) are less critical with one empty slot available. Further a safety recall was issued in December of 2014 (Safety Recall P54/14V530 Fuel Pump Relay) for 2011 models of the Dodge Durango and Jeep Grand Cherokee, but no other models despite that the same or very similar designed TIPM's are used in virtually all Chrysler, Dodge, Ram and Jeep vehicles along with many VW models. If this was a SAFETY ISSUE for select 2011 models, why not the other vehicles using the same or similar TIPM's. Further experience has shown that the Chrysler fix tends to have a high failure rate also. Suggestion: Recall all vehicles with TIPM's which have soldered in Relays, for replacement with a re-designed part which allows for all the relays that can be readily replaced. Further consideration in the design of a new part should include the minimization or elimination of multiple points of failure (is a relay really necessary on a circuit?).
While driving the Vehicle at 9:30pm on 7/22/22 the vehicle suddenly accelerated on its own at a very fast rate after I sped up to yield over into another lane coming off the highway. There was luckily no vehicles ahead of me and I was on a straight away or else I would-??ve hit someone. I pressed the brakes down but they wouldn-??t bring the vehicle to a stop. I placed the transmission in neutral and it slowed down but soon as I put it back in drive it accelerated again. I went through this cycle 4 times then finally I gained control of the vehicle again. I have read online the dealer says it-??s user error or floor mats. That was not the case at all. My floor mats are stock and have taps keeping them secure. This situation was very dangerous and if it happens again it could cause serious injury to me or someone else.
Engine ticking heavily and diminishes some when engine warms up. Vehicle dies randomly while driving and loss of power steering and assisted breaking. Almost had an accident while turning a corner and vehicle died.
A D V E R T I S E M E N T S
- Clarkston , MI, USA