Technical Service Bulletins (TSBs) for the 1999 Town Car are official communications between Lincoln & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
INFORMATION REGARDING PASSIVE ANTI-THEFT SYSTEM (PATS) TRANSCEIVER WIRING MAY BE BROKEN DUE TO IMPROPER WIRE ROUTING AND / OR A MISPLACEMENT OF THE CONNECTOR NEAR THE BASE OF THE STEERING COLUMN. Read More »
ON SOME VEHICLES THE REAR SUSPENSION UPPER CONTROL ARM BRACKETS ON THE FRAME MAY DEVELOP MINOR CRACKS WHEN SUBJECTED TO SEVERE DUTY SERVICE. *JB Read More »
SUBJECT PERTAINING TO COSMETIC CRACKS IN FRAME AT THE REAR UPPER CONTROL ARM ACCESS OPENING WHEN SUBJECTED TO SEVERE DUTY OPERATING CONDITIONS. *JB Read More »
SOME VEHICLES MAY APPEAR TO SIT HIGH IN THE REAR WHEN THE IGNITION IS FIRST TURNED ON DURING THE FIRST 200 MILES (320 KM) OF VEHICLE OPERATION. *TT Read More »
VEHICLE MAY APPEAR TO SIT HIGH IN THE REAR WHEN THE IGNITION IS FIRST TURNED ON DURING THE FIRST 200 MILES (320 KM) OF VEHICLE OPERATION. *MJS Read More »
DISLODGMENT OF REAR AIR SPRING FROM AXLE SPRING SEAT DURING ACCELERATION OR FULL SUSPENSION TRAVEL CONDITIONS ON SOME LIMOUSINE VEHICLES THAT ARE OPERATED AT OR NEAR MAXIMUM LOADS. *AK Read More »
SOME VEHICLES EQUIPPED WITH TEVES FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT A YELLOW ANTI-LOCK BRAKE LAMP ILLUMINATED WITH NO DIAGNOSTIC TROUBLE CODES IN MEMORY. *TT Read More »
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
SOME VEHICLES, BUILT BEFORE AUGUST 31, 1999, ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MAY DISPLAY THE OUTSIDE TEMPERATURE VALVE LOWER THAN THE ACTUAL OUTISDE TEMPERATURE WHEN OPERATED UNDER CERTAIN WEATHER AND LOW MEDIUM DRIVING ... Read More »
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
VEHICLES BUILT UP TO DECEMBER OF 1999 MAY EXHIBIT A CLUNK NOISE FROM THE REAR OF THE VEHICLE WHEN DRIVING OVER SPEED BUMPS. THIS MAY BE CAUSED BY THE FILL-LIMITING VALVE INSIDE THE FUEL TANK. Read More »
ON SOME VEHICLES, THE ENGINE MOUNTS MAY NOT EXHIBIT SATISFACTORY DURABILITY UNDER SEVERE OPERATING CONDITIONS THAT MAY BE ENCOUNTERED BY POLICE, TAXI OR LIMO / LIVERY VEHICLES SUCH AS EXTENDED IDLING AT HIGH AMBIENT TEMPERATURES. Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. Read More »
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. Read More »
VEHICLES BUILT UP TO DECEMBER OF 1999 MAY EXHIBIT A CLUNK NOISE FROM THE REAR OF THE VEHICLE WHEN DRIVING OVER SPEED BUMPS. THIS MAY BE CAUSED BY THE FILL-LIMITING VALVE INSIDE THE FUEL TANK. Read More »
SOME OF THE COMPOSITE INTAKE MANIFOLDS USED ON 4.6L SOHC ENGINES MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. THIS CONDITION COULD RESULT IN ENGINE COOLANT LEAKAGE WHICH, IF NOT SERVICED, MAY CAUSE ENGINE OVERHEATING. Read More »
OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE ON CERTAIN 4.6L SOHC INTAKE MANIFOLDS. SOME OF THE COMPOSITE INTAKE MANIFOLDS MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. Read More »
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. Read More »
INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639 PRESENT AFTER A POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT. Read More »
THIS BULLETIN STATES THAT ON SOME VEHICLES (INCLUDING 2002 BLACKWOOD) A BATTERY DISCONNECT OR PARAMETER RESET IS REQUIRED DURING POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER (VIC / HEC / ICM) REPLACEMENT. Read More »
INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE POWERTRAIN CONTROL MODULE (PCM) INFORMATION CHARTS. *TT Read More »
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
ON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION. STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT Read More »
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
SOME VEHICLES MAY EXHIBIT VARIOUS CLUSTER CONCERNS SUCH AS ILLUMINATION OF THE CHECK TRACTION ASSIST LAMP, SPEEDOMETER READS O; DIGITAL ODOMETER READS ALL DASHES; MESSAGE CENTER DISPLAY FOR DTE / GTE READS FOR LOSS OF SPEED SINGLE TO THE ... Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
CONCERNS THAT THE PASSIVE ANTI-THEFT SYSTEM (PATS) TRANSCEIVER WIRING MAY BE BROKEN DUE TO IMPROPER WIRE ROUTING AND / OR A MISPLACEMENT OF THE CONNECTOR NEAR THE BASE OF THE STEERING COLUMN. Read More »
VEHICLES WILL NOT START WITH A PROGRAMMED PASSIVE ANTI-THEFT (PATS) KEY FOR 20 SECONDS AFTER AN ATTEMPT TO START WITH A NON-PROGRAMMED PATS KEY. *MJS Read More »
CERTAIN VEHICLES WILL NOT START WITH A PROGRAMMED PASSIVE ANTI-THEFT (PATS) KEY FOR 20 SECONDS AFTER AN ATTEMPT TO START WITH A NON-PROGRAMMED PATS KEY. *TT Read More »
INFORMATION REGARDING DRIVERS DOOR MODULES (DDM) INCORRECTLY REPLACED WHEN DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) / BATTERY RELATED NO START CONDITIONS. *TT Read More »
SOME VEHICLES EQUIPPED WITH FACTORY MOONROOFS AND BUILT THROUGH 9/20/1999 MAY EXPERIENCE A BOOMING NOISE WHILE DRIVING WITH THE MOONROOF OPEN. *TT Read More »
SOME VEHICLES EQUIPPED WITH FACTORY INSTALLED MOONROOF MAY EXHIBIT A BOOMING OR BUFFETING NOISE WHILE TRAVELING AT SPEEDS GREATER THAN 40 MPH WHEN THE MOONROOF IS OPEN. *TT Read More »
SOME CARS EQUIPPED WITH FACTORY INSTALLED MOONROOF MAY EXHIBIT A BOOMING OR BUFFETING NOISE WHILE TRAVELING AT SPEEDS GREATER THAN 40 MPH WHEN THE MOONROOF IS OPEN. *TT Read More »
SOME VEHICLES MAY DEVELOP COSMETIC CRACKS IN THE FRAME AT THE REAR UPPER CONTROL ARM ACCESS OPENING WHEN OPERATED UNDER SEVERE DUTY CONDITIONS. *TT Read More »
CUSTOMER SATISFACTION PROGRAM 05B31 - INFORMATION ONLY. A POSSIBILITY THAT DURING A HIGH SPEED / HIGH ENERGY REAR COLLISION, CERTAIN COMPONENTS HAVE AN INCREASED RISK OF PUNCTURING THE FUEL TANK ON VEHICLES WITH LIMO PREP PACKAGE LIMO ... Read More »
FOR ALL VEHICLES WITH DRIVERS DOOR MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING. *TT Read More »
FOR ALL VEHICLES WITH DRIVERS SEAT MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
SUBJECT PERTAINING TO THE SERVICE MANUAL NOT HAVING A PINPOINT TEST FOR "DEGRADED AM RECEPTION OR CONTINUOUS SEEK IN AM" IN THE DIAGNOSIS AND TESTING PORTION OF THE AUDIO CHAPTER. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) WILL NOT CYCLE THE AI CONDITIONER COMPRESSOR WHEN THE FLOOR MODE IS SELECTED. *TT Read More »
VEHICLES MAY EXPERIENCE AIR CONDITIONING INACCURATE AMBIENT TEMPERATURE DISPLAYED- VEHICLES EQUIPPED WITH EATC- CONTINENTAL AND LS BUILT THROUGH 10/15/99, ALL OTHERS BUILT THROUGH 8/31/99. *MJS Read More »
VEHICLES BUILT THROUGH 4/16/1998 MAY EXHIBIT IMPROPER, ERRATIC, OR NO TEMPERATURE CONTROL OR POOR A/C PERFORMANCE AND / OR A POPPING / CLICKING NOISE IN MAX A/C ON VEHICLES BUILT THORUGH 4/1/1999. Read More »
VEHICLES BUILT BEFORE AUGUST 31, 1999 HAVE AN ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) THAT DISPLAYS THE OUTSIDE TEMPERATURE VALUE LOWER THAN THE ACTUAL OUTSIDE TEMPERATURE WHEN OPERATED UNDER CERTAIN WEATHER AND LOW / MEDIUM ... Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. Read More »
SOME VEHICLES MAY EXHIBIT THE FOLLOWING CONCERNS IMMEDIATELY AFTER STARTING THE VEHICLE: THE SPEEDOMETER WILL NOT DISPLAY VEHICLE SPEED, THE ODOMETER DISPLAY IS ALL DASHES, THE MESSAGE CENTER DISPLAY FOR DISTANCE TO EMPTY OR AVERAGE ... Read More »
SOME VEHICLES WILL NOT START WITH A PROGRAMMED PASSIVE ANTI-THEFT (PATS) KEY FOR 20 SECONDS AFTER AN ATTEMPT TO START WITH A NON-PROGRAMMED PATS KEY. THE PATS WILL NOT RECOGNIZE A PROGRAMMED PATS KEY UNTIL THE SYSTEM RESETS. Read More »
