2000 Mercury Sable

170 Technical Service Bulletins (TSBs)

TSB List for the 2000 Mercury Sable

Technical Service Bulletins (TSBs) for the 2000 Sable are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.

  • SUSPENSION:FRONT
  • SUSPENSION:FRONT:STABILIZER BAR
  • SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
  • SUSPENSION:REAR
  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
  • SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
  • ENGINE AND ENGINE COOLING
  • ENGINE AND ENGINE COOLING:ENGINE
  • ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
  • ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
  • FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
  • FUEL SYSTEM, OTHER
  • POWER TRAIN
  • POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING
  • POWER TRAIN:MANUAL TRANSMISSION
  • POWER TRAIN:AUTOMATIC TRANSMISSION
  • POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
  • POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
  • POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
  • POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
  • POWER TRAIN:DRIVELINE
  • POWER TRAIN:DRIVELINE:DRIVESHAFT
  • POWER TRAIN:AXLE ASSEMBLY
  • ELECTRICAL SYSTEM
  • ELECTRICAL SYSTEM:12V/24V/48V BATTERY
  • ELECTRICAL SYSTEM:WIRING
  • ELECTRICAL SYSTEM:IGNITION
  • ELECTRICAL SYSTEM:IGNITION:SWITCH
  • ELECTRICAL SYSTEM:IGNITION:MODULE
  • ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
  • EXTERIOR LIGHTING:HEADLIGHTS
  • EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
  • EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
  • VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
  • VISIBILITY:SUN/MOON ROOF ASSEMBLY
  • VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT
  • VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW
  • VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
  • AIR BAGS
  • AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
  • AIR BAGS:SIDE/WINDOW
  • SEAT BELTS
  • SEAT BELTS:FRONT:RETRACTOR
  • SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
  • STRUCTURE:BODY
  • STRUCTURE:BODY:DOOR
  • LATCHES/LOCKS/LINKAGES:DOORS:LATCH
  • VEHICLE SPEED CONTROL
  • VEHICLE SPEED CONTROL:LINKAGES
  • VEHICLE SPEED CONTROL:CABLES
  • VEHICLE SPEED CONTROL:CRUISE CONTROL
  • EQUIPMENT
  • EQUIPMENT:ELECTRICAL
  • EQUIPMENT:OTHER:LABELS
  • EQUIPMENT:APPLIANCE:AIR CONDITIONER
  • UNKNOWN OR OTHER

    • SUSPENSION:FRONT

    • TSB #17094

      Date Announced:
      AUG 01, 2003
      NHTSA ID:
      #10003184

      RATTLING OR CLUNKING NOISE FROM THE FRONT SUSPENSION UNDER NORMAL DRIVING CONDITIONS. *TT Read More »

    • TSB #16710

      Date Announced:
      MAR 01, 2003
      NHTSA ID:
      #10001950

      RATTLING OR CLUNKING NOISE FROM THE FRONT SUSPENSION UNDER NORMAL DRIVING CONDITIONS. *TT *JB Read More »

    SUSPENSION:FRONT:STABILIZER BAR

    • TSB #8199

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612411

      SOME VEHICLES MAY EXHIBIT A RATTLING OR CLUNKING NOISE FROM THE FRONT END (FRONT STABILIZER LINK) UNDER NORMAL DRIVING CONDITIONS. Read More »

    SUSPENSION:FRONT:SPRINGS:COIL SPRINGS

    • TSB #TSB-14-0165

      Date Announced:
      SEP 09, 2014
      NHTSA ID:
      #10058102

      MERCURY/FORD: SAFETY RECALL REGARDING FRONT COIL SPRINGS CAN FRACTURE ON VEHICLES OPERATING FOR EXTENDED PERIODS IN HIGH CORROSION AREAS. MODEL 1999-01 TAURUS, SABLE. *PE Read More »

    • TSB #TSB-14-0149

      Date Announced:
      AUG 11, 2014
      NHTSA ID:
      #10056656

      MERCURY/FORD: FRONT COIL SPRINGS CAN FRACTURE, AFTER OPERATING, FOR AN EXTENDED PERIOD OF TIME, IN HIGH CORROSION AREAS, MOVE MOVE PAST SPRING SEAT AND CONTACT RUPTURE FRONT TIRE, RESULTING RAPID AIR LOSS. MODEL 1999-2001 TAURUS, SABLE. Read More »

    SUSPENSION:REAR

    • TSB #0025

      Date Announced:
      JAN 29, 2000
      NHTSA ID:
      #612315

      VEHICLE MAY EXPERIENCE A BUSSING OR GROANING AND OR RATTLING NOISE FROM THE REAR OF THE VEHICLE, VEHICLES BUILT BEFORE 12-11-99. *MJS Read More »

    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

    • TSB #99194

      Date Announced:
      SEP 20, 1999
      NHTSA ID:
      #6090082

      INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »

    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

    • TSB #7819

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612210

      THE ROTER COVERS HAVE BEEN INSTALLED TO REDUCE CORROSION WHILE IN DEALER STORAGE AND REDUCE THE POTENTIAL FOR BRAKE SHUDDER/VIBRATION CONCERNS. THEREFORE; DO NOT REMOVE ROTOR COVER UNTIL JUST PRIOR TO VEHICLE DELIVERY TO THE CUSTOMER. Read More »

    ENGINE AND ENGINE COOLING

    • TSB #041601

      Date Announced:
      NOV 14, 2005
      NHTSA ID:
      #10018745

      WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT Read More »

    • TSB #052212

      Date Announced:
      NOV 14, 2005
      NHTSA ID:
      #10018746

      BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM - NO DTC - 3.0L 2V GAS AND FFV ENGINE. *TT Read More »

    • TSB #18614

      Date Announced:
      MAY 01, 2005
      NHTSA ID:
      #10017916

      SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT Read More »

    • TSB #0361

      Date Announced:
      MAR 31, 2003
      NHTSA ID:
      #10001855

      MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB Read More »

    ENGINE AND ENGINE COOLING:ENGINE

    • TSB #031404

      Date Announced:
      AUG 23, 2004
      NHTSA ID:
      #10011162

      ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »

    • TSB #0415

      Date Announced:
      JAN 26, 2004
      NHTSA ID:
      #10007358

      LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE. DIAGNOSTIC SERVICE TIPS. *TT Read More »

    • TSB #03144

      Date Announced:
      JUL 21, 2003
      NHTSA ID:
      #10003744

      ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »

    • TSB #16982

      Date Announced:
      JUL 01, 2003
      NHTSA ID:
      #10003851

      CLUNKING/POPPING NOISE FROM THE PASSENGER SIDE OF THE ENGINE COMPARTMENT UPON ACCELERATION AND/OR DECELERATION. *TT Read More »

    • TSB #0335

      Date Announced:
      FEB 17, 2003
      NHTSA ID:
      #10002482

      IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT Read More »

    • TSB #0322

      Date Announced:
      FEB 03, 2003
      NHTSA ID:
      #10002472

      STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS ... Read More »

    • TSB #02221

      Date Announced:
      NOV 11, 2002
      NHTSA ID:
      #10008304

      ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ Read More »

    • TSB #870197

      Date Announced:
      OCT 22, 2002
      NHTSA ID:
      #10000592

      INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »

    • TSB #01124

      Date Announced:
      JUN 25, 2001
      NHTSA ID:
      #622665

      ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT Read More »

    • TSB #14355

      Date Announced:
      SEP 01, 2000
      NHTSA ID:
      #618630

      INFORMATION PERTAINING TO DURATEC OIL PAN INVESTIGATION. *JB Read More »

    • TSB #00B34

      Date Announced:
      FEB 04, 2000
      NHTSA ID:
      #610228

      SOME VEHICLES WITH 3.0L 2V VULCAN ENGINES MAY BE EQUIPPED WITH A CAMSHAFT THAT WAS INCORRECTLY HEAT TREATED DURING THE MANUFACTURING PROCESS. Read More »

    • TSB #14355

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #620504

      EXHIBITING AN OIL LEAK FROM THE ENGINE OIL PAN. *TT Read More »

    • TSB #6997

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090310

      SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT Read More »

    • TSB #13180

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090538

      INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS Read More »

    • TSB #996874

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608805

      SUBJECT PERTAINING TO THE SBDS RELATIVE CAM TIMING TEST WHICH HAS BEEN TEMPORARILY REMOVED FROM USE ON SOME VEHICLES DUE TO NOISE CONCERNS. *TT Read More »

    • TSB #13101

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091905

      SUBJECT REGARDING THE SBDS RELATIVE CAM TIMING TEST. *TT Read More »

    ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

    • TSB #15674

      Date Announced:
      FEB 01, 2002
      NHTSA ID:
      #630738

      SOME VEHICLES MAY EXHIBIT ENGINE SPARK KNOCK CONDITION ON ACCELERATION. *TT Read More »

    • TSB #0214

      Date Announced:
      JAN 21, 2002
      NHTSA ID:
      #630001

      SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »

    • TSB #01246

      Date Announced:
      DEC 10, 2001
      NHTSA ID:
      #630515

      ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT Read More »

    • TSB #15481

      Date Announced:
      DEC 01, 2001
      NHTSA ID:
      #630587

      SOME VEHICLES WITH 3.0L 2V AND 3.0L FFV ENGINES MAY EXHIBIT SPARK KNOCK DURING LIGHT ACCELERATOR TIP IN OR HEAVY ACCELERATION. *TT Read More »

    • TSB #01205

      Date Announced:
      OCT 15, 2001
      NHTSA ID:
      #627927

      SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »

    • TSB #01191

      Date Announced:
      OCT 01, 2001
      NHTSA ID:
      #627677

      SOME VEHICLES BUILT PRIOR TO 10/5/2000 EQUIPPED WITH THE 3.0L 24-VALVE DURATEC ENGINE MAY EXHIBIT COLD ENGINE LONG CRANK/HAND START, TRANSMISSION SHUDDER/VIBRATION, HARSH DOWNSHIFT COASTING, AND ERRONEOUS CODE P1443 STORED. Read More »

    • TSB #0143

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619420

      SOME VEHICLES MAY EXHIBIT A FUEL ODOR NOTICED THROUGH THE VENTS INSIDE THE VEHICLE. THE ODOR MAY BE NOTICED UPON INITIAL STARTUP AFTER HOT SOAK. Read More »

    • TSB #0147

      Date Announced:
      MAR 05, 2001
      NHTSA ID:
      #619424

      SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT Read More »

    • TSB #00255

      Date Announced:
      DEC 11, 2000
      NHTSA ID:
      #616822

      SOME VEHICLES EQUIPPED WITH THE 3.0L 2-VALVE ENGINE MAY EXHIBIT A SPARK KNOCK CONDITION ON HEAVY ACCELERATION WITH 87 OCTANE GASOLINE. *TT Read More »

    • TSB #00B55

      Date Announced:
      SEP 01, 2000
      NHTSA ID:
      #618566

      INFORMATION REGARDING ENGINE PERFORMANCE, REPROGRAMMING OF POWERTRAIN CONTROL MODULE. *JB Read More »

    • TSB #8583

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613689

      SOME VEHICLES MAY EXHIBIT DTC P1518 AND / OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC). *MR Read More »

    • TSB #7927

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612414

      REVISED ENGINE OIL INDICATOR (DIPSTICK) GRAPHICS. THE FULL LEVEL IS BETWEEN THE MIN AN MAX. IF THE OIL READING IS BETWEEN THE MARKINGS THE LEVEL IS ACCEPTABLE, DO NOT ADD OIL. Read More »

    • TSB #13770

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612797

      VEHICLES WITH 3.0L 2-VALVE VULCAN ENGINE HAVE REVISED ENGINE OIL INDICATOR (DIPSTICK) GRAPHICS. *MJS Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

    • TSB #8194

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612406

      SOME VEHICLE EQUIPPED WITH 3.0L 4-VALVE DURATEC ENGINES BUILT PRIOR TO FEBRUARY 8TH, 2000 MAY EXHIBIT AN INTERMITTENT EXHAUST RINGING NOISE. *TT Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

    • TSB #02M01

      Date Announced:
      JUN 01, 2004
      NHTSA ID:
      #10007207

      CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. Read More »

    • TSB #7857

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612223

      SOME VEHICLES EQUIPPED WITH A 3.0L 2-VALVE ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH A DIAGNOSTIC TROUBLE CODE P0401 AND / OR P1408 STORED IN MEMORY. THIS MAY BE CAUSED BY INSUFFICIENT EXHAUST GAS RECIRCULATION FLOW. Read More »

    • TSB #7857

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612218

      VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH A DIAGNOSTIC TROUBLE CODE (DTC) P0401 AND/OR P1408 STORED IN MEMORY. Read More »

    ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

    • TSB #14074

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #620296

      THIS BULLETIN STATES THAT CERTAIN VEHICLES' POWERTRAIN CONTROL MODULE (PCM) REQUIRE A FINAL DRIVE RATIO (NOT AXLE RATIO) AND TIRE REVOLUTION PER MILE INFORMATION DURING A PCM REPLACEMENT OR PCM RE-PROGRAM. Read More »

    • TSB #00204

      Date Announced:
      OCT 02, 2000
      NHTSA ID:
      #618542

      ON SOME VEHICLES, THE EXHAUST PIPE CONTACTS THE REAR CONTROL ARM RESULTING IN BUZZING, GROANING AND / OR RATTLING NOISE FROM THE REAR OF THE VEHICLE. *JB Read More »

    FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

    • TSB #14087

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613729

      SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1518 AND/OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC). **MR Read More »

    • TSB #7315

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609600

      VEHICLES WITH 3.0L 4-VALVE ENGINES MAY EXHIBIT A SLIGHT HISS OR VACCUM LEAK TYPE SOUND FROM THE INTAKE MANIFOLD / THROTTLE BODY AREA. *TT Read More »

    FUEL SYSTEM, OTHER

    • TSB #0398

      Date Announced:
      MAY 12, 2003
      NHTSA ID:
      #10002780

      MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT Read More »

    POWER TRAIN

    • TSB #17358

      Date Announced:
      AUG 01, 2004
      NHTSA ID:
      #10008183

      GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT Read More »

    • TSB #16678

      Date Announced:
      MAR 01, 2003
      NHTSA ID:
      #10001934

      AX4S TRANSAXLE MAY EXHIBIT NO REVERSE ENGAGEMENT CONDITION. *TT *JB Read More »

    • TSB #15820

      Date Announced:
      APR 01, 2002
      NHTSA ID:
      #637556

      SOME VEHICLES EQUIPPED WITH AN AX4N/4F50N TRANSAXLE MAY EXHIBIT A SHUDDER DURING A 3-4 SHIFT. *TT Read More »

    • TSB #15370

      Date Announced:
      NOV 01, 2001
      NHTSA ID:
      #630351

      SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT Read More »

    • TSB #15392

      Date Announced:
      NOV 01, 2001
      NHTSA ID:
      #630356

      SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT Read More »

    • TSB #14566

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617948

      SOME VEHICLES BUILT BEFORE 12/17/99 EQUIPPED WITH 3.0LV-2V (VULCAN) ENGINE AND AX4S TRANSAXLE AND BUILT BEFORE 01/14/2000 WITH AN AX4N TRANSAXLE MAY EXHIBIT A GROWL OR SCRAPING SOUND DURING ACCELERATION FROM A STOP. Read More »

    • TSB #7866

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612258

      THE VEHICLE MAY EXHIBIT A DTC P0720 AND P0722; OUTPUT SHAFT SPEED (OSS) SENSOR CONCERNS. Read More »

    POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING

    • TSB #8242

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613625

      SOME VEHICLES MAY EXHIBIT TRANSMISSION FLUID AT THE BELL HOUSING AREA. **MR Read More »

    • TSB #8242

      Date Announced:
      MAR 01, 2000
      NHTSA ID:
      #612678

      SOME VEHICLES BUILT BEFORE NOVEMBER, 1999 MAY EXHIBIT TRANSMISSION FLUID AT THE BELL HOUSING AREA. *TT Read More »

    • TSB #13924

      Date Announced:
      MAR 01, 2000
      NHTSA ID:
      #612914

      SOME VEHICLES BUILT BEFORE NOVEMBER 1999 MAY EXHIBIT TRANSMISSION FLUID AT THE BELL HOUSING AREA. *TT Read More »

    POWER TRAIN:MANUAL TRANSMISSION

    • TSB #15559

      Date Announced:
      JAN 01, 2002
      NHTSA ID:
      #630095

      SUBJECT REGARDING SHUDDER WHILE IN REVERSE. *YH Read More »

    • TSB #8484

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613648

      INFORMATION REGARDING SOME VEHICLES EXHIBITING VARIOUS DRIVEABILITY OR TRANSMISSION SHIFT RELATED PROBLEMS. **MR Read More »

    • TSB #14041

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613725

      SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY OR TRANSMISSION SHIFT RELATED SYMPTOMS. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION

    • TSB #14041

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #620295

      SOME VEHICLES MAY EXHIBIT VARIOUS DIAGNOSTIC TROUBLE CODES (DTCS) P1233, P1235, P1237, P0191) AND / OR DRIVEABILITY / TRANSMISSION SHIFTING CONCERNS DUE TO WIRING THAT HAS BECOME CHAFED ON THE TOP OF THE TRANSMISSION PAN OR THE BRACKET ... Read More »

    • TSB #0015

      Date Announced:
      JAN 10, 2000
      NHTSA ID:
      #612203

      INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

    • TSB #042107

      Date Announced:
      DEC 13, 2004
      NHTSA ID:
      #10014086

      GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »

    • TSB #04217

      Date Announced:
      NOV 01, 2004
      NHTSA ID:
      #10013369

      GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »

    • TSB #14854

      Date Announced:
      APR 01, 2001
      NHTSA ID:
      #619331

      SOME VEHICLES EQUIPPED WITH A 3.0L 2 VALVE ENGINE AND AX4N TRANSAXLE MAY EXHIBIT A CLOSED THROTTLE, DOWNHILL, SURGE SENSATION AT 25 MPH DURING A 2-3 SHIFT WITH NO INCREASE IN VEHICLE SPEED. Read More »

    • TSB #14728

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #619474

      SOME VEHICLES EQUIPPED WITH 3.0L 2-VALVE ENGINE AND VEHICLES EQUIPPED WITH 3.0L 2V/4V MAY EXHIBIT INTERMITTENT NO STARTER CRANK AND / OR AUDIO MUTING IN PARK AND NEUTRAL OR AN INOPERATIVE CONTROL MODULE (PCM) FAULT. Read More »

    • TSB #14074

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #620296

      THIS BULLETIN STATES THAT CERTAIN VEHICLES' POWERTRAIN CONTROL MODULE (PCM) REQUIRE A FINAL DRIVE RATIO (NOT AXLE RATIO) AND TIRE REVOLUTION PER MILE INFORMATION DURING A PCM REPLACEMENT OR PCM RE-PROGRAM. Read More »

    • TSB #8536

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613668

      INFORMATION REGARDING PCM PROGRAMMING PER ONP 00B38. **MR Read More »

    • TSB #8562

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613678

      INFORMATION ON CONFIGURING AXLE RATIO WITH THE NGS OR WDS. **MR Read More »

    • TSB #14074

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613697

      ALL VEHICLES CONTAINING POWERTRAIN CONTROL MODULES (PCM) REQUIRE AXLE RATIO AND TIRE REVOLUTION PER MILE INFORMATION DURING A PCM REPLACEMENT OR PCM REPROGRAM. **MR Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

    • TSB #03148

      Date Announced:
      JUL 21, 2003
      NHTSA ID:
      #10003748

      NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

    • TSB #03123

      Date Announced:
      JUN 23, 2003
      NHTSA ID:
      #10002684

      TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT Read More »

    POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

    POWER TRAIN:DRIVELINE

    • TSB #05145

      Date Announced:
      NONE PROVIDED
      NHTSA ID:
      #10016808

      ERRATIC FLUID LEVEL READING ON TRANSAXLE DIPSTICK-LEAKS-4F50N, AX4N, AX4S TRANSAXLE. *SC Read More »

    POWER TRAIN:DRIVELINE:DRIVESHAFT

    • TSB #13826

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612883

      SOME VEHICLES MAY EXHIBIT A DTC OF PO720,PO722, OUTPUT SHAFT SPEED SENSOR (OSS). *MJS Read More »

    POWER TRAIN:AXLE ASSEMBLY

    • TSB #15059

      Date Announced:
      JUL 01, 2001
      NHTSA ID:
      #621059

      CONCERNS WITH VEHICLES EQUIPPED WITH A AX4N / 4F50N TRANSAXLE EXHIBITING A SHUDDER DURING A 3-4 SHIFT. *TT Read More »

    • TSB #01125

      Date Announced:
      JUN 25, 2001
      NHTSA ID:
      #622671

      SOME VEHICLES EQUIPPED WITH A 3.0L 2 VALVE ENGINE AND AZ4N TRANSAXLE MAY EXHIBIT A CLOSED THROTTLE, DOWNHILL, SURGE SENSATION AT 40 KM/H (25 MPH). DURING A 2-3 SHIFT WITH NO INCREASE IN VEHICLE SPEED. Read More »

    • TSB #14920

      Date Announced:
      MAY 01, 2001
      NHTSA ID:
      #620184

      SUBJECT REGARDING AX4N TRANSAXLE DIAGNOSTIC PINT POINT TEST C3 ERROR. *TT Read More »

    • TSB #14911

      Date Announced:
      MAY 01, 2001
      NHTSA ID:
      #620222

      SOME VEHICLES EQUIPPED WITH AX4N OR 4F50N TRANSAXLE MAY EXHIBIT A FLUID LEAK FROM THE MAIN CONTROL COVER AREA. *TT Read More »

    • TSB #14220

      Date Announced:
      JUN 01, 2000
      NHTSA ID:
      #613907

      SOME VEHICLES EQUIPPED WITH AN AX4N TRANSAXLE MAY EXHIBIT A SHUDDER DURING A 3-4 SHIFT. *TT Read More »

    • TSB #8306

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613635

      SOME VEHICLES MAY EXHIBIT FLUID VISIBLE AROUND THE TOP FRONT CORNER OF THE CHAIN COVER. **MR Read More »

    • TSB #8359

      Date Announced:
      MAR 02, 2000
      NHTSA ID:
      #612764

      SOME VEHICLES EQUIPPED WITH A 3.0L-2V (VALCAN) ENGINE, BUILT BEFORE 12/17/1999 WITH AX4S TRANSAXLE AND 1/14/2000 WITH AX4N TRANSAXLES MAY EXHIBIT A GROWL OR SCRAPING SOUND DURING ACCELERATION FROM A STOP. Read More »

    • TSB #8306

      Date Announced:
      MAR 01, 2000
      NHTSA ID:
      #612725

      SOME VEHICLES BUILT 1/19/2000 THROUGH 2/11/2000 WITH AX4N TRANSAXLE MAY EXHIBIT FLUID VISIBLE AROUND THE TOP FRONT CORNER OF THE CHAIN COVER IN THE AREA OF THE TRANSAXLE SIDE PAN, 8 MM CORNER BOLT AND THREADED HOLE BEHIND THE SIDE PAN BOLT. Read More »

    • TSB #13985

      Date Announced:
      MAR 01, 2000
      NHTSA ID:
      #612940

      VEHICLES BUILT 1/19/2000 THROUGH 2/11/2000 WITH AX4N TRANSAXLE MAY EXHIBIT FLUID VISIBLE AROUND THE TOP FRONT CORNER OF THE CHAIN COVER IN THE AREA OF THE TRANSAXLE SIDE PAN, 8 MM CORNER BOLT AND THREADED HOLE BEHIND THE SIDE PAN BOLT. Read More »

    • TSB #13986

      Date Announced:
      MAR 01, 2000
      NHTSA ID:
      #612960

      SOME VEHICLES EQUIPPED WITH 3.0L-2V (VULCAN) ENGINE, BUILT BEFORE 12/17/99 WITH AX4S TRANSAXLE AND 1/15/00 WITH AX4N TRANSAXLE MAY EXHIBIT A GROWL OR SCRAPING SOUND DURING ACCELRATION FROM A STOP. Read More »

    • TSB #8053

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612264

      SOME VEHICLES MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE OF P0720, P0722; OUTPUT SHAFT SPEED SENSOR (OSS). *TT Read More »

    • TSB #14220

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #620388

      INFORMATION USED TO SERVICE AX4N TRANSAXLE EQUIPPED VEHICLES EXHIBITING SHUDDER DURING 3-4 SHIFT. *TT Read More »

    • TSB #99202

      Date Announced:
      OCT 04, 1999
      NHTSA ID:
      #6089641

      THIS BULLETIN MENTIONS THAT SOME VEHICLES WITH AN AX4S OR AX4N TRANSAXLES HAVE A NEW REDESIGNED PARK SYSTEM IN THE TRANSAXLE. *TT Read More »

    • TSB #99184

      Date Announced:
      SEP 06, 1999
      NHTSA ID:
      #6090053

      SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT Read More »

    • TSB #6918

      Date Announced:
      SEP 01, 1999
      NHTSA ID:
      #6090260

      INFORMATION ON THE REDESIGNED PARK SYSTEM IN VEHICLES WITH AX4S TRANSAXLES. *TT Read More »

    • TSB #99171

      Date Announced:
      AUG 23, 1999
      NHTSA ID:
      #607638

      SOME AX4N TRANSAXLES WILL HAVE A GREEN PRIOR TO REPAIR TAG ON THE LOWER PAN. THE GREEN TAG REFERS TO THIS TSB ARTICLE AND PROVIDES A TOLL-FREE PHONE NUMBER TO BE USED BY ALL US AND CANADIAN DEALERS FOR FURTHER SERVICE DIRECTION. Read More »

    • TSB #99165

      Date Announced:
      AUG 09, 1999
      NHTSA ID:
      #607659

      SERVICE PROCEDURE FOR BLUE SERVICE TAGGED TRANSAXLES. *TT Read More »

    • TSB #996735

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #608455

      SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT Read More »

    • TSB #13151

      Date Announced:
      AUG 01, 1999
      NHTSA ID:
      #6091962

      SUBJECT REGARDING A REDESIGNED PARK SYSTEM IN AX4S AND AX4N TRANSAXLE. *TT Read More »

    ELECTRICAL SYSTEM

    • TSB #04174

      Date Announced:
      SEP 06, 2004
      NHTSA ID:
      #10013116

      MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »

    • TSB #04111

      Date Announced:
      JUN 14, 2004
      NHTSA ID:
      #10008252

      STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »

    • TSB #17899

      Date Announced:
      JUN 01, 2004
      NHTSA ID:
      #10008272

      MALFUNCTION INDICATOR LAMP (MIL) ON WITH MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS). *TT Read More »

    • TSB #03223

      Date Announced:
      JAN 26, 2004
      NHTSA ID:
      #10007360

      STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »

    • TSB #03203

      Date Announced:
      OCT 13, 2003
      NHTSA ID:
      #10004886

      MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »

    • TSB #03181

      Date Announced:
      SEP 15, 2003
      NHTSA ID:
      #10004027

      REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »

    ELECTRICAL SYSTEM:12V/24V/48V BATTERY

    • TSB #0245

      Date Announced:
      MAR 04, 2002
      NHTSA ID:
      #636065

      INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT Read More »

    ELECTRICAL SYSTEM:WIRING

    • TSB #99222

      Date Announced:
      OCT 18, 1999
      NHTSA ID:
      #6089681

      SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »

    ELECTRICAL SYSTEM:IGNITION

    • TSB #15280

      Date Announced:
      SEP 01, 2001
      NHTSA ID:
      #625820

      SOME VEHICLESMAY EXHIBIT AN INTERMITTENT STICKING/BINDING IGNITION KEY LOCK CYLINDER AT OR NEAR THE START POSITION. *JG Read More »

    ELECTRICAL SYSTEM:IGNITION:SWITCH

    • TSB #012113

      Date Announced:
      OCT 29, 2001
      NHTSA ID:
      #627774

      SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »

    ELECTRICAL SYSTEM:IGNITION:MODULE

    • TSB #15828

      Date Announced:
      APR 01, 2002
      NHTSA ID:
      #637571

      SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE B1213, B1342, B1601, B2431. *TT Read More »

    ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

    • TSB #0162

      Date Announced:
      APR 02, 2001
      NHTSA ID:
      #619266

      VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT Read More »

    • TSB #7953

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612462

      ALL VEHICLES WITH SECURILOCK (PARTS) DO NOT USE THE SAME TYPE OF IGNITION KEY. DIFFERENT PATS KEYS EXIST FOR DIFFERENT VEHICLES. Read More »

    • TSB #8018

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612573

      THE KEYLESS ENTRY KEYPAD MAY REQUIRE THE NEED TO ACCESS THE KEYPAD CODE FOR THE VEHICLE. A KEYPAD CODE CARD SHOULD BE FOUND IN THE GLOVE BOX. Read More »

    • TSB #13568

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610937

      SERVICE TIP INFORMATION REGARDING THE PASSIVE ANTI-THEFT (PATS) SYSTEM. *TT Read More »

    EXTERIOR LIGHTING:HEADLIGHTS

    • TSB #99227

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #6089688

      SOME VEHICLES MAY HAVE MOISTURE / CONDENSATION VISIBLE IN THE HEADLAMP OR TAILLAMP OUTER EDGE AREAS AFTER WASHING OR RAINFALL. *TT Read More »

    EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

    • TSB #02176

      Date Announced:
      SEP 02, 2002
      NHTSA ID:
      #10008580

      LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »

    • TSB #0251

      Date Announced:
      MAR 04, 2002
      NHTSA ID:
      #636069

      ON SOME VEHICLES, THERE MAY BE AN INADVERTENT STOP LAMP SWITCH ACTIVATION WITH THE BRAKE PEDAL NOT DEPRESSED. *TT Read More »

    EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

    • TSB #99243

      Date Announced:
      NOV 29, 1999
      NHTSA ID:
      #6090186

      ON SOME VEHICLES, THE FRONT WINDSHIELD WIPERS MAY OPERATE WHILE THE MULTIFUNCTION SWITCH IS IN THE OFF POSITION. *TT Read More »

    VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

    • TSB #05227

      Date Announced:
      NOV 14, 2005
      NHTSA ID:
      #10018742

      POWER WINDOW CONCERNS - SERVICE TIP. *TT Read More »

    • TSB #04223

      Date Announced:
      NOV 15, 2004
      NHTSA ID:
      #10013395

      GRUNTING NOISE FROM FRONT POWER WINDOW GLASS IS POWERED TO THE FULL UP POSITION. *EH Read More »

    • TSB #0325

      Date Announced:
      FEB 03, 2003
      NHTSA ID:
      #10002475

      GRUNTING NOISE FROM FRONT POWER WINDOW AFTER GLASS IS POWERED TO THE FULL-UP POSITION. *TT Read More »

    • TSB #00263

      Date Announced:
      DEC 22, 2000
      NHTSA ID:
      #616828

      SOME VEHICLES MAY EXHIBIT A POWER WINDOW THAT WILL NOT OPERATE DOWNWARD BECAUSE IT'S STUCK / BOUND TO THE WEATHERSHIP HEADER. *TT Read More »

    • TSB #13804

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612821

      SOME VEHICLES EQUIPPED WITH A KEYLESS ENTRY KEYPAD MAY REQUIRE THE NEED TO ACCESS THE KEYPAD CODE FOR THE VEHICLE. *MJS Read More »

    • TSB #7319

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #609604

      SOME VEHICLES MAY EXHIBIT AN ERROR MESSAGE ON THE NEW GENERATION STAR TESTER (NGS) WHEN ATTEMPTING TO ENABLE / DISABLE THE BELTMINDER, AUTOLOCK, AND (DOOR LOCKED) HORN CHIRP FEATURES. *TT Read More »

    • TSB #13407

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6092205

      INFORMATION ON ENABLING / DISABLING THE BELTMINDER / AUTOLOCK / HORN CHIRP. *TT Read More »

    VISIBILITY:SUN/MOON ROOF ASSEMBLY

    • TSB #8087

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613619

      SOME VEHICLES MAY EXHIBIT A BINDING, RATTLING, OR INOPERABLE MOONROOF THAT MAY BE DIFFICULT TO DIAGNOSE. **MR Read More »

    VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

    • TSB #041514

      Date Announced:
      AUG 09, 2004
      NHTSA ID:
      #10011159

      REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT Read More »

    • TSB #031501

      Date Announced:
      JUL 12, 2004
      NHTSA ID:
      #10009321

      INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT Read More »

    • TSB #02236

      Date Announced:
      NOV 25, 2002
      NHTSA ID:
      #10008314

      ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT Read More »

    VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW

    • TSB #04189

      Date Announced:
      DEC 13, 2004
      NHTSA ID:
      #10014062

      REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT Read More »

    VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

    • TSB #01156

      Date Announced:
      AUG 06, 2001
      NHTSA ID:
      #623944

      SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »

    AIR BAGS

    • TSB #14666

      Date Announced:
      FEB 01, 2001
      NHTSA ID:
      #619163

      SOME VEHICLES EQUIPPED WITH SEAT SIDE AIR BAGS MAY EXHIBIT A DIFFICULT TO DIAGNOSE AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODE B1994 OR B1998 (OPEN / RESISTANCE IN THE DRIVER / PASSENGER SEAT AIR BAG CIRCUIT). Read More »

    • TSB #14579

      Date Announced:
      JAN 01, 2001
      NHTSA ID:
      #617964

      SOME VEHICLES EQUIPPED WITH SIDE SEAT AIR BAGS MAY EXHIBIT AN INTERMITTENT AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODES U2017 AND / OR U2018 (SIDE CRASH SENSOR COMMUNICATIONS ERROR) STORED IN MEMORY. Read More »

    AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

    • TSB #15016

      Date Announced:
      JUN 01, 2001
      NHTSA ID:
      #622831

      SOME VEHICLES MAY EXHIBIT A DIFFICULT TO DIAGNOSE AIR BAG LIGHT ON WITH A DIAGNOSTIC CODE C1946 (DRIVER SEAT TRACK POSITION SENSOR CIRCUIT MALFUNCTION) STORED IN MEMORY. *TT Read More »

    • TSB #14533

      Date Announced:
      DEC 01, 2000
      NHTSA ID:
      #616871

      SOME VEHICLES EQUIPPED WITH SIDE SEAT AIR BAGS MAY EXHIBIT AN INTERMITTENT AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODES (DTC) U2017 AND / OR U2018 (SIDE CRASH SENSOR COMMUNICATIONS ERROR) STORED IN MEMORY. Read More »

    • TSB #14579

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #620475

      VEHICLES EQUIPPED WITH SIDE SEAT AIR BAGS MAY EXHIBIT AN INTERMITTENT AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODES U2017 AND / OR U2018 (SIDE CRASH SENSOR COMMUNICATIONS ERROR) STORED IN MEMORY. Read More »

    • TSB #13472

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610888

      FOR VEHICLES THAT REQUIRE CONFIGURATION OF THE ELECTRONIC CRASH SENSOR MOUDLE TO SETTINGS OTHER THAN THE PRESET SETTINGS, THE CONFIGURATION INSTRUCTIONS WERE OMITTED FROM THE SHOP MANUAL. *TT Read More »

    AIR BAGS:SIDE/WINDOW

    • TSB #14812

      Date Announced:
      APR 01, 2001
      NHTSA ID:
      #619312

      SOME VEHICLES EQUIPPED WITH SIDE SEAT AIR BAGS BUILT PRIOR TO JUNE 1, 2001 MAY EXHIBIT AN AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODE B1994 AND / OR B1998 (OPEN / HIGH RESISTANCE IN THE DRIVER / PASSENGER SIDE SEAT AIR BAG CIRCUITS). Read More »

    SEAT BELTS

    • TSB #05310

      Date Announced:
      FEB 21, 2005
      NHTSA ID:
      #10012954

      SAFETY BELT WEB STOP BUTTON SERVICE. *EH Read More »

    SEAT BELTS:FRONT:RETRACTOR

    SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

    • TSB #0125

      Date Announced:
      FEB 05, 2001
      NHTSA ID:
      #619147

      SEAT BELT WARNING SYSTEM - BELT REMINDER FUNCTION, OPERATION AND SERVICE TIPS. *TT Read More »

    STRUCTURE:BODY

    • TSB #04251

      Date Announced:
      DEC 27, 2004
      NHTSA ID:
      #10014165

      ALUMINUM CORROSION - SERVICE TIP. *TT Read More »

    • TSB #16315

      Date Announced:
      OCT 01, 2002
      NHTSA ID:
      #10013080

      HEADLINER GRAB HANDLES LOOSEN. *TT Read More »

    • TSB #8087

      Date Announced:
      FEB 01, 2000
      NHTSA ID:
      #612281

      SOME VEHICLES MAY EXHIBIT A BINDING, RATTLING OR AN INOPERABLE MOONROOF THAT MAY BE DIFFICULT TO DIAGNOSE. *TT Read More »

    STRUCTURE:BODY:DOOR

    • TSB #99242

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090184

      INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT Read More »

    LATCHES/LOCKS/LINKAGES:DOORS:LATCH

    • TSB #05224

      Date Announced:
      NOV 14, 2005
      NHTSA ID:
      #10018738

      POWER LOCK CONCERNS - SERVICE TIP. *TT Read More »

    VEHICLE SPEED CONTROL

    • TSB #13732

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612727

      SOME VEHICLES EQUIPPED WITH 3.0L 2-VALVE ENGINES MAY EXHIBIT A CRANKS NO-START, ROUGH IDLE, MALFUNCTION INDICATOR LAMP AND/OR ANY DRIVEABILITY SYMPTOM ASSOCIATED WITH A RICH OR LEAN FUEL MIXTURE. Read More »

    VEHICLE SPEED CONTROL:LINKAGES

    • TSB #7906

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612394

      FUEL PRESSURE SENSOR CONTAMINATION, CAUSING CRANKS NO-START,ROUGH IDLE, MALFUNCTION INDICATIOR LAMP AND/OR ANY DRIVEABILITY SYMPTOM ASSOCIATED WITH A RICH OR LEAN FUEL MIXTURE. Read More »

    • TSB #13403

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6092197

      VEHICLES WITH 3.0L 4V ENGINES MAY EXHIBIT A SLIGHT HISS OR VACUUM LEAK TYPE SOUND FROM THE INTAKE MANIFOLD / THROTTLE BODY AREA. *TT Read More »

    VEHICLE SPEED CONTROL:CABLES

    • TSB #CSP-13B04

      Date Announced:
      JUN 21, 2013
      NHTSA ID:
      #10052600

      FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPEED CONTROL CABLE IS SUSCEPTIBLE TO DAMAGE AND CAN DISCONNECT DURING HOOD MAINTENANCE AND ALSO INTERFERE WITH FULL THROTTLE RETURN TO IDLE AFTER RELEASING ACCELERATOR PEDAL. Read More »

    VEHICLE SPEED CONTROL:CRUISE CONTROL

    • TSB #13732

      Date Announced:
      MAR 01, 2001
      NHTSA ID:
      #620268

      SOME VEHICLES BUILT PRIOR TO 12/20/1999 EQUIPPED WITH 3.0L 2-VALVE ENGINES MAY EXHIBIT A CRANK - NO START, ROUGH IDLE, MALFUNCTION INDICATOR LAMP AND / OR ANY DRIVEABILITY SYMPTON ASSOCIATED WITH A RICH OR LEAN FUEL MIXTURE. Read More »

    EQUIPMENT

    EQUIPMENT:ELECTRICAL

    • TSB #8431

      Date Announced:
      MAR 01, 2000
      NHTSA ID:
      #612855

      SUBJECT REGARDING CELLULAR PHONE OPTIONS. *TT Read More »

    • TSB #14025

      Date Announced:
      MAR 01, 2000
      NHTSA ID:
      #612905

      SUBJECT REGARDING CELLULAR PHONE OPTIONS. *TT Read More »

    EQUIPMENT:OTHER:LABELS

    • TSB #0052

      Date Announced:
      MAR 06, 2000
      NHTSA ID:
      #612945

      SUBJECT ON A LABEL WITH THE INCORRECT R-134A REFRIGERANT CHARGE LEVEL AS INSTALLED ON SOME VEHICLES. *MJS Read More »

    • TSB #7538

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610864

      SOME VEHICLES BUILT BETWEEN OCTOBER 4, 1999 AND NOVEMBER 30, 1999 MAY HAVE AN INCORRECT R134A REFRIGERANT CHARGE CAPACITY LABEL. THE CHARGE CAPACITY SHOULD BE .96 KG (34 OZ.), NOT .79 KG AS THE LABEL MIGHT READ. Read More »

    • TSB #13514

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #614638

      SOME VEHICLES BUILT BETWEEN OCTOBER 4, 1999 AND NOVEMBER 30, 1999 MAY HAVE AN INCORRECT R134A REFRIGERANT CHARGE CAPACITY LABEL. *TT Read More »

    EQUIPMENT:APPLIANCE:AIR CONDITIONER

    • TSB #02208

      Date Announced:
      OCT 14, 2002
      NHTSA ID:
      #10013060

      CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH Read More »

    • TSB #16190

      Date Announced:
      SEP 01, 2002
      NHTSA ID:
      #10008596

      LACK OF A/C COOLING. *MJ Read More »

    • TSB #15889

      Date Announced:
      MAY 01, 2002
      NHTSA ID:
      #637765

      SOME VEHICLES EQUIPPED WITH THE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) WILL NOT CYCLE THE AI CONDITIONER COMPRESSOR WHEN THE FLOOR MODE IS SELECTED. *TT Read More »

    • TSB #7249

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6090834

      INFORMATION ON USING PEANUT STYLE A/C FITTINGS. *TT Read More »

    • TSB #13355

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6092160

      INFORMATION REGARDING A/C PEANUT O-RING COLOR. *TT Read More »

    • TSB #99196

      Date Announced:
      SEP 20, 1999
      NHTSA ID:
      #6090087

      INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »

    UNKNOWN OR OTHER

    • TSB #01157

      Date Announced:
      AUG 06, 2001
      NHTSA ID:
      #623988

      INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »

    • TSB #8018

      Date Announced:
      APR 01, 2000
      NHTSA ID:
      #613613

      SOME VEHICLES EQUIPPED WITH A KEYLESS ENTRY KEYPAD MAY REQUIRE THE NEED TO ACCESS THE KEYPAD CODE FOR THE VEHICLE. **MR Read More »

    • TSB #7820

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #612211

      SERVICE TIP, HOW TO REMOVE ICP RETAINING SPRING CLIP. Read More »

    • TSB #14427

      Date Announced:
      JAN 01, 2000
      NHTSA ID:
      #620445

      VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LAMP ILLUMINATION AND MULTIPLE DIAGNOSTIC TROUBLE CODES, MOSTLY TRANSMISSION RELATED, STORED IN MEMORY. THE TCIL LAMP WILL ALSO FLASH. *TT Read More »

    • TSB #99234

      Date Announced:
      NOV 15, 1999
      NHTSA ID:
      #6090131

      INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »

    • TSB #7161

      Date Announced:
      NOV 01, 1999
      NHTSA ID:
      #610775

      INFORMATION REGARDING DOUBLE EDSR AWARD POINTS. *TT Read More »

    • TSB #7314

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6092095

      SUBJECT REGARDING PHONE CONTACTS. *TT Read More »

    • TSB #13297

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6092119

      SUBJECT REGARDING DOUBLE EDSR AWARD POINTS FOR EDSR'S. *TT Read More »

    • TSB #13402

      Date Announced:
      OCT 01, 1999
      NHTSA ID:
      #6092195

      SUBJECT REGARDING PHONE CONTACTS. *TT Read More »

    Browse Other Sable Years