Technical Service Bulletins (TSBs) for the 2016 Wrangler are official communications between Jeep & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
The SKU is a Tie Rod Center Stud. The Customer commnunication requested return of unsold inventory to inpsect for possible incorrect direction threads (right hand rather than left hand). Read More »
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. Read More »
Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob. Read More »
Incorrect Front Caliper Slide Pins This bulletin involves inspecting the front caliper slide pins and if necessary replacing the slide pins. The customer may describe rattle in front brakes. Read More »
Wheel Speed Sensors For Jeep Wrangler (JK) only. Before replacing the wheel speed sensors, please check for wiring/connection to the speed sensor. If the sensor is replaced, record the fault codes and note any damage to the sensor. Read More »
"ANTI-LOCK BRAKE MODULE (ABS) 2015 AND 2016 JK ONLY; BEFORE REPLACING THE ABS MODULE, PLEASE CALL BREANNE SCHERBATY AT CELL (586) 604-4582. IF YOU DON'T RECEIVE RESPONSE WITHIN 15 MINUTES, PLEASE CONTINUE WITH NORMAL REPAIR PROCEDURE. Read More »
Anti-Lock Brake Module (ABS) 2015 and 2016 JK ONLY; Before replacing the ABS module, please call Breanne Scherbaty at cell (586) 604-4582. If you don't receive response within 15 minutes, please continue with normal repair procedure. Read More »
KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press ... Read More »
KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press ... Read More »
Console Lid If you are replacing the console lid because it does not open properly or because the button covers are missing, check STAR Parts - there is a button cover replacement kit available. Read More »
3.6L Oil Pan Drain Plug and Pan: When an oil pan leak is detected and the oil drain plug is loose please on JK/KL models call one of the following people. If your call in not answered within 15 minutes please proceed with the repair. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) All vehicles equipped with a 3.2L or 3.6L except for model year 2014 vehicles with leak concern: 1) Ensure the Oil Filter Adapter (OFA) Cap O-ring is seated in the proper groove in the cap and ... Read More »
Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block ... Read More »
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob. Read More »
Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable provided they are not cut, torn or melted. Read More »
3.6L Oil Pan Drain Plug and Pan: When an oil pan leak is detected and the oil drain plug is loose please on JK/KL models call one of the following people. If your call in not answered within 15 minutes please proceed with the repair. Read More »
3.6L Oil Pan Drain Plug and Pan: When an oil pan leak is detected and the oil drain plug is loose please on JK/KL models call one of the following people. If your call in not answered within 15 minutes please proceed with the repair. Read More »
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA). Read More »
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
Fuel Tank and Fuel Evap System Components 1) For JK MIL On ? P0441: Before replacing this part due to fault code P0441, check for restriction due to plastic over-flash in the Purge Hose Port of the Intake Manifold. Read More »
Fuel Tank 1) Before replacing this part due to fault code P0441, check for restriction due to plastic over-flash in the Purge Hose Port of the Intake Manifold for the ERB (3.6L engine only). Read More »
Fuel Tank and Fuel Evap System Components Before replacing this part due to fault code P0441, check for restriction due to plastic over-flash in the Purge Hose Port of the Intake Manifold. Read More »
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob.Bruni@fcagroup. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob. Read More »
Replace Fuel Tank This bulletin involves replacing the fuel tank. Some vehicles may have been built with a fuel tank that is out of specifications. Read More »
Replace Fuel Tank This bulletin involves replacing the fuel tank. Some vehicles may have been built with a fuel tank that is out of specifications. Read More »
Replace Fuel Tank This bulletin involves replacing the fuel tank. Some vehicles may have been built with a fuel tank that is out of specifications. Read More »
Replace Fuel Tank This bulletin involves replacing the fuel tank. Some vehicles may have been built with a fuel tank that is out of specifications. Read More »
Fuel Tank Pressure Sensor and Purge Valve Canister Before replacing this part due to fault code P0441, please call David Thomas at cell (248) 613-6908. Engineering may want to visit dealers in the metro Detroit area with this condition. Read More »
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time ... Read More »
Transfer Case Input Seal Leak This bulletin involves replacing the transfer case input gear and seal. The customer may experience red fluid weeping from under their vehicle and showing up on the ground. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
T-case switch If you are working on a 2016 JK and you're replacing t-case position switch, please call Ashley Gerebics @ (248) 472-6524. If no response within 15 minutes, please proceed with the repair. Read More »
Customer Satisfaction Notification S80 Aftermarket Dana 60 Front Axle The aftermarket front axle steering knuckles have been machined with an incorrect taper during the manufacturing process on about 250 of the above vehicles, with ... Read More »
Customer Satisfaction Notification S80 Aftermarket Dana 60 Front Axle The aftermarket front axle steering knuckles have been machined with an incorrect taper during the manufacturing process on about 250 of the above vehicles, with ... Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
complete wiring harness Before replacing this harness, please check for an available connector repair kit at the following: http://connectors.dcctools.com/home. Read More »
Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes P0407 ? EGR Sensor B Circuit Low, or P0408 ? EGR Sensor B Circuit High Set Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Read More »
Hands Free Module - Convergence Telematics Module (CTM) Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear ... Read More »
Hands Free Module - CTM ? Peiker Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear codes or perform a battery ... Read More »
Hands Free Module - CTM ? Peiker Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear codes or perform a battery ... Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Read More »
Anti-Lock Brake Module (ABS) 2015 and 2016 JK ONLY; Before replacing the ABS module, please call Breanne Scherbaty at cell (586) 604-4582. If you don't receive response within 15 minutes, please continue with normal repair procedure. Read More »
Anti-Lock Brake Module (ABS) 2015 and 2016 JK ONLY; Before replacing the ABS module, please call Breanne Scherbaty at cell (586) 604-4582. If you don't receive response within 15 minutes, please continue with normal repair procedure. Read More »
Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature - Engineering is investigating a keyfob unable to program or no function or low keyfob coin battery condition. Read More »
"PENTASTAR OIL FILTER ADAPTER BEFORE REPLACING THIS PART, PLEASE CALL ANY ONE OF THE FOLLOWING PEOPLE. ENGINEERING IS SEEKING INFORMATION REGARDING THIS PART.~ DYE MUST BE USED TO DETERMINE WHERE THE LEAK IS COMING FROM BEFORE REPLACING. Read More »
3.6L Oil Pan Drain Plug and Pan: When an oil pan leak is detected and the oil drain plug is loose please on JK/KL models call one of the following people. If your call in not answered within 15 minutes please proceed with the repair. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob. Read More »
3.6L Oil Pan Drain Plug and Pan: When an oil pan leak is detected and the oil drain plug is loose please on JK/KL models call one of the following people. If your call in not answered within 15 minutes please proceed with the repair. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Navigation failed message is displayed. Read More »
Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Read More »
Hands Free Feature Inoperative This bulletin involves updating the Hands Free Module (HFM) software. The customer may notice that the hands free feature (Bluetooth) does not work. Read More »
Heated Seat Elements; Cushion and Back DEALERCONNECT HEATED ELEMENT RESISTANCE INFO OUT IS OF SPEC. Prior to ordering any of the parts (55057300A$, 55057293A$, 55057301A$, 55057294A$) Please contact Micah Straub at cell phone# ... Read More »
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp ... Read More »
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. Read More »
WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Read More »
Two Underhood Relays Not Capped and Unsecured This bulletin involves inspecting the wiring harness and if needed, attaching relays to secure the harness. Read More »
KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press ... Read More »
Hands Free Module - Convergence Telematics Module (CTM) Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear ... Read More »
"TPM SENSOR OR CONTROL MODULE 2015 AND 2016 JK VEHICLES ONLY - ENGINEERING IS INVESTIGATING A TIRE PRESSURE MONITOR (TPM) ISSUE FOR TPM LAMP ON. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass. Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Read More »
Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks This bulletin involves adjusting the windshield frame and A-pillar between the door to close gaps and prevent water leaks. Read More »
Windshield Sealer 2016 JK WRANGLER wind noise or water leak coming from a void in the windshield sealer.~ Before re-sealing or removing the windshield to re-apply sealer, please call Alex Wamer at Cell (419) 377 7303. Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the ... Read More »
Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982. If no response in 15 minutes, continue with repair. Read More »
Non-desiccated Passenger Frontal Airbag This bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached "Important Notice" document and retain a signed copy. Read More »
Non-desiccated Passenger Frontal Airbag This bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached "Important Notice" document and retain a signed copy. Read More »
"Non-desiccated Passenger Frontal Airbag This bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached ""Important Notice"" document and retain a signed copy. Read More »
KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press ... Read More »
KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press ... Read More »
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
DOOR, Assembly (Front or Rear) For concern of flag nut not aligned to hole, use a blunt tool and lightly tap on the flag nut to knock it loose from e-coat that has dried it in place. Read More »
Fuel Tank and Fuel Evap System Components 1) For JK MIL On ? P0441: Before replacing this part due to fault code P0441, check for restriction due to plastic over-flash in the Purge Hose Port of the Intake Manifold. Read More »
Fuel Tank and Fuel Evap System Components Before replacing this part due to fault code P0441, check for restriction due to plastic over-flash in the Purge Hose Port of the Intake Manifold. Read More »
Header Weatherstrip, Center Targa Top Seal, Right Door Mounted Weatherstrip Water leak from the Freedom Panels at the rearview mirror/drops down on the instrument panel/radio area OR Water leak at the right front A pillar/on the ... Read More »
Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks This bulletin involves adjusting the windshield frame and A-pillar between the door to close gaps and prevent water leaks. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair. Read More »
Header Weatherstrip, Center Targa Top Seal, Right Door Mounted Weatherstrip Water leak from the Freedom Panels at the rearview mirror/drops down on the instrument panel/radio area OR Water leak at the right front A pillar/on the ... Read More »
Discolored Door Hinge Nuts This bulletin involves replacing all the lower nuts on the side upper and lower door hinges. The customer may describe discoloring or rust from the lower nut securing the doors to the hinges. Read More »
Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Read More »
Discolored Door Hinge Nuts This bulletin involves replacing all the lower nuts on the side upper and lower door hinges. The customer may describe discoloring or rust from the lower nut securing the doors to the hinges. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code. Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Read More »
Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. Read More »
Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. Read More »
Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code. Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Read More »
Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Read More »
TPM Sensor or Control Module 2015 and 2016 JK vehicles only - Engineering is investigating a Tire Pressure Monitor (TPM) issue for TPM lamp ON. Read More »
"TPM SENSOR OR CONTROL MODULE 2015 AND 2016 JK VEHICLES ONLY - ENGINEERING IS INVESTIGATING A TIRE PRESSURE MONITOR (TPM) ISSUE FOR TPM LAMP ON. Read More »
TPM Sensor or Control Module 2015 and 2016 JK vehicles only - Engineering is investigating a Tire Pressure Monitor (TPM) issue for TPM lamp ON. Read More »
TPM Sensor or Control Module 2015 and 2016 JK vehicles only - Engineering is investigating a Tire Pressure Monitor (TPM) issue for TPM lamp ON. Read More »
Transfer Case Input Seal Leak This bulletin involves replacing the transfer case input gear and seal. The customer may experience red fluid weeping from under their vehicle and showing up on the ground. Read More »
Dimpled Driver Side Front Leather Heated Seat This bulletin involves inspecting and installing heater element patches and replacing seat cushion cover, on the driver?s front seat. Read More »
Squeaking Noise Below The Front Seat While Turning and Going Over Bumps This bulletin involves replacing the bolt and bushing on driver and passenger side seat slide mechanism to resolve a squeaking issue (Two door models only). Read More »
Squeaking Noise Below The Front Seat While Turning and Going Over Bumps This bulletin involves replacing the bolt and bushing on driver and passenger side seat slide mechanism to resolve a squeaking issue (Two door models only). Read More »
Heated Seat Elements; Cushion and Back DEALERCONNECT HEATED ELEMENT RESISTANCE INFO OUT IS OF SPEC. Prior to ordering any of the parts (55057300A$, 55057293A$, 55057301A$, 55057294A$) Please contact Micah Straub at cell phone# ... Read More »
Passenger Seat Is Difficult To Move This bulletin involves greasing the inboard passenger seat track. The customer may describe it is difficult to move the passenger seat forward or backwards. Read More »
Dimpled Driver Side Front Leather Heated Seat This bulletin involves inspecting and installing heater element patches and replacing seat cushion cover, on the driver?s front seat. Read More »
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Read More »
Transfer Case Input Seal Leak This bulletin involves replacing the transfer case input gear and seal. The customer may experience red fluid weeping from under their vehicle and showing up on the ground. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob. Read More »
Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob. Read More »
complete wiring harness Before replacing this harness, please check for an available connector repair kit at the following: http://connectors.dcctools.com/home. Read More »
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Read More »
KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press ... Read More »
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
DIPAP Requirements - Addition of Jeep Wrangler (JL/JK) and Jeep Gladiator (JT) Hard Top and Targa Top Panel Replacements - All Dealers (Rev. A) Read More »
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
The SKU is a Tie Rod Center Stud. The Customer commnunication requested return of unsold inventory to inpsect for possible incorrect direction threads (right hand rather than left hand). Read More »
Console Lid If you are replacing the console lid because it does not open properly or because the button covers are missing, check STAR Parts - there is a button cover replacement kit available. Read More »
"Console Lid JK ONLY - If you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. Read More »
Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks This bulletin involves adjusting the windshield frame and A-pillar between the door to close gaps and prevent water leaks. Read More »
RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Read More »
Console Lid JK ONLY - If you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. Read More »
Console Lid JK ONLY - If you are replacing the console lid because it does not open properly or because it does not close properly, please also replace the console base and the lock cylinder (04746315) in addition to the console lid. Read More »
Replace Fuel Tank This bulletin involves replacing the fuel tank. Some vehicles may have been built with a fuel tank that is out of specifications. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Navigation failed message is displayed. Read More »
PANEL, Targa Top, Complete with Hardware For water sloshing noise in the Targa Top Panel, do not replace the panel. There is a drain hole along the rear edge of the panel (in car position). Read More »
RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Read More »
MY16 RA3 & RA4 Replacement Radios All MY16 RA3 and RA4 replacement radios must be ordered through the exchange process at United Radio. DO NOT order a NEW radio from Mopar. Go back and order a "Z" level part number. Read More »
RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Navigation failed message is displayed. Read More »
RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Read More »
RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: ? Navigation failed message is displayed. Read More »
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used Read More »
"CONSOLE LID JK ONLY - IF YOU ARE REPLACING THE CONSOLE LID BECAUSE IT DOES NOT OPEN PROPERLY OR BECAUSE IT DOES NOT CLOSE PROPERLY, PLEASE ALSO REPLACE THE CONSOLE BASE AND THE LOCK CYLINDER (04746315) IN ADDITION TO THE CONSOLE LID. Read More »
"PENTASTAR OIL FILTER ADAPTER BEFORE REPLACING THIS PART, PLEASE CALL ANY ONE OF THE FOLLOWING PEOPLE. ENGINEERING IS SEEKING INFORMATION REGARDING THIS PART.~ DYE MUST BE USED TO DETERMINE WHERE THE LEAK IS COMING FROM BEFORE REPLACING. Read More »
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington ... Read More »
Water Pump For JK Bodies ONLY: If replacing the water pump for a chirp, squeal or NVH, please contact either: Nick Morand cell: (248) 410-5078 nick.morand@fcagroup.com Joe Lovell cell: (734) 309-6467 joe.lovell@fcagroup. Read More »
Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982. If no response in 15 minutes, continue with repair. Read More »
Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the following people regarding this repair: Mahmoud (Mo) Touha at cell (248) 705-3934. Read More »
Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the following people regarding this repair: Mahmoud (Mo) Touha at cell (248) 705-3934. Read More »
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when ... Read More »
T-case switch If you are working on a 2016 JK and you're replacing t-case position switch, please call Ashley Gerebics @ (248) 472-6524. If no response within 15 minutes, please proceed with the repair. Read More »
