Technical Service Bulletins (TSBs) for the 1997 Town Car are official communications between Lincoln & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
OWNER NOTIFICATION PROGRAM 98B19-S1 - BRAKE LINE WEAR ON CERTAIN VEHICLES. CORRECTION TO ORIGINAL TECHNICAL INSTRUCTIONS REGARDING DIAMETER OF REPLACEMENT BRAKE LINES. YD Read More »
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. Read More »
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. Read More »
FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. Read More »
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. Read More »
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. Read More »
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. Read More »
INFORMATION CONCERNING VIBRATION-SHUDDER UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35MPH) IN 3RD OR 4RD GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. Read More »
VIBRATION- SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. *JD Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0420 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD - BANK 1) AND/OR P0430 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD - BANK 2). Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
FOR ALL VEHICLES WITH LIGHTING CONTROL MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS ... Read More »
SOME VEHICLES EQUIPPED WITH FACTORY INSTALLED MOONROOF MAY EXHIBIT A BOOMING OR BUFFETING NOISE WHILE TRAVELING AT SPEEDS GREATER THAN 40 MPH WHEN THE MOONROOF IS OPEN. *TT Read More »
SOME CARS EQUIPPED WITH FACTORY INSTALLED MOONROOF MAY EXHIBIT A BOOMING OR BUFFETING NOISE WHILE TRAVELING AT SPEEDS GREATER THAN 40 MPH WHEN THE MOONROOF IS OPEN. *TT Read More »
CUSTOMER SATISFACTION PROGRAM 05B31 - INFORMATION ONLY. A POSSIBILITY THAT DURING A HIGH SPEED / HIGH ENERGY REAR COLLISION, CERTAIN COMPONENTS HAVE AN INCREASED RISK OF PUNCTURING THE FUEL TANK ON VEHICLES WITH LIMO PREP PACKAGE LIMO ... Read More »
FOR ALL VEHICLES WITH DRIVERS DOOR MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING. *TT Read More »
FOR ALL VEHICLES WITH DRIVERS SEAT MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
SOME 1995-1999 CROWN VICTORIA/GRAND MARQUIS/ CONTINENTAL, 1995-1997TOWN CAR AND 1997-1998 MARK VIII EQIPPED WITH REMOTE KEYLESS ENTRY, MAY EXHIBIT CONCERNS WITH INTERIOR LIGHTS TURNING ON AND THEN OFF WHILE PARKED. Read More »
VEHICLES EQUIPPED WITH A CELLULAR PHONE MAY EXHIBIT A CONDITION IN WHICH THE CELLULAR PHONE DOES NOT RING WHEN RECEIVING INCOMING CALLS. *TT Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES MAY EXHIBIT NO TEMPERATURE CONTROL AND/OR A CLICKING NOISE HEARD COMING FROM BEHIND THE INSTRUMENT PANEL NEAR THE GLOVE COMPARTMENT. *YC Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. Read More »
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
FOR ALL VEHICLES WITH REMOTE KEYLESS ENTRY CONCERNS THAT REQUIRE A MODULE AND / OR TRANSMITTER (KEYFOB) REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE OR KEYFOB. Read More »
