We are having issues when braking. The backend of the car wiggles when braking hard. Shop advised that the subframe on the passenger side completely broke away and on the driver side it is very rotted. They advised this is a safety issue since the broken side could pierce the gas tank. I googled this and found that there was a warranty extension for the same year and make car (document MC-10233796-0001) Spoke to the service department and they advised this did not apply to our VIN. I called the corporate number on the warranty extension letter and they advised the same. My complaint is that several other Mercedes models and makes have this issues and are covered. Why isn't ours? Based on images I found online it looks to be the exact failure mode. My son was supposed to drive the car 4.5 hours on the 4th and could have gotten into an accident or been stranded. I also read that in Germany they are fixing all vehicles with this issue.

- Purcellville, VA, USA

Took my car for a doorknob repair and was told the whole subframe is rotted. They told me not to drive the car on the highway. The car brakes very hard to the right and always goes right while making cranking noises. Car feels very unsafe. I paid a lot of money for this and own a 2012 c300 4matic.

- Pine Brook, NJ, USA

This is a low mileage car with odometer reading of 25668 (less than 2000 miles per year), used sparingly and always parked in the garage. On 05/07/2024 I noticed brake fluid flowing from the left rear side of the car; on examination this seemed to come from the flexible hose that connects the brake fluid line to the brake caliper. I called my Mercedes-Benz (MB) dealer and arranged for further inspection and service. The technician identified that the brake fluid lines to the rear were both totally corroded and in need of immediate replacement. Since the lines were embedded behind the subframe it necissated lowering the subframe to access. Other parts were also severely corroded and required replacement. (see attached PDF of Invoice) The total cost of the repair was $4,592.93. The dealership applied a discount of $150 to this for an amount due of $4,442.93. As an engineer, I believe the material used for the brake fluid lines were unsuitable and furthermore were unprotected for the harsh environment experienced under the car, and I believe MB with all their experience in automobiles manufacturing over the years clearly should have known and forseen this fact; I do believe that MB is responsible for this premature failure of the brake lines of my car aven driven only 25,666 miles to date. I am therefore requesting NHTSA to require MB to reimburse me for the unnecessary expense of the costly repairs. It is only fortunate that this failure was identified in my garage and not on the highway. Please advise me of your resolution. Thank you.

- Sudbury, MA, USA

car has a rear subframe damage from corrosion

- Chicago, IL, USA

Rear subframe is corroded, rusted through, and cracking.

- Sussex, NJ, USA

The contact owns a 2012 Mercedes-Benz C300. The contact stated that the vehicle was making a loud bang sound towards the rear of the vehicle while driving over bumps in the roadway. The contact took the vehicle to the dealer and was informed that the rear subframe and the rear brake line were severely rusted. The subframe was replaced under an extended warranty coverage; however, the brake line was not covered under the extended warranty. The brake line was not replaced. The manufacturer was made aware of the failure. The approximate failure mileage was 110,000.

- Duxbury, MA, USA

Recently we had he brakes replaced and new tires put on to prepare for a trip out to Minnesota in a couple of weeks. My son felt like the car wasn-??t driving correctly and took it to the shop and upon being put on the lift the service department called and said the rear subframe rusted out and was broken and the gas tank was scratched do to the subframe rubbing against it. When he called Mercedes they told him there was an extended warranty put on these cars which I never received a letter concerning this issue. car is waiting to be towed to Mercedes, they would not give us back the keys, it was too dangerous to drive. son unknowing drove this car on the highway putting himself and others in danger for who knows how long. If he did not take it in for a check before driving himself and his father to Minnesota they could have been killed. Perhaps a fire due to the gas tank damage. *confirmed by independent repair shop but will be seen when the car is towed to Mercedes. *there was no warning to the dangerous situation my family was placed in. The cars should have been recalled. We were told by Mercedes they were fixing the problem as it arises, luckily no one was injured or killed when this problem arose!

- Hammonton, NJ, USA

The subframe assembly on my car is defective, as I learned today from my mechanic. This issue is known for my model of car and widely reported online. The mechanic says they have seen this issue before. I heard a strange noise while driving so I took the car to the shop after 60 days of enduring the sound. The shop immediately deemed the car unfit for driving and unsafe. In their words, if I had hit one bad pothole, the wheels could have come off the back of my car, and my gas tank could have been punctured, leading to a potentially catastrophic accident. I am lucky to have gotten this defective part identified before being injured, and others need to be protected from this outcome before a serious injury occurs. As of now this has only been inspected by the shop doing the fix. People online have indicated that Mercedes will not fix the problem free of charge - and in fact they charge a premium to other places to replace this faulty subframe. There were zero warning indicators of this dangerous issue - the car drove completely normally aside from an infrequent knocking sound that would occur every 5-10 minutes under normal city driving conditions.

- Seattle, WA, USA

Cradle and subframe are completely rusted out. This a widely common issue with these cars and am reading it across several forums. Other c300 owners say they have had the exact same issue and request for the MB dealership to fix it. Instead they are given a quote of nearly $10,000 to fix it. MB is responsible for this.

- Perrysburg, OH, USA

As per an inspection by my mechanic, the rear sub frame of the vehicle has cracked due to rust corrosion and subsequent metal failure. I first noticed the issue when there was a thumping sound over bumps and the car started to swerve when applying brakes on the highway, quite a scary situation as I thought the brakes were failing. The car has 78000 miles and has had all maintenance done. The is no other rust on or underneath the car. According to my research on Mercedes-Benz owner forums I discovered that it is a common issue and that, so far, Mercedes Benz has not issued a recall in the US. According to these forums Mercedes has issued recalls in other countries (although I have not confirmed this point). The estimated cost to replace the sub frame is $3000 including labor and there is an 8 to 10 week backlog for the part due to the number of failures occurring. In the meantime I cannot drive the vehicle as my mechanic has told me that the car is not safe to operate.

- Darien, CT, USA

The rear subframe rusted and completely cracked. The car started to shake violently while I was on the highway. Fortunately I was in the right hand land and was able to slow down. I was driving in the car with my mother. My understanding from the mechanic is that we were lucky not to be killed or hurt anyone else. The frame is completely cracked. I called the local dealership and they said this is an extremely common problem. So common they have multiple vehicles on the lot waiting for parts, and the waitlist is indefinite. There were absolutely no warnings on the car.

- Alexandria, VA, USA

I have a 20212 Mercedes C300 with 70,000 miles. I took it into the MB dealership for inspection and was told that the rear subframe was rusted through. The subframe's failure also caused the brake lines to rust to the point of needing to be replaced. The subframe repair will cost $5,900 and the brake line replacement will cost around $1,200. The dealer told me the car couldn't be driven safely, so I had to leave it there to be repaired. There were no interior warning alarms about the structure or the brakes. According to forums on Benzworld.org, this is a known problem on these specific cars and the component is replaced for free by MB in Europe.

- West Chester, PA, USA

Rear Subframe Cracking in Mercedes Benz 2012, C- Class, Sports. It can be life threatening for driver and passengers. Cost is $5700 for repairs. This replacement is free in Europe and Canada.

- Wilmington, DE, USA

Rare Subframe breaking off parts are not available for at least 6 months. I have kids and mechanics advise me to keep it off the road. My only means of transportation

- Ashburn , VA, USA

- Right Rear Subframe; Yes, available for inspection. - My mechanic told me that driving the car more than 2 miles or at a high rate of speed was very dangerous. He told me there that if the car braked quickly or was driven at a high rate of speed that there was a very good chance of an accident. There is a risk of the right control arm detaching from the frame; this could cause the car to be uncontrollable with the right rear wheel and control arm detaching from the vehicle. - Yes, the issue was confirmed by my mechanic, who works at an independent service center. - No. - There were no warning lamps or messages. I had begun to hear a loud clunking noise, usually when braking.

- Jenkintown, PA, USA

I-??m filing a complaint due to a concern regarding the rear subframe of my vehicle becoming rotted/rusted out and falling apart at any time. This is due to a Mercedes Benz manufacturing issue where they tried cost cutting which turned out very poor quality materials for this very important assembly. I have researched online about this problem, and turns out, it is very common with this body style c300 ('08 - '14). There are hundreds, if not thousands, of individuals within the USA who are having this exact same issue with as little as 60,000 miles. Most are happening around the 90,000 mile mark however. They primarily mention in many online forums how scared they were when it happened and how lucky they are it didn-??t cause a major accident-??yet. My car only has ~110,000 miles and is just about 10 years of age. This issue should never happen for a vehicle with such low miles and such a short life, especially from a prominent and distinguished automotive company. This is a Huge Safety Concern, and I am Scared that this subframe will fail without warning and at a high speed, which can likely cause me to be involved in a major accident where people are killed or seriously injured. It is astonishing how this subframe was not recalled by now and how Mercedes USA has not taken responsibility for this. This issue needs to be addressed and recalled Immediately before people are killed or seriously injured, and before more of these parts break. Please look into this very soon as this is a very serious matter.

- Seymour, CT, USA

the Rear Subrame CRACKED while Driving, Almost causing a Major accident with my son in the car as well. This seems to be a MAJOR problem being overlooked and ignored by Mercedes Benz. This repair is going to Cost me $ 3000-$ 5000 Dollars. and the Replacement Subframe is Impossible to find and on Back order ! so Now I'm without a Vehicle for God knows How long "? I Feel there is No Doubt this is a Defect and Should be Covered by Mercedes Benz and a Recall ! How is this not being investigated is Really Scary. How can a Frame or a Car just Crack " That's Not safe for ANYBODY !

- Sutton, MA, USA

During a routine oil change Mercedes mechanic discovered our rear subframe is rusted on both sides and needs to be replaced. This is apparently a well known problem, and Mercedes will replace this for free in Germany, but has not recalled the subframes in the US. Mercedes created a new OEM part as the replacement part, proving the original part is faulty. However Mercedes does not have enough parts ane every mechanic we have spoken with has several subframes on order for months at a time. We have waited 9 weeks at this point. Many Mercedes drivers subframes have broken making the cars undrivable.

- Falls Church, VA, USA

Dealer states that the rear subframe has rusted and degraded to the point of requiring full replacement. The car is 10 years old with 98,000 miles on the odometer. This is premature degradation of an essential component.

- Milford, CT, USA

Took my car in for inspection at the Mercedes dealership. They advised the rear subframe was rotted or rusted. This occurred from the inside. The vehicle is garage kept. They advised Mercedes has no re-call on the issue in the United States. They are covering the issue outside the US. This is a major safety issue.

- Elizabethtown, PA, USA