This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Started smelling smoke randomly and discovered an apparent oil leak in the engine. Mechanic inspected and noted that it appears to be an issue relating to the cylinder head/head gasket, which is in line with a technical services bulletin put out by Mazda several years ago for this make/model/year for a known design flaw that can result in catastrophic engine failure. I am just outside the five year warranty but well under the 60,000 miles, so expecting them to tell me they won't cover the repair even though this should have been a recall due to the potential outcome. I cannot drive the vehicle until this is repaired because it can cause engine fires (or worse).
There is a coolant leak at the cylinder head. We have been told that the cylinder is cracked at the back of the cylinder head where the exhaust ports meet. The dealer's technician said there is a "redesign" in the cylinder head. This is a known issue that is a defect apparently due to Mazda's design of securing the turbo on exhaust studs that are not designed to hold the weight. Why has there not been a recall? There is a Mazda TSB - 01-013/21, issued 10/15/2021 Verbal estimate from dealer for repair - over $7,000
My vehicle started smoking and I smelled a oil burning smell coming through the vents. I took it to the Mazda dealership and they diagnosed it with a cracked cylinder head. The repair estimate is $4,900. It is a 2019 with less than 60,000 miles, but it is a few months out of the powertrain warranty. However, this is a KNOWN issue to Mazda. As I have been researching online, many Mazda CX-5 owners have reported the same issue and I believe Mazda has traced it back to defective manufacturing in a batch of these parts. My local mechanic has also told us that he has seen this issue with 2019 Mazda CX-5s and recommended we report them. Mazda SHOULD issue a recall, but I understand that is expensive for them. At the very least, they should alerting drivers to this possibility and voluntarily repairing these cylinders without cost to unsuspecting drivers who could end up with an engine fire. I have submitted a complaint to Mazda customer service and I am awaiting a response.
I am writing to express serious concerns regarding the recent service that occurred on November 14th, 2023. Due to the service's failure and negligence, Luther Brookdale Mazda has jeopardized the safety and well-being of my family members. On [XXX], my 2019 CX-5 was towed from Monticello, Minnesota, to the dealership in Brooklyn Center around 9 pm. While returning from [XXX] dinner in St. Cloud on [XXX], a sudden warning appeared on the dashboard: "Engine Coolant Temperature High. Stop the vehicle immediately in a safe place." Upon receiving this notification, we pulled over to the shoulder and observed smoke emanating from the engine bay. We promptly turned off the vehicle. Concerned for our safety, we contacted our family to pick us up and had the vehicle towed by AAA. As we awaited the tow truck's arrival, we noticed coolant had sprayed all over the engine under the hood, and the engine cover was missing. Furthermore, the coolant reservoir was below the minimum threshold. This particular issue is the reason I brought the vehicle in for service the week prior, regarding insufficient coolant temperature. It was evident from the state of the engine bay that the dealership failed to follow proper protocol. This lack of oversight likely resulted in damage to the engine and other essential vehicle components, leading to the total loss of the car. I am deeply disappointed by the lack of care and attention to detail in the service provided. This negligence also compromised my family's safety. Moreover, what was meant to be a festive holiday was marred due to the disregard for my property. I have been a loyal customer at Luther Mazda Brooklyn Park for several years, and I am shocked by the incident that has transpired. We have approached the dealer with the issue and they are continue to articulate that there is no engine damage, but with the ongoing class action lawsuit, I am extremely skeptical of their claims. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
This report is for a 2019 Mazda CX-5 with the Naturally Aspirated/Non-Turbo engine. This vehicle only has 26,500 miles and has developed a major oil leak from a cracked Cylinder Head. The continued safety of the vehicle has been degraded. The engine could seize while driving making the vehicle inoperable while on roadways. The vehicle has been inspected and confirmed by both an independent service center and by an authorized dealer service center. The only warning lamp that appeared was a low oil light. I immediately pulled over for safety and inspected the oil levels of the engine. I determined the engine oil levels were just below the fill line on the dip stick. I then added approximately half a quart of recommended oil and the oil warning light turned off. I then contacted a local service center for diagnostics of the problem. They determined the cause of the oil leak which was a Cracked Cylinder Head on the Engine. I then drove the vehicle to an authorized Mazda service center at the dealership. They also diagnosed the problem as a Cracked Cylinder Head on the Engine. Both the independent service center and the authorized Mazda service center recommended a full Engine replacement.
- St George, UT, USA
Search CarComplaints.com for these popular complaint phrases...
I have a 2019 CX5 Mazda that consistently leaks oil and smokes. After taking it to a mechanic, I learned that this is a known Mazda issue, but because my car is under warranty, they won't help me. The Cylinder head is pours, and my mechanic said even if he replaces it, it will happen again due to the design. After I have checked online, it seems that MANY people have this issue from 2018-2021. Mazda even made TSB #SA-031-21 to cover some of this issue but no recall. As mentioned, my car leaks oil everyday, and I have to constantly put oil in just to keep it from burning up. It smokes really bad, but I cannot afford a new car or afford to pay over $3K to get this fixed, or don't understand why they won't fix it if they know it was poor design"?"
The contact owns a 2019 Mazda CX-5. The contact stated while driving 35 MPH, the vehicle was smoking. There were no warning lights illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was oil leaking from the main gasket and referred the contact to the dealer. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 31,000.
The 2019 Mazda CX5 GT started to make a clicking noise coming from the engine. After much investigation online, sharing multiple resources of videos and sound this seems to be the hydraulic lash adjusters for this specific year and model. Unfortunately this is outside the normal warranty and wasn't noticed until now. The car was inspected by local independent service center. This would pose risk to my family and others if the vehicle seized to work properly. There were no warnings given other than the clicking noise and inspected.
engine head crack causing antifreeze leak. caught problem at 65980 miles. Defect confirmed by dealer. I had no indication of problem, only a terrible smell/odor. Dealer indicated a $6000+ cost of repair.(out of warranty). Thank goodness for extended warranty I purchased. I feel Mazda should be held accountable.
Went to drive home from work one night, car had been normal until this event. Car suddenly began to state that it was overheating and throttled my speed down to 20 MPH. I was in the middle of traffic going 40-50 at this time. Turns out there is a VSB regarding a coolant leak that can occur and break. Nothing about how you are suddenly governed to 20 MPH
I had just had my car serviced for 30k services and about 2 months later smoke was coming out of my engine after driving. Took it in and it turned out to be a cracked cylinder head. None of my lights were on indicating there was an issue either. I was told this is a known issue with Mazda and should be a recall but there still isn-??t one. TSB#SA-031-21
The Cylinder head cracked and caused oil to spill out. This was inspected at Towne Mazda in Orchard Park, NY. I was driving ~50 miles when the issue occurred, and had driven approximately 40 of the 50 miles when me and my sister pulled over and noticed my engine smoking and the burning smell to be pungent. Had I not pulled over, It could have led to engine misfire and damage to other parts of my vehicle. The Dealer confirmed the need for a new cylinder head and parts, and is currently repairing the vehicle. The Component was not recently inspected by the manufacturer, police, insurance. During the course of driving, after about ~35 miles, the oil pressure light turned on. I drove roughly 5 more miles before I pulled the car over to have it towed to my Mazda dealership.
As I was driving home one day in February 2024, my car felt like a strong gust of wind was getting up underneath the hood of my car, causing it to pull left and right slightly. When checking the weather, wind gusts were at 5 MPH and you could barely see trees/leaf movement. I pulled off the side of the road, checked underneath the car to see if anything was dragging/missing and all was fine. As I started driving again, I then noticed my RPM's vs MPH was very strange. When accelerating, the car randomly increased up to 4,500 RPM when trying to go 45 MPH, then shifted down to 2,000 RPM's once I reached 45 MPH. But, no matter if I left my foot on the gas pedal, lifted my foot off of the gas pedal or hit the breaks, the car would not move off of 2,000 RPM's until I pressed my foot on the break all the way down to the floorboard. No lights came on at all. I took it to the dealership that I purchased it from, expressing the scary feeling of the driving the car and showing video proof of what the car was doing in RPM's vs MPH. After further conclusion, they determined that a "sensor" had gone bad. The thought that a plastic, electronic sensor going back caused my car to feel that way and put my life at risk while driving is a scary thought. Fast-forward to April of 2024, similar symptoms have come back again. Wind feeling like it's getting under my hood, causing the car to pull left and right, RPM's not matching up and now a hot engine with no warning light coming on, is questioning if it's this particular sensor again. Not to mention, I had it inspected by the dealership two weeks ago and had an oil change done to it and the dealership said "everything looks great". You should have zero thought or worry when operating your personal vehicle, but in the past three months, I have taken my car to the dealership and or a mechanic 7 times with thoughts/worries about my car. This car has now turned into a "lemon" as one would call it and I'm terrified to even start the car.
Had a constant Valve tick on cold starts and sometimes while running long periods. Oil level top offs and changes did not remedy the issue. Mechanic says it's a bad valve lash adjuster.
I developed a cracked cylinder head in my 2019 Mazda CX-5 that only had 33,000 miles on it. I lost approximately 50% of my oil in a 4 mile drive. I believed I had been leaking oil, checked the dipstick, drove 4 miles (max speed of 35 mph), smelled the burning oil, pulled over, saw smoke coming from the hood and checked the dipstick again. Losing this much oil is a safety risk with the possibility of a fire especially if driving at a faster speed and inability to have a safe place to pull over along with smoke from the burning oil causing visibility issues which at higher speeds such as on an interstate can cause a safety concern. No indicator lights/messages appeared, this was determined from seeing what I thought was oil on the ground and then checking the dipstick. Mazda is well aware of the issue. When picking up the car for the dealership after being fixed, I asked what kind of parts were used to ensure this does it happen again. The shop employee said they were -??revamped-?? parts due to the known issue with this model and pointed out 4 other Mazda cx5s currently in the shop with the same issue getting repaired.
Had the sudden onset of strong exhaust fumes in the cabin as others have described - especially when idling at a light. Returned to dealer after having it up on a rack to find oil dripping everywhere (shield underneath prevents from seeing drops when parked) - got word today it is indeed the cylinder head assembly. How is oil running on hot exhaust not a fire concern? I had to roll my windows down for fresh air in zero degree weather the fumes were so strong inside the vehicle. On top of that the P0126 (thermostat stuck open) diagnostic code is back for the second year in a row after having the -??fix-?? installed under warranty last year.
My engine started smoking while I was driving fast got out of car oil leaking everywhere there was a crack in the cylinder head, another few minutes of driving and the car could have burst into flames seems like it-??s a common issue with Mazda cx5 a quick google search has shown me I-??m not the only one with this issue, worst thing about it is Mazda refused to fix it.
A D V E R T I S E M E N T S
- Linthicum, MD, USA