2005 Mercury Mountaineer
71 Technical Service Bulletins (TSBs)
TSB List for the 2005 Mercury Mountaineer
Technical Service Bulletins (TSBs) for the 2005 Mountaineer are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #0538
INCREASED TURNING EFFORT DURING LOW SPEED SHARP TURNS FALSE 4X4 ENGAGEMENT. *EH Read More »
SUSPENSION:FRONT:WHEEL BEARING
-
TSB #051710
NOISE FROM REAR WHEEL HUB BEARINGS. *TT Read More »
SUSPENSION:REAR
-
TSB #050618
REAR AXLE NOISE REPAIR. *SC Read More »
ENGINE (PWS)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #TSB-12-7-4
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. Read More »
ENGINE AND ENGINE COOLING
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT Read More »
-
TSB #051016
NO START/HARD START ON COLD SOAK - 4.0L ENGINE. *TT Read More »
-
TSB #18573
NO START/HARD START ON COLD SOAK. *TT Read More »
-
TSB #0539
MIL ON AND/ OR RUNS ROUGH/MISFIRE DTCS P0300-P0308 P0316 AND OR P0171/P0174 4.6L ENGINE. *EH Read More »
-
TSB #04225
THROTTLE PEDAL RESPONSE ON TIP IN VEHICLES BUILT BEFORE 10/4/2004 EQUIPPED WITH A 4.0L ENGINE. *EH Read More »
-
TSB #042112
ROUGH IDLE IN DRIVE. *EH Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
-
TSB #0531
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM). *TT Read More »
-
TSB #031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
-
TSB #042115
FUEL GAUGE SLOW TO UPDATE AFTER REFUELING. *EH Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #05213
MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL GAUGE DROPS TO EMPTY OR SLOW TO UPDATE AFTER REFUELING. *TT Read More »
-
TSB #06167
MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB Read More »
POWER TRAIN
-
TSB #05612
DELAYED OR HARSH REVERSE ENGAGEMENTS - 5R55S TRANSMISSION - VEHICLES BUILT PRIOR TO 09/23/2004. *TT Read More »
-
TSB #04268
INCREASED EFFORT DURING LOW SPEED SHARP TURNS ON 4X4 VEHICLES. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #04B22
IMPROPERLY FORMULATED TRANSMISSION FLUID THAT, OVER TIME, MAY CAUSE DELAYED/HARSH REVERSE ENGAGEMENTS. CUSTOMER SATISFACTION PROGRAM 04B22. 5R55S/E & 5R44E TRANSMISSION FLUID ADDITIVE. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
-
TSB #042212
GEAR SELECTOR LEVER - INCREASED EFFORT TO SHIFT FROM DRIVE TO PARK. *TT Read More »
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
-
TSB #18815
A TINY CRACK, OR CRACKS, AROUND THE TRANSFER CASE DRAIN PLUG HOLE. *TT Read More »
POWER TRAIN:DRIVELINE
-
TSB #0537
DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY
-
TSB #06216
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT Read More »
-
TSB #05618
REAR AXLE NOISE REPAIR. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
-
TSB #04105
AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL. SERVICE TIPS. *TT Read More »
ELECTRICAL SYSTEM
-
TSB #051017
SERVICE ENGINE SOON LAMP ON WITH PCM DTC P0463, INSTRUMENT CLUSTER DTC B1201 AND OR FUEL GAUGE DROPS TO EMPTY-VEHICLES BUILT 8/2/2004 THROUGH 4/7/2005. *SC Read More »
-
TSB #04219
MALFUNCTION INDICATOR LAMP (MIL) AND ELECTRONIC THROTTLE CONTROL (ETC) LAMPS ON WITH BOTH DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P2135. *TT Read More »
-
TSB #0561
WRENCH LAMP ON AND NO DIAGNOSTIC TROUBLE CODE (DTC) STORED. *TT Read More »
-
TSB #18381
OPEN FUSE F2.20 (5 AMP) AND/OR F2.1 (30 AMP) WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT Read More »
-
TSB #05262
MIL ON WITH DTC P0191 WITH OR WITHOUT VARIOUS DRIVABILITY SYMPTOMS AND/OR ADDITIONAL DTCS. *TT Read More »
-
TSB #04197
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTC'S) P0172 AND/OR P0175. *TT Read More »
ELECTRICAL SYSTEM:STARTER ASSEMBLY
-
TSB #18171
NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C). *TT Read More »
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
-
TSB #061710
MIL ON WITH P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB Read More »
VISIBILITY:GLASS, SIDE/REAR
-
TSB #05136
BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW
-
TSB #04189
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT Read More »
SEAT BELTS:FRONT:RETRACTOR
-
TSB #042421
SAFETY BELT RETRACTION SPEED. *TT Read More »
STRUCTURE
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #042616
WELD BONDING PROCEDURE. *TT Read More »
STRUCTURE:BODY
-
TSB #0485
LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED. SERVICE PROCEDURE. *TT Read More »
-
TSB #04251
ALUMINUM CORROSION - SERVICE TIP. *TT Read More »
-
TSB #04255
RATTLING NOISE - RIGHT FRONT FENDER WHILE DRIVING. *TT Read More »
TIRES
-
TSB #0637
LOW TIRE INDICATOR ON - TPMS SYSTEM SENSOR WAKE UP. *TT Read More »
-
TSB #052624
VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT Read More »
WHEELS
-
TSB #052624
VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT Read More »
SEATS
-
TSB #05416
FRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING. *TT Read More »
BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT
-
TSB #05419
FALSE PARKING AID WARNINGS. *TT Read More »
-
TSB #04262
FALSE PARKING AID WARNINGS. *TT UPDATE. *TT Read More »
EQUIPMENT
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »