NHTSA — Visibility: Windshield Problems

CarComplaints.com Seal Of Avoid Like The Plague

CarComplaints.com Notes: The 2005 Pontiac G6 has major problems with two areas fairly critical to the act of driving... steering & safety.

The 2005 G6 has a major defect trend with electronic power-assisted steering failure. The power steering cuts out while driving, making it extremely difficult to steer. G6 owners typically report spending $600 - $1,200+ to fix the problem, replacing either the entire steering column or the power assist motor.

In March 2010, GM recalled 1.3 million vehicles for this exact problem "...after receiving 1,100 complaints of power steering failures." However the 2005 G6 wasn't included in that recall.

In July 2010, GM issued a "Special Coverage Adjustment" — TSB #10183 — covering "certain" (not all) 2005, 2006 & 2008 Pontiac G6's for power steering problems, up to 10 years/100k miles.

As of early 2013 the NHTSA had 300+ steering complaints on file for the 2005 G6, with 12 crashes & 4 injuries. The NHTSA closed their initial investigation in 2007, having determined that losing your power steering going over 15-20 mph isn't a big deal & that most crashes occurred at slow speeds, so not a safety risk. Ridiculous? Yep, we think so too.

The 2005 G6 also has an expensive problem with "popping" or "clunking" noises when turning, & that issue extends to newer model years as well.

Factor in the 2005 Pontiac G6's poor side impact protection & you end up with a vehicle you should steer clear of.

9.5

really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
1,000 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2005 Pontiac G6 windows / windshield problems

windows / windshield problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Pontiac G6:

Unsubscribe any time. We don't sell/share your email.

2005 Pontiac G6 Owner Comments

problem #2

Aug 172005

G6 6-cyl

  • Automatic transmission
  • 1,000 miles

A D V E R T I S E M E N T S

Too many complaints to write them all up, here are a few: Engine makes metal grinding "whooshing" noise independent from acceleration-dealer cannot replicate, warped rotors-dealer wanted over $1,000 to fix, have had radio replaced 5 times due to disc errors-dealer keeps replacing, had steering rack and water pump replaced at 30,000 miles-dealer covered, sensor that turns on lights went-dealer replaced, power steering problems, hard to turn and rough, but no "lock-ups" like others have had(thankfully)-dealer cannot replicate, had drivers side front panel sunroof drain clog, water soaked front carpet(3 inches of water)-dealer fixed but left me with a moldy carpet!, engine flutters/stutters to a start on random-dealer has no answer for me, trunk lid was scraping rear bumper due to latches being tightened wrong-dealer fixed, headlamp full of condensation-dealer fixed, car ridiculously bad in the rain and snow, stability control makes loud grinding noises and causes the car to buck, replaced tires with snow tires, still bad-dealer has no answer for me, large deep scratch across windshield right in the line of view from Contour oem windshield wipers, dealer said too bad. Those are just a few, I cant remember them all, this car is such a lemon. Im sticking with Toyota from now on! I learned my lesson!

- East Bridgewater, MA, USA

Add Complaint
problem #1

Oct 152005

G6 6-cyl

  • Automatic transmission
  • 1,000 miles
Car is 3 months old and front windshield has chipped and cracked significantly in several spots at the first contact with any degree of impact(small stones, slow speeds, high speeds, etc). I noticed about 8 little chips all over the glass, inside and out within the first month. Now, there is a huge slit in between the panel of the glass and the entire windshield now needs replacing. There is definitely something wrong with the quality of the glass that was put in this vehicle. I owned a used 1997 Chrysler cirrus for 6 years prior to buying this G6 3 months ago, and I have never experienced even one chip in the windshield and it was driven under the same conditions for the entire life of the car.

- Windsor, 00, USA

Add Complaint

Search CarComplaints.com for these popular complaint phrases...

Dex-Cool lawsuit intake gasket leak engine complaint electrical issue heater complaint transmission complaint paint defect G6 recall

Not what you are looking for?