2002 Mercury Mountaineer
251 Technical Service Bulletins (TSBs)
TSB List for the 2002 Mercury Mountaineer
Technical Service Bulletins (TSBs) for the 2002 Mountaineer are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
STEERING
-
TSB #16427
LOW SPEED OR STATIONARY NOISE/VIBRATION AT LOWER STEERING SHAFT AREA WHEN TURNING. *MJ Read More »
-
TSB #15580
SOME 4 DOOR VEHICLES MAY EXHIBIT A STEERING COLUMN RATTLE AT SPEEDS OF 10-20 MPH ON UNEVEN SURFACES. *TT Read More »
-
TSB #15408
SOME VEHICLES EQUIPPED WITH DUAL AUTOMATIC TEMPERATURE CONTROL (DATC) MAY EXHIBIT INOPERATIVE REDUNDANT STEERING WHEEL CONTROLS (RSWC). *TT Read More »
-
TSB #15017
STIFF STEERING OR POOR STEERING WHEEL RETURNABILITY. *TT Read More »
STEERING: STEERING WHEEL/HANDLE BAR
-
TSB #15647
SOME VEHICLES EQUIPPED WITH A V6 ENGINE MAY EXHIBIT A STEERING RATTLE NOISE WHICH MAY BE HEARD AND FELT IN THE STEERING WHEEL AND COLUMN. *TT Read More »
-
TSB #15091
SOME VEHICLES MAY EXHIBIT A SCRUNCH NOISE FROM THE UPPER STEERING COLUMN WHEN MAKING NEAR FULL LOCK TURNS. *TT Read More »
-
TSB #14947
SOME VEHICLES MAY EXHIBIT A STEERING WHEEL SHUDDER DURING LOW SPEED TURNING MANEUVERS. *TT Read More »
STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-
TSB #15899
SUBJECT REGARDING THEFT LIGHT RELOCATION. *TT Read More »
STEERING:HYDRAULIC POWER ASSIST SYSTEM
-
TSB #15906
INFORMATION ON POWER STEERING LEAK CONDITION. *TT Read More »
SUSPENSION
-
TSB #15984
EXHIBITING SQUEAK / CREAK NOISES DURING FRONT SUSPENSION MOVEMENT. *TT Read More »
-
TSB #15084
STEERING WHEEL SHUDDER DURING LOW-SPEED TURNING MANEUVERS. *TT Read More »
SUSPENSION:FRONT:WHEEL BEARING
-
TSB #051710
NOISE FROM REAR WHEEL HUB BEARINGS. *TT Read More »
SUSPENSION:REAR
-
TSB #050618
REAR AXLE NOISE REPAIR. *SC Read More »
SUSPENSION:MULTIPLE AXLE
-
TSB #14795
SOME VEHICLES MAY EXHIBIT A NOISY AND / OR LOOSE FRONT WHEEL BEARING. *TT Read More »
SERVICE BRAKES, HYDRAULIC
-
TSB #16926
STABILITY ASSIST (ADVANCETRAC/IVD) SYSTEMS MAY NOT BE RECALIBRATED PROPERLY USING WDS. *TT Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-
TSB #15910
CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT Read More »
-
TSB #14894
SOME VEHICLES MAY EXHIBIT A REPETITIVE THUMP / KNOCK NOISE FROM THE REAR WHICH IS PROPORTIONAL TO WHEEL SPEED WHEN BRAKE. THIS MAY BE CAUSED BY THE INITIAL FINISH / SPIRAL CUT OF THE REAR BREAK ROTOR(S). Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
-
TSB #14896
SOME VEHICLES MAY EXHIBIT AN ERROR INDICATING THAT THERE IS NO COMMUNICATION OR RETURN DIAGNOSTIC TROUBLE CODES (DTC) THAT ARE NOT RELATED TO THE ANTI-LOCK BRAKE (ABS) SYSTEM WHEN RETRIEVING DTCS FROM OR ATTEMPTING TO VIEW PIDS IN THE ABS ... Read More »
-
TSB #14723
SOME VEHICLES MAY EXHIBIT A TINNY RATTLE NOISE COMING FROM THE CENTER STEERING COLUMN AREA WHILE DRIVING OVER BUMPY ROADS. Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
-
TSB #03263
ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODE (DTC) C1235, C1236, C1237 ON VEHICLES WITH DIFFERENTIAL-MOUNTED RAR WHEEL SPEED SENSOR. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT
-
TSB #14900
SOME VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM LIGHT ON WITH DIAGNOSTIC TROUBLE CODE C1230 AND / OR C1237 FROM THE ANTI-LOCK BRAKE SYSTEM. *TT Read More »
-
TSB #14933
SOME VEHICLES MAY EXHIBIT A YELLOW FOUR WHEEL ANTI-LOCK BRAKE (4WABS) LAMP ILLUMINATED AND A DIAGNOSTIC TROUBLE CODE (DTC) B1342 (ANTI-LOCK BRAKE CONTROL MODULE FAILURE) IN SELF TEST. *TT Read More »
SERVICE BRAKES, AIR:DISC:ROTOR
-
TSB #15248
SOME OWNERS MAY NOTICE A KNOCKING NOISE FROM THE REAR OF THE VEHICLE WHEN THE BRAKES ARE APPLIED. *TT Read More »
SERVICE BRAKES, AIR:ANTILOCK:INTERCONNECTING ASSEMBLY(WIRING)
-
TSB #14903
INFORMATION REGARDING TRAILER WIRING - BRAKE CONTROLLER CONNECTOR LOCATION. *TT Read More »
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
-
TSB #17215
THE AMBER ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON WITH DIAGNOSTIC TROUBLE CODES C1235, C1236/C1237 STORED IN MEMORY. *TT Read More »
-
TSB #16918
ANTI-LOCK BRAKE SYSTEM (ABS) INDICATOR LAMP ON WITH CODES C1235 AND C1236 OR C1237. *TT Read More »
ENGINE AND ENGINE COOLING
-
TSB #041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT Read More »
-
TSB #18572
NO START/HARD START N HOT SOAK RESTART. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE
-
TSB #07212
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
-
TSB #051313
HARD START/NO START CONDITION DURING COLD AMBEINT TEMPERATURES AFTER SHORT HOT SOAK PERIOD-4.0L ENGINE. *SC Read More »
-
TSB #031404
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
-
TSB #17544
GENERATOR NOISE IN COLD AMBIENT TEMPERATURES. *MJ Read More »
-
TSB #03256
ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ Read More »
-
TSB #17167
MULTIPLE VEHICLES WITH 3.0L OR 4.0L ENGINES LACKS POWER/RUNS ROUGH/BLACK SMOKE. 2004 SPORT TRAC INCLUDED. *TT Read More »
-
TSB #03164
SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. Read More »
-
TSB #17049
ROUGH IDLE / ENGINE SHAKE. *TT Read More »
-
TSB #17069
ROUGH/ROLLING IDLE OR HESITATION AFTER FIRST STARTUP OR A ROUGH/ROLLING ENGINE SPEED WHEN RETURNING TO IDLE AFTER A SHORT TRIP. *TT Read More »
-
TSB #03144
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
-
TSB #16968
DRIVEABILITY CONDITIONS DUE TO CALIBRATION VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE. IDLE AIR CONTROL (IAC) VALVE REPLACEMENT FOR THESE SYMPTOMS IS TYPICALLY NOT EFFECTIVE. *TT Read More »
-
TSB #03106
THROTTLE CABLE ROUTING AND SPLASH SHIELD MODIFICATION WHEN REPLACING THROTTLE CABLE DURING NORMAL SERVICE. *TT Read More »
-
TSB #16771
ROUGH / ROLLING IDLE AND HESITATION ON ACCELERATION AFTER A FIRST COLD STARTUP. *TT Read More »
-
TSB #0335
IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT Read More »
-
TSB #16508
VIBRATION CONDITION. CONTACT REQUEST ST. LOUIS REGION. OASIS. *TT Read More »
-
TSB #870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »
-
TSB #02177
COOLING SYSTEM-MOTORCRAFT PREMIUM GOLD ENGINE COOLANT-SERIVCE TIPS. *MJ Read More »
-
TSB #15290
SOME 4.0L SOHC MAY EXHIBIT AN ENGINE OIL LEAK CONDITION, COMING FROM THE OIL PAN OR LADDER FRAME AREA. *TT Read More »
-
TSB #14726
INFORMATION ON THE INTAKE MANIFOLD VALLEY STUFFER BAG. *TT Read More »
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
-
TSB #15853
SUBJECT REGARDING INTERMITTENT ENGINE QUIT DURING TRANSMISSION ENGAGEMENTS OR PARKING MANEUVERS. *TT Read More »
-
TSB #0281
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT Read More »
-
TSB #0276
INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT Read More »
-
TSB #15804
SOME VEHICLES BUILT SINCE OCTOBER 1, 2001 MAY EXHIBIT A NO START CONDITION OR AN INTERMITTENT NO START CONDITION, AND / OR POSSIBLY NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. Read More »
-
TSB #0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
-
TSB #15540
INFORMATION REGARDING ENGINE WIND NOISE.*YH Read More »
-
TSB #01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT Read More »
-
TSB #15470
CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY. *TT Read More »
-
TSB #15489
SOME VEHICLES EQUIPPED WITH 4.6L ENGINES MAY EXHIBIT A HIGH FREQUENCY WHINE NOISE (HAIR DRYER TYPE NOISE), THAT LASTS FOR 30-60 SECONDS AFTER COLD START. *TT Read More »
-
TSB #15383
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER WITH THE WDS/NGS DIAGNOSTIC EQUIPMENT. *TT Read More »
-
TSB #01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
-
TSB #15286
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER (PTEC) WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. *TT Read More »
-
TSB #15058
SOME VEHICLES EQUIPPED WITH A 5R55W AUTOMATIC TRANSMISSION MAY EXHIBIT A TICK NOISE WHILE AT IDLE IN PARK AND NEUTRAL. *TT Read More »
-
TSB #14868
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-
TSB #17163
EXCESSIVE ENGINE COOLING FAN NOISE. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
-
TSB #02216
EXCESSIVE SULFUR SMELL FROM EXHAUST. *EH Read More »
-
TSB #15783
SOME VEHICLES MAY EXHIBIT EXCESSIVE SULPHUR SMEEL FROM THE EXHAUST UNDER CERTAIN DRIVE MODES. *TT Read More »
-
TSB #15210
SOME VEHICLES EQUPPED WITH 4.0L ENGINE MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROMTHE EXHAUST SYSTEM WHILE OPERATING UNDER CERTAIN DRIVE MODES RELATED TO CALIBRATION. *TT Read More »
-
TSB #14983
SOME VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT EXCESSIVE SULPHUR SMELL FROM THE EXHAUST SYSTEM WHILE OEPRATING UNDER DRIVE MODES. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
-
TSB #16094
SOME VEHICLES MAY EXHIBIT FUEL DIAGNOSTIC TROUBLE CODES P0171, P0172, P0174, P0175 OR MASS AIR FLOW DIAGNOSTIC TROUBLE CODES P0102, P0103, P0112, P0113. *TT Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
-
TSB #02M01
CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
-
TSB #15519
SOME VEHICLES MAY EXPERIENCED A STRONG SULPHUR ODOR DURING CERTAIN DRIVE MODES.*YD Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-
TSB #05N04
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. Read More »
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-
TSB #15532
INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT Read More »
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
-
TSB #042115
FUEL GAUGE SLOW TO UPDATE AFTER REFUELING. *EH Read More »
FUEL SYSTEM, OTHER
-
TSB #18719
MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT Read More »
-
TSB #18217
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
-
TSB #18224
RUNS ROUGH OR MISFIRE - DIAGNOSTIC TROUBLE CODES P0300-P0308 OR P0316. *TT Read More »
-
TSB #17494
DISTANCE TO EMPTY NOT DISPLAYED. *TT Read More »
-
TSB #17316
FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP. *TT Read More »
-
TSB #0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT Read More »
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
-
TSB #05213
MALFUNCTION INDICATOR LAMP ON WITH PCM DIAGNOSTIC TROUBLE CODE P0463 AND/OR IC DIAGNOSTIC TROUBLE CODE B1201 - FUEL GAUGE DROPS TO EMPTY OR SLOW TO UPDATE AFTER REFUELING. *TT Read More »
-
TSB #18121
FUEL GAUGE SLOW TO UPDATE. *TT Read More »
POWER TRAIN
-
TSB #18123
UPDATED REAR HALFSHAFT REMOVAL PROCEDURE. *TT Read More »
-
TSB #17555
CERTIFIED REAR AXLE AVAILABLE. *MJ Read More »
-
TSB #17560
REAR AXLE NOISE. ALSO INCLUDES LINCOLN AVIATOR 2002. *MJ Read More »
-
TSB #16898
A WHINE NOISE ON TIP-IN AT SPEEDS OF 45 TO 65 MPH. THIS MAY BE DUE TO DRIVELINE STACK-UP TOLERANCE WITH THE DRIVESHAFT AND REAR AXLE. *TT Read More »
-
TSB #16806
FLUID LEAKS FROM THE REAR HALFSHAFT SEAL. 2002-2003 EXPLORER/MOUNTAINEER/AVIATOR ADDED. *TT Read More »
-
TSB #0258
INOPERATIVE OR INACURRATE SPEEDOMETER, 4X4 LAMP ILLUMINATD, AND / OR DIAGNOSTIC TROUBLE CODE P1635 OR P1639. *TT Read More »
-
TSB #02101
SOME ALL-WHEEL DRIVE VEHICLES MAY EXHIBIT A GROWL NOISE AT SPEEDS OF 65-112 KM/H (40-70 MPH). *TT Read More »
-
TSB #15840
SOME VEHICLES WITH THE 4.6L ENGINE AND ALL WHEEL DRIVE BUILT BETWEEN 02/25 AND 04/24, 2002 MAY EXHIBIT A SHUDDER ON THE 4-5 UPSHIFT AND / OR THE 5-4 DOWNSHIFT. *TT Read More »
-
TSB #15495
SOME ALL WHEEL DRIVE VEHICLES MAY EXHIBIT A GROWL NOISE AT SPEEDS OF APPROXIMATELY 45 MPH AND ABOVE. *TT Read More »
-
TSB #15250
INFORMATION REGARDING MISDIAGNOSIS OF MAIN CONTROLS - INCORRECT PRESSURES. *TT Read More »
-
TSB #15209
SOME ALL-WHEEL DRIVE VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT A WHINE NOISE FROM THE FRONT DRIVELINE AT SPEEDS BETWEEN 40 - 80 MPH. *TT Read More »
-
TSB #15267
SOME VEHICLES WITH 5R5W MAY EXHIBIT A NO ENGAGEMENT CONDITION. ENGINEERING IS INVESTIGATING. *TT Read More »
-
TSB #14872
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NO CRANK CONDITION AND NO COMMUNICATION FROM THE POWERTRAIN ELECTRONIC CONTROLLER (PTEC) WITH THE WDS / NGS DIAGNOSTIC EQUIPMENT. *TT Read More »
-
TSB #14866
SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT Read More »
POWER TRAIN:MANUAL TRANSMISSION
-
TSB #15019
SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT A WHINE NOISE THAT OCCURS IN 3RD GEAR ONLY. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION
-
TSB #03254
5R55W TRANSMISSION - NO 3RD GEAR OR SLIPPING 2-3 SHIFT - DIAGNOSTIC TROUBLE CODE P0733 AND P0745 - VEHICLES BUILT PRIOR TO 3/4/2002. *TT Read More »
-
TSB #03147
SHUDDER DURING 4/5 UPSHIFT AND/OR 5/4 DOWNSHIFT ON VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5R55W AUTOMATIC TRANSMISSION. *TT Read More »
-
TSB #0357
FLUID LEAK FROM THE CONVERTER HOUSING AREA. *TT *JB Read More »
-
TSB #0262
SUBJECT REGARDING 5R55W AUTOMATIC TRANSMISSION HARSH UPSHIFTS DURING LIGHT TO MEDIUM THROTTLE CONCERNS. *TT Read More »
-
TSB #01203
EXHIBIT HARSH 1-2, 3-4 UPSHIFTS AT LIGHT TO MEDIUM THROTTLE ON SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5R55W AUTOMATIC TRANSMISSION BUILT THROUGH 9/21/2001. *TT Read More »
-
TSB #01207
SOME VEHICLES PRODUCED BEFORE 9/6/2001 EQUIPPED WITH THE 5R55W TRANSMISSION MAY EXHIBIT A TICK NOISE EMANATING FROM THE FRONT OR INTERMEDIATE SERVO COVER. *TT Read More »
-
TSB #01142
SOME VEHICLES, BUILT PRIOR TO 8/01/2001, MAY EXHIBIT A WHINE OR HOWL NOISE DURING COLD STARTS AT TEMPERATURES BELOW 4 DEGREES C (40 DEGREES F). *TT Read More »
-
TSB #15069
VEHICLES EQUIPPED WITH THE 5R55W AUTOMATIC TRANSMISSION BUILT PRIOR TO 08/01/2001 MAY EXHIBIT A NEUTRAL OUT CONDITION WHEN COMING TO A STOP. *TT Read More »
-
TSB #15088
SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT NO TRANSMISSION ENGAGEMENT INTO FORWARD AND / OR REVERSE GEAR. *TT Read More »
-
TSB #01111
SOME VEHICLES EQUIPPED WITH A 4.0L ENGINE AND 5R55W AUTOMATIC TRANSMISSION BUILT 11/13/2000 THROUGH 5/21/2001 MAY EXHIBIT LIGHT THROTTLE SOFT OR LONG 2-3 UPSHIFTS BETWEEN 16-40 KM/H (10-25 MPH) OR HARSH 3-4 UPSHIFTS BETWEEN 32-56 KM/H ... Read More »
-
TSB #14759
INFORMATION REGARDING TRANSMISSION OIL LEVEL CHECKING GUIDELINES. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
-
TSB #042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #14923
SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT Read More »
-
TSB #14934
SOME VEHICLES EQUIPPED WITH 5R55W TRANSMISSION MAY EXHIBIT VARIOUS FIRM AND / OR SOFT SHIFTS. *TT Read More »
-
TSB #14827
INFORMATION ON VEHICLES EQUIPPED WITH WITH 5R55W TRANSMISSION HAVING A (POWERTRAIN CONTROL MODULE) PCM ADAPTIVE LEARNING STRATEGY FEATURE THAT CONTROLS SHIFT FEEL AND TIMING. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
-
TSB #042212
GEAR SELECTOR LEVER - INCREASED EFFORT TO SHIFT FROM DRIVE TO PARK. *TT Read More »
-
TSB #14874
SOME VEHICLES MAY EXHIBIT A TRANSMISSION SHIFTER STUCK IN THE PARK GEAR POSITION. THIS MAY BE DUE TO THE BRAKE SHIFT INTERLOCK SWITCH. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-
TSB #0213
SOME ALL WHEEL DRIVE EQUIPPED VEHICLES MAY EXHIBIT A GROWL NOISE AT SPEEDS OF 65-112 KM/H (40-70 MPH). *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
-
TSB #15030
SOME VEHICLES MAY EXHIBIT A TRANSMISSION SHIFTER STUCK IN THE PARK GEAR POSITION. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
-
TSB #03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »
-
TSB #01102
A FLUID LEAK AT THE TRANSMISSION COOLER LINE-TO-TRANSMISSION CASE CONNECTION. THIS MAY BE CAUSED BY CONTAMINATION ON THE COOLER TUBE BETWEEN THE TUBE NUT AND FLARE, CONTAMINATION ON THE TUBE NUT THREADS OR IMPROPER INSTALLATION TORQUE. Read More »
-
TSB #011002
SOME 4-DOOR VEHICLES BUILT 11/13/2000 THROUGH 4/2/2001 EQUIPPED WITH THE 5R55W TRANSMISSION MAY EXHIBIT A FLUID LEAK AT THE TRANSMISSION COOLER LINE-TO-TRANSMISSION CASE CONNECTION. Read More »
-
TSB #002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
-
TSB #01223
SOME VEHICLES BUILT PRIOR TO 11/11/2001 EQUIPPED WITH 5R55W TRANSMISSION AND 4.6L ENGINE, MAY EXHIBIT A BUZZING NOISE WHEN THE TORQUE CONVERTER IS ENGAGED. *TT Read More »
-
TSB #01115
FLUID LEAK IN THE CONVERTER HOUSING AREA ON VEHICLES BUILT 11/13/2000 THROUGH 4/27/2001. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
-
TSB #01181
BRAKE SHIFT INTERLOCK.*JB Read More »
POWER TRAIN:DRIVELINE
-
TSB #0537
DRIVELINE 1ST ORDER VIBRATION/BOOM/DRONE. *TT Read More »
-
TSB #17107
DRIVELINE VIBRATION ON DRONE/BOOM AT HIGHWAY SPEEDS. *TT Read More »
POWER TRAIN:DRIVELINE:DRIVESHAFT
-
TSB #15251
SOME 4X4 VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT. *TT Read More »
-
TSB #15080
SOME VEHICLES WITH FEWER THAN 10,000 MILES MAY EXHIBIT GREASE OOZING FROM THE FRONT DRIVESHAFT CV JOINT. *TT Read More »
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
-
TSB #14966
SOME ALL-WHEEL DRIVE VEHICLES MAY EXHIBIT A WHINE NOISE FROM THE FRONT DRIVELINE AT SPEEDS BETWEEN 40 AND 80 MILES PER HOUR. *TT Read More »
-
TSB #14950
SOME ALL-WHEEL DRIVE VEHICLES MAY EXHIBIT A WHINE NOISE FROM THE FRONT DRIVELINE AT SPEEDS BETWEEN 40 AND 80 MILES PER HOUR. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY
-
TSB #06216
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT Read More »
-
TSB #05618
REAR AXLE NOISE REPAIR. *TT Read More »
-
TSB #18221
REAR AXLE NOISE. OASIS. VARIOUS MODELS INCLUDING 2005 EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
-
TSB #03198
CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT Read More »
-
TSB #17905
MULTIPLE VEHICLES USING FEHP REAR AXLE FLUID. FLUID USAGE CHANGE. *TT Read More »
-
TSB #04B15
REAR AXLE DATE CODE INSPECTION AND SERVICE. VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER MIX OF REAR AXLE LUBRICANT AND FRICTION MODIFIER ADDITIVE. IF SO, THE CUSTOMER MAY EXPERIENCE NOISE AND VIBRATION WHILE DRIVING. Read More »
-
TSB #17717
REAR AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS. *TT Read More »
-
TSB #17736
REAR AXLE NOISE. *TT Read More »
-
TSB #17641
REAR 3.55 AXLE NOISE. CERTIFIED REAR AXLE OR IMPROVED GEAR SET AVAILABLE. *TT Read More »
-
TSB #17054
AXLE WHINE AT CRUISE OR DURING ACCELERATION/ DECELERATION. *TT Read More »
-
TSB #16949
REAR AXLE VIBRATION/DRONE ABOVE 60 MPH. *TT Read More »
-
TSB #15646
CONCERNS WITH CLUNK NOISE FROM FRONT AXLE AREA. *TT Read More »
-
TSB #0186
ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
-
TSB #04105
AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL. SERVICE TIPS. *TT Read More »
ELECTRICAL SYSTEM
-
TSB #18381
OPEN FUSE F2.20 (5 AMP) AND/OR F2.1 (30 AMP) WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT Read More »
-
TSB #0471
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
-
TSB #04174
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
-
TSB #04111
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
-
TSB #03223
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
-
TSB #17375
MALFUNCTION INDICATOR LAMP (MIL) ON AND HARD START/LONG CRANK. *TT Read More »
-
TSB #03203
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
-
TSB #17246
INSTRUMENT CLUSTER LOCKING UP AND ACCESSORIES SUCH AS THE RADIO, POWER WINDOWS, POWER LOCKS AND MOONROOF INOPERATIVE. *TT Read More »
-
TSB #03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »
-
TSB #17011
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC'S) P0171, P0172, P0174, OR P0175. *TT Read More »
-
TSB #03136
NO CRANK CONDITION. SERVICE TIPS. *TT Read More »
-
TSB #16967
CLUSTER LOCKING UP & VARIOUS ACCESSORIES SUCH AS THE RADIO, POWER WINDOWS, POWER LOCKS AND MOONROOF BEING INOPERATIVE. *TT Read More »
-
TSB #17002
AN INTERMITTENT OR CONTINUOUS OPEN OF FUSE 1.15. *TT Read More »
-
TSB #0365
INTERMITTENT FUEL GAUGE LEVEL DROPPING TO EMPTY WHEN FUEL LEVEL IS NOT ACTUALLY EMPTY. DIAGNOSTIC TROUBLE CODES B1201, B1202, B1204 MAY OR MAY NOT BE PRESENT. *TT *JB Read More »
-
TSB #16703
BATTERY LIGHT ON OR AN ALTERNATOR THAT IS NOT CHARGING. *TT *JB Read More »
-
TSB #16665
BLINKING/HALF ILLUMINATED SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AND/OR ANTI-LOCK BRAKE (ABS) WARNING INDICATORS AFTER COLD SOAK DURING AMBIENT TEMPERATURES COLDER THAN 30 DEGREES FAHRENHEIT. Read More »
-
TSB #021710
ELECTRICAL-CENTRAL SECURITY MODULE (CSM) SERVICE TIPS. *MJ Read More »
-
TSB #16029
SOME VEHICLES MAY EXHIBIT UNINTENDED SMART UNLOCK ACTIVATION WITHOUT KEY IN IGNITION. *TT Read More »
-
TSB #19091
LOW OIL PRESSURE INDICATION/WARNING, A/C COMPRESSOR INOPERATIVE AND/OR NO CRANK CONDITION ON 4.6L EQUIPPED VEHICLES. *TT Read More »
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
-
TSB #0245
INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT Read More »
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
-
TSB #17280
GENERATOR WHISTLE/HOOT NOISE IN COLD AMBIENT TEMPERATURES. *TT Read More »
ELECTRICAL SYSTEM:STARTER ASSEMBLY
-
TSB #18171
NO CRANK/NO START CONDITION WHEN VEHICLE TEMPERATURE IS BELOW FREEZING (32F/0C). *TT Read More »
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
-
TSB #16617
OPEN F2.20 5 AMP FUSE WHICH MAY RESULT IN LOSS OF FUNCTION OF SEVERAL SYSTEMS INCLUDING POWER SEATS, ADJUSTABLE PEDALS AND POWER DOOR LOCKS. *TT Read More »
ELECTRICAL SYSTEM:IGNITION
-
TSB #15107
SOME VEHICLES MAY REQUIRE EXCESSIVE EFFORT WHEN TRYING TO INSERT THE KEY INTO THE IGNITION LOCK CYLINDER. *TT Read More »
-
TSB #14890
SOME VEHICLES MAY EXHIBIT EXCESSIVE EFFORTS WHEN TRYING TO INSERT OR REMOVE THE KEY FROM THE IGNITION LOCK. *TT Read More »
ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
-
TSB #16159
SOME VEHICLES BUILT AFTER MARCH 2002 MAY NOT ALLOW PASSIVE ANTI-THEFT SYSTEM (PATS) SECURITY ACCESS WHEN PROGRAMMING SPARE KEYS OR REPLACING DEFECTIVE KEYS. *TT Read More »
-
TSB #01245
SOME VEHICLES EQUIPPED WITH THE 4.0L ENGINE MAY EXHIBIT A CONDITION OF UNABLE TO ACCESS WITH THE SECURILOCK PASSIVE ANTI-THEFT SYSTEM (PATS). *TT Read More »
-
TSB #14906
INFORMATION ON PERFORMING ANY PASSTIVE ANTI-THEFT (PATS) SYSTEM FUNCTIONS INCLUDING KEY REPLACEMENTS WITH WDS OR NGS. *TT Read More »
-
TSB #0162
VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT Read More »
EXTERIOR LIGHTING:HEADLIGHTS
-
TSB #15683
SOME VEHICLES MAY EXHIBIT A NEED FOR HEADLAMP AIM ADJUST AFTER DRIVING ON ROUGH ROADS. *TT Read More »
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-
TSB #02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »
VISIBILITY:GLASS, SIDE/REAR
-
TSB #05136
BACKGLASS DIFFICULT TO CLOSE AND AN INTERMITTENT DOOR AJAR LAMP. *TT Read More »
-
TSB #16688
BACK GLASS HINGE RATTLING/LOOSENESS, GLASS MISALIGNMENT AND/OR GLASS HARD-TO-CLOSE. *TT *JB Read More »
-
TSB #01T02
SPECIAL SERVICE INSTRUCTIONS FOR THE LIFTGATE GLASS BRACKET INSPECTION AND TORQUE PROCEDURE. *TT Read More »
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
-
TSB #04259
REAR POWER WINDOW(S) INOPERATIVE. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT
-
TSB #041514
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT Read More »
-
TSB #031501
INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT Read More »
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW
-
TSB #04189
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT Read More »
AIR BAGS
-
TSB #16618
ILLUMINATED AIR BAG WARNING LAMP WITH DIAGNOSTIC TROUBLE CODE (DTC) B2292. *TT Read More »
AIR BAGS:FRONTAL
-
TSB #17640
POOR FIT BETWEEN DRIVER AIR BAG AND STEERING WHEEL. *TT Read More »
SEAT BELTS:FRONT:RETRACTOR
-
TSB #042421
SAFETY BELT RETRACTION SPEED. *TT Read More »
STRUCTURE
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #16304
SUN VISOR RATTLE / DETROIT AREA DEALERS CONTACT REQUEST. *TT Read More »
STRUCTURE:FRAME AND MEMBERS
-
TSB #011110
SOME VEHICLES EQUIPPED WITH A CLASS II HITCH MAY EXHIBIT INSUFFICIENT CLEARANCE INT HE RECEIVER TO ATTACH TUBULAR HITCH ACESSORIES TO THE VEHICLE. *TT Read More »
STRUCTURE:BODY
-
TSB #0485
LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED. SERVICE PROCEDURE. *TT Read More »
-
TSB #04251
ALUMINUM CORROSION - SERVICE TIP. *TT Read More »
-
TSB #02171
PAINT-PREMATURE CLEARCOAT CRACKING-SERVICE TIPS. *MJ Read More »
-
TSB #15892
SUBJECT REGARDING REAR LIFTGATE APPLIQUE (TRIM PANEL) CRACKS. *TT Read More »
-
TSB #15445
SOME VEHICLES MAY EXHIBIT A RATTLE NOISE WHEN CLOSING EITHER THE MIDGATE OR THE REAR LIFTGATE. *TT Read More »
-
TSB #15287
SOME VEHICLES MAY EXHIBIT A FLUTTER/TURBULENCE NOISE CONDITION (I.E., HELICOPTER NOISE) AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOWS ARE IN THE DOWN POSITION. *TT Read More »
-
TSB #15335
CONCERNS WITH SQUEAK AND RATTLE NOISS COMING FROM THE INSTRUMENT PANEL AND FROM THE SIDE DOOR WINDOWS. *TT Read More »
-
TSB #15090
SOME VEHICLES MAY DEVELOP YELLOW STAINS ON THE REAR LIFTGATE PAINT, USUALLY NOTICED ON WHITE COLORED VEHICLES. *TT Read More »
STRUCTURE:BODY:DOOR
-
TSB #18215
BROKEN REAR CARGO STORAGE DOOR LIFT HANDLE. VARIOUS MODELS INCLUDING 2005 EXPLORER/MOUNTAINEER. *TT Read More »
-
TSB #16195
CONTACT ST LOUIS ASSEMBLY PLANT/ST LOUIS VICINITY ONLY. *MJ Read More »
-
TSB #15575
SOME VEHICLES MAY EXHIBIT THE DRIVERS DOOR UNLOCKING AFTER IT HAS BEEN LOCKED. *TT Read More »
-
TSB #14901
SOME VEHICLES MAY EXHIBIT A CONDITION IN WHICH THE REAR DOOR(S) WILL NOT UNLOCK VIA MANUAL OR POWER OPERATION. *TT Read More »
STRUCTURE:BODY:HATCHBACK/LIFTGATE
-
TSB #03126
LIFTGATE GLASS APPLIQUE DAMAGED/CRACKED - SERVICE PROCEDURE. *TT Read More »
STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
-
TSB #17216
BREAKAGE OF A LIFTGATE WINDOW HINGE. *TT Read More »
-
TSB #01T02
LIFTGATE GLASS BRACKET INSPECTION AND TORQUE PROCEDURE. *MR Read More »
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-
TSB #16608
UNINTENDED DOOR UNLOCKS WITHOUT KEY IN IGNITION (QSF). *TT Read More »
VEHICLE SPEED CONTROL
-
TSB #15054
VEHICLES WITH 4.0L ENGINE MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION. *TT Read More »
-
TSB #15105
SOME VEHICLES EQUIPPED WITH A 4.0L ENGINE MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION. *TT Read More »
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
-
TSB #16706
SQUEAKING ACCELERATOR PEDAL WHILE DRIVING DURING COLD, HOT, DUSTY, AND DRY CONDITIONS. *TT *JB Read More »
VEHICLE SPEED CONTROL:CRUISE CONTROL
-
TSB #15423
EXHIBITING ROUGH IDLE, OR ROUGH IDLE UPON INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT Read More »
-
TSB #15103
SOME VEHICLES MAY EXHIBIT A ROUGH IDLE OR ROUGHT IDLE AFTER INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT Read More »
-
TSB #15104
SOME VEHICLES MAY EXHIBIT A ROUGH IDLE OR ROUGH IDLE AFTER INITIAL START-UP THAT CLEARS UP AFTER A FEW MINUTES. *TT Read More »
-
TSB #15041
SOME VEHICLES EQUIPPED WITH 4.0L ENGINE MAY EXHIBIT A ROUGH IDLE CONDITION. *TT Read More »
TIRES
-
TSB #01B77
OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT Read More »
WHEELS
-
TSB #04181
CLEAR COAT PEEL OFF THE WHEEL OR CRACKS THAT LOOK LIKE SPIDER WEBS UNDER THE CLEAR COAT - 16 INCH WHEELS. *TT Read More »
WHEELS:HUBCAP/COVER
-
TSB #14804
INFORMATION ON FRONT WHEEL HUB ASSEMBLIES. *TT Read More »
SEATS
-
TSB #05416
FRONT SEAT(S) SLIGHT MOVEMENT WHEN ACCELERATING AND/OR DECELERATING. *TT Read More »
-
TSB #16090
SOME 4DR VEHICLES MAY EXHIBIT SEATING APPEARANCE OR RELATED ISSUES. *TT Read More »
-
TSB #14881
SOME VEHICLES EQUIPPED WITH 7 PASSENGER SEATING MAY EXHIBIT THE 2ND ROW 40 PERCENT SEAT BACK STAYING IN THE DOWN POSITION. THIS MAY BE DUE TO A RIVET INTERFERENCE AT THE FLOORPAN LATCHES. *TT Read More »
SEATS:FRONT ASSEMBLY:RECLINER
-
TSB #15329
SOME VEHICLES EQUIPPED WITH 3RD ROW SEATING MAY EXHIBIT A CONDITION WITH THE SEAT RELEASE LATCH STICKING/BINDING. *TT Read More »
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
-
TSB #15055
INFORMATION ON THE LOCATION OF THE HEATED SEAT SWITCH. *TT Read More »
BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT
-
TSB #05419
FALSE PARKING AID WARNINGS. *TT Read More »
-
TSB #04262
FALSE PARKING AID WARNINGS. *TT UPDATE. *TT Read More »
INTERIOR LIGHTING
-
TSB #01107
SOME VEHICLES BUILT 11/13/2000 THROUGH 3/8/2001 EQUIPPED WITH A 5R55W TRANSMISSION MAY EXHIBIT A TRANSMISSION CONTROL INDICATOR LAMP (TCIL) FLASHING WITH VARIOUS DIAGNOSTIC TROUBLE CODES (DTCS) IN SELF TEST. Read More »
EQUIPMENT
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #15938
INFORMATION USED WHEN REPLACING THE DRIVERS SEAT MODULE. *TT Read More »
-
TSB #15191
INFORMATION REGARDING NEW COMPASS SETTING PROCEDURE, PDI MUST SET ALL. *YD Read More »
EQUIPMENT:ELECTRICAL
-
TSB #17729
MESSAGE CENTER DISPLAYS COMPUTING FUEL INSTEAD OF DISTANCE TO EMPTY. *TT Read More »
-
TSB #15829
SUBJECT REGARDING CIGAR LIGHTER REVISED INSTALLATION PROCEDURES. *TT Read More »
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
-
TSB #15912
SUBJECT REGARDING FAMILY OR REAR SEAT ENTERTAINMENT SYSTEM HANDLE CONCERNS. *TT Read More »
EQUIPMENT:APPLIANCE:AIR CONDITIONER
-
TSB #17217
AIR CONDITIONER HOOTING NOISE DURING LIGHT LOAD ACCELERATION AT LOW SPEEDS, FROM 1000-1300 RPM. *TT Read More »
-
TSB #02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH Read More »
-
TSB #16309
HIGH SIDE PRESSURE FLUCTUATIONS ON VEHICLES EQUIPPED WITH A FIXED SCROLL A/C COMPRESSOR. *TT Read More »
-
TSB #15242
SOME VEHICLES MAY EXHIBIT UNEVEN AIR DISCHARGE TEMPERATURES IN A/C COOLING MODES. *TT Read More »
-
TSB #15263
CONCERNS WITH A/C PERFORMANCE TEMP. DIFFERENCE SIDE-SIDE AT REGISTERS. *TT Read More »
-
TSB #01126
SOME VEHICLES EQUIPPED WITH THE MANUAL A/C SYSTEM MAY EXHIBIT A CONTINUOUS CLICKING NOISE FROM THE BLEND DOOR ACTUATOR WHENTHE BLOWER SPEED IS SET AT THE #2 POSITION AND THE TEMPERATURE CONTROL KNOB IS SET BETWEEN THE 12:00 AND 2:00 ... Read More »
UNKNOWN OR OTHER
-
TSB #0256
THIS BULLETIN INVOLVES PROPER PROCEDURES FOR PREPARATION OF SERVICE SHEET METAL PARTS COATED WITH ELECTRO DEPOSITION PRIMER (E-COAT). *TT Read More »
-
TSB #0232
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT Read More »
-
TSB #15605
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
-
TSB #15504
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
-
TSB #15563
INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH Read More »
-
TSB #15486
SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457 (GROSS LEAK AFTER FUEL FILL). *TT Read More »
-
TSB #15215
SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457 STORED. *TT Read More »
-
TSB #15215
SOME VEHICLES MAY EXHIBIT DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 OR P0457. *TT Read More »
-
TSB #01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »
-
TSB #15093
EXHIBITING DRIVABILITY CONDITIONS OR CHECK ENGINE LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
-
TSB #011007
SOME VEHICLES BUILT 11/13/2000 THORUGH 3/8/2001 EQUIPPED WITH A 5R55W TRANSMISSION MAY EXHIBIT A TRANSMISSION CONTROL INDICATOR LAMP (TCIL) FLASHING WITH VARIOUS DIAGNOSTIC TROUBLE CODES (DTCS) IN SELF TEST. Read More »
-
TSB #14710
SUBJECT REGARDING EDSR BONUS POINTS. *TT Read More »
-
TSB #14745
INFORMATION ON OBTAINING ENGINEERING ASSISTANCE FOR ANTI-LOCK BRAKE SYSTEM. *TT Read More »
-
TSB #14741
MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1633 AND / OR P1639 WITH NO DRIVEABILITY CONCERN PRESENT. *TT Read More »
-
TSB #14742
SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH EGR SYSTEM RELATED DIAGNOSTIC TROUBLE CODES P0400, P0401, P0402, P1400, P1401, P1405, P1406, P1408, P1409. *TT Read More »
-
TSB #14741
MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P1633 AND / OR P1639 WITH NO DRIVEABILITY CONCERN PRESENT. *TT Read More »