Head gasket blew and caused coolant to leak into the engine. We broke down on the side of the interstate. Our vehicle sat at the dealer for 5 months awaiting a new engine to be put in. No warnings beforehand.

- Grantville, GA, USA

Engine in my 2018 Kia has failed. This should be covered under warranty as van only has 90k miles on it but because I am the second owner they are telling me it is not covered. Several other 2018 Kia-??s have already been recalled for engine failure. My car was burning oil. This is a manufacturing issue and I am very stressed about paying to get it fixed out of pocket.

- Pittsburgh , PA, USA

Blown engine at 108,000. Known issues with 3.3-liter V6 engine. Kia refises to repair.

- Vancouver , WA, USA

Engine failed. Replacement is required. Currently at dealership where auto was purchased. Dropped off 30 JUL '24. Waitng for replacement.

- Catawba, NC, USA

I took the vehicle to get serviced to check the engine light coming on. The Kia dealership stated that the CVVT Assembly and Oil Control Valve had to be replaced. The entire engine would have to be replaced if there was engine damage. The check engine would turn off for a couple of days and then turn back on. When the light would turn off, there was a lack of power, causing a lag in the throttle control.

- Bakersfield, CA, USA

108,000 miles failed engine due to know rod issues with this engine

- Vancouver, WA, USA

While driving at highway speed all the dashboard lights came on and the engine instantly quit. I managed to pull the wheel and coast to the side of the road, which was difficult with no power steering. I tried restarting the engine, but it would not stay running. I had to have the car towed to the mechanic who, upon inspection, found the engine seized due to no oil. An engine replacement was required. All routine maintenance performed on this engine and records were provided. The dealership where I purchased the vehicle refused to replace the engine under warranty, 92330 miles, stating the engine showed "sludge" and was not maintained, this despite my providing maintenance records. This catastrophic engine failure was caused by a manufacturing/engineering defect in the GDI engine causing the engine to burn oil excessively. There was no indication of a problem prior to the failure. The failure at highway speed could have easily caused serious injury or death.

- Rockwall, TX, USA

I was driving my 2018 Kia Sedona on [XXX]. I had all 4 of my kids with me in the van, I heard a click, click, click, then the car went dark, in the middle of the road no warning nothing. There was no light or anything that came on as a warning. It just died. It was scary to go through that with my kiddos. We are devastated as the car is only 6yrs old and it wont work at all. Had it towed to my local auto shop. They said the engine is defective and needs to be replaced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Maple Valley, WA, USA

10 mile drive to town. On return home, smoke began pouring from the engine compartment. Within 3-4 minutes flames came from grill area, and within 15 minutes entire car was engulfed in flames.

- Rosman, NC, USA

Vehicle was idling when smoke and fire started presumably from the engine causing a car fire. We are the insurance company that paid for the car and Clearcover Insurance is now the owner.

- Portsmouth, NH, USA

We barely use it and just for Sunday service only which our church is just 2 miles away from our home. We did the oil change last July 2022 and on December 2022, Suddenly the engine stops working (ONLY 120 MILEAGE ADDED). NO WARNING LIGHTS or INDICATION saying ENGINE OLI needs to change. My son heard a clunk noise while he's on the way home. Huntington Beach Hyundai Service center said that the ENGINE BROKE DUE TO OIL ISSUE.

- Anaheim, CA, USA

Our 2018 Kia Sedona SXL caught on fire in the engine compartment while driving. IT almost killed my wife (driver) and my 4 year old son. Car had been driven only 2 blocks after picking up my son from daycare. The car started to produce black smoke incessantly from the engine compartment that made visibility almost impossible. Bystandards were waving with their arms up and trying to warn my wife and she managed to stop in a parking lot and run away with my son. Car got very hot. Despite of keeping regular maintenance, car has had a myriad of issues: electrical components going off and not working anymore (cruise control, rear view camera, navigation system), booming sound from air conditioner like an old airplane is inside the cabin..etc.There were no warning lights suggesting any problem before car caught on fire. Please help.

- New Orleans, LA, USA