Technical Service Bulletins (TSBs) for the 2003 Navigator are official communications between Lincoln & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
ADVANCETRAC MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE C1277 (STEERING WHEEL ANGLE 1 AN 2 CIRCUIT FAILURE) OR C1278 (STEERING WHEEL ANGLE 1 AND 2 SIGNAL FAULTED) IN THE IVD MODULE. Read More »
FOUR CORNER LOAD LEVELING AIR SUSPENSION MAY EXHIBIT LEVELING CONCERNS, SUCH AS ONE FRONT CORNER DROPPING. INDIVIDUAL AIR SPRINGS AVAILABLE FOR SERVICE. *TT Read More »
THIS ARTICLE ADDRESSES THE PROPER PROCEDURE TO CLEAR DIAGNOSTIC TROUBLE CODES C1990 OR C1991 FROM THE VEHICLE DYNAMICS MODULE/4-WHEEL AIR SUSPENSION MODULE. *TT Read More »
BRAKE SHUDDER (ROTOR THICKNESS VARIATION) DUE TO THE NEW LOW DUST FRONT BRAKE LINING USED IN PRODUCTION, OR NEW LININGS THAT WERE INSTALLED PER TSB 04-05-02. *TT Read More »
DIAGNOSTICS FOR DIAGNOSTIC TROUBLE CODE C1991 IN THE ABS (ANTILOCK BRAKE SYSTEM) MODULE - OMITTED FROM WORKSHOP MANUAL - PROCEDURE PROVIDED. *TT Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. Read More »
SOME VEHICLES MAY EXHIBIT A NO-START CONDITION WITH NO FUEL PRESSURE PRESENT AND / OR FUEL PUMP CIRCUIT DIAGNOSTIC TROUBLE CODES P0231 OR P0232. *TT Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
TRANSMISSION FLUID LEAK BETWEEN THE RADIATOR TRANSMISSION OIL COOLER AND THE TRANSMISSION OIL COOLER FITTING (NOT THE COOLER LINE INTO THE FITTING), WHICH MAY RESULT IN A RESIDUE OF TRANSMISSION FLUID ON THE RADIATOR TANK AROUND THE ... Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT Read More »
CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS. CONCERNS MAY SEEM TO ORIGINATE FROM FRONT AXLE, OR STEERING GEAR. *TT Read More »
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
A DIAGNOSTIC TROUBLE CODE B2721 (LIFTGATE/DECKLID AJAR OUTPUT SHORT TO GROUND OR OPEN) IN THE POWER LIFTGATE MODULE, WITHOUT ANY ASSOCIATED SYMPTOMS - SERVICE TIP. *TT Read More »
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
DIAGNOSTIC TROUBLE CODE (DTC) P0320 WITH POSSIBLE DRIVEABILITY CONCERNS AND/OR CHARGING SYSTEM WARNING INDICATOR ON WITH POSSIBLE DTC P0620. *TT Read More »
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
ADVANCETRAC LIGHTING ON WITH DIAGNOSTIC TROUBLE CODE C1277 (STEERING WHEEL ANGLE 1 AND 2 CIRCUIT FAILURE) OR C1278 (STEERING WHEEL ANGLE 1 AND 2 SIGNAL FAULTED) IN THE IVD MODULE. *TT Read More »
DIAGNOSTICS PROVIDED FOR DIAGNOSTIC TROUBLE CODES C2777 / C2778 (SENSOR CLUSTER CAN BUS FAILURE / SENSOR CLUSTER POWER SUPPLY FAILURE). *TT Read More »
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
FRONT DOOR GLASS MAKING A POPPING NOISE AS IT ENTERS THE HEADER SEAL AT THE TOP OF THE DOOR OPENING AT HIGHWAY SPEEDS. IN THE CASE OF THE NAVIGATOR DRIVER'S DOOR, THE GLASS MAY BOUNCE OFF THE HEADER AND REVERSE TO A MID-POSITION. Read More »
LIFTGATE REVERSING DIRECTION WHEN CLOSING IN HOT AMBIENT TEMPERATURES ABOVE 90 F (32 C). DIAGNOSTIC TROUBLE CODE (DTC) B2825 PRESENT DURING SELF TEST. *TT Read More »
CLIMATE CONTROLLED (CC) SEAT MAY EXHIBIT PREMATURE SHUTDOWN OF THE CC SEAT WHEN IT IS IN HEAD MODE ON THE SECOND OR SUBSEQUENT HEAT CYCLES. *TT Read More »
SOME VEHICLES EQUIPPED WITH A 4R100 TRANSMISSION AND BUILT BETWEEN JANUARY 1, 2001 AND MAY 1, 2002 MAY EXHIBIT FLASHING TRANSMISSION CONTROL INDICATOR LAMP AND ANY OR ALL TORQUE CONVERTER CLUTCH DIAGNOSTIC TROUBLE CODES P0740, P0741, ... Read More »
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES P0740, P0741, P0743, AND P1744 (TORQUE CONVERTER CLUTCH). *TT Read More »
