This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
The owner had just left the driveway and was driving up the neighborhood block at low speed in the vehicle when another driver motioned that there was a problem with the car, pointing at the driver's side wheel well. The owner immediately pulled to the curb, exited the vehicle, and saw smoke pouring from the vehicle. Grabbed purse and moved a safe distance away. Spontaneously the car caught fire under the engine before the fire truck arrived 8 minutes later. Huge flames shooting from under the hood were captured on both video and photos. The car is a total loss. Had been well maintained.
Dealership suspects "Rod Bearing Failure" due to knocking, loss of power and metal flakes in oil. Just 400 miles before oil was changed at dealership with no mention of issue. Technician claimed it just didn't happen, its been going on for some time. There is no mention in any service history of 4 years between the 2 dealers that it was happening. Total engine failure will happen (engine will seize). It matches the recall done in November 2017, #168 by Hyundai on a "certain" Santa Fe with the 3.3L engines. If the engine seized while driving, it could have caused an accident. Hyundai Corporate said I was the 2nd owner, warranty ended at 60,000 miles... I am owed nothing. No warning light or knocking happened until the afternoon of 8/9/21. Then the dealership took possession at 1st available date 2 days later and inspected it.
While driving the vehicle on a major city street at approximately 40 mph the stopped running not allowing me to move out of the roadway and almost rear ended by another vehicle. The vehicle was moved out of the road way and towed to my residence. It was found that the check engine light showed code P0014 and P0024 crank shaft issues which caused the vehicle engine to lose power. Vehicle was taken to dealer ship and manufacture was contacted. Note that there had been a prior recall for engine and crank shaft issues. Manufacture advised that the vehicle was out of warranty and that the VIN number was not part of the recall. Manufacture was not willing to take any other action to resolve the problem with the engine issues.
Had oil changed on June30 2021 and on July 3 2021 the engine seized without oil in it. Had it towed to St. Augustine Hyundai and put a claim for replacement engine and Hyundai denied fixing it 3 months later with no explanation. Anyone I talked to in Hyundai Corporate they couldn't tell me why it was denied. This is the only vehicle we have and now we have no vehicle to drive.
This is a Santa Fe Ultimate AWD with the 3.3 l engine. We were driving home and in our neighborhood when the car suddenly stopped with no warning. We had it towed to a local shop and were told the engine had completely seized and needs to be replaced. It was not low on oil and has been regularly maintained. Only 60,000 miles.
- Woodinville , WA, USA
Search CarComplaints.com for these popular complaint phrases...
Even though my check engine light wasn-??t on my vehicle began to stall while I was merging on a major highway. A mile later the car began to smoke from behind made a weird noise and it completely stopped. Me and my 7 yr old stayed stranded on the shoulder of a highway while semis whizzed by at 80 mph. Called roadside assistance but no longer covered so couldn-??t be helped while me and my families life was in danger. Case manager at the national office rude unsympathetic and hung up on me. My car is still with the dealer even though it is under warranty and has been with the dealer since September 8,2021 every time I call they give me the run around as I pay $1200 for a rental because they refuse to provide me with one.
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving 50 MPH, the vehicle loss power. The vehicle was towed to an independent mechanic where it was diagnosed that the engine had seized. The vehicle was towed to the dealer where they confirmed the diagnosis. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.
The contact owns a 2017 Hyundai Santa Fe. The contact stated that while operating the vehicle, a knocking noise was present coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the engine bearings had failed, and metal particles were discovered in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was included in NHTSA Campaign Number: 17V578000 (Engine and Engine Cooling). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 74,400.
The engine warning light came on and Oil leak from engine, I have taken the vehicle to the dealership and they thought it was an oil cap plug not put in correctly, they put it back in back in July 2021. But oil leak still happen and the engine warning light keeps turn on. Every day i have to check oil level to make sure it not go below the minimum and I keep on adding oil. I have go to the dealership and they unable to help me. I made repair issues know to them, and schedule several appointments and they keep cancel it, they say at this time they do not take any serious engine issues. The last appointment was made on August for September 4, and the Huyndai auto repair center cancel the day before, say that i have to find other repair shop to work on my engine problem. My car buy in October 2016, and currently sit at under 41,000 miles. The Engine warning light came up back in June 2021.
The engine in our 2017 Hyundai Santa Fe SE 3.3L V6 has always had problems with lag/ hesitation when accelerating from a stop from the very beginning of ownership (first owner). This was always dismissed by Hyundai's mechanics as not actually existing, although it did lag constantly. I know many other have reported similar issues so, I include this only that it could potentially be an early sign of a manufacturers defect leading to larger problems later? Now, we regularly change the oil in our Santa Fe and have never seen a single warning light outside of tire pressure warnings. But on 7/29/21, with our vehicle just out of warranty at 112k miles, while accelerating to freeway speed from an on ramp at 60 mph multiple warning lights came and at the same time there was a very large bang from the engine and a large amount of smoke came from under the hood, enough to seriously affect the vision of drivers behind me. There was a very rapid lose of speed and I also observed things falling from the vehicle in the rearview. I luckily managed the vehicle to the shoulder and quickly got out. I thought vehicle was on fire, it may have been, the smoke kept up for 5-10 minutes. At this point the car would not start or run and a large pool of oil and or coolant formed underneath. It was towed to a Hyundai dealer and the prognosis was a broken connecting rod that had blew a large maybe 5" diameter hole through the bottom of the engine. And now, despite providing proof of recent oil changes, Hyundai has dismissed any manufacturing issues from causing the issue and sighting the problem was from lack of maintenance because of sludge in the engine. Although to my understanding sludge can also be produced rapidly when contaminants, like coolant, from bad valves or head gaskets, enter the oil. When I asked about this the technician literally just didn't answer. So, now we currently owe $7k on a vehicle needing repairs at the quoted price of $8-$14k and Hyundai has closed our case.
The engine lite came on, there was a lost of acceleration, the vehicle stalled when slowing down for a stop light or stop sign, There was a ping noise evident with the engine. I didnt trust the vehicle had it towed to the mechanic. The mechanic noted you have only two quarts of oil in the engine. This mechanic performed all routine maintenance, rotations, oil changes, checking fluids etc. There were no signs of oil leaks and or burning of oil with the exhaust. I then sent the car to the dealership for their own review. They confirmed the engine failure and the ping noise was the rod due to lack of oil. The dealership files a claim with Hyundai #PA102790, the claim was denied and still has not provided a reason for the oil loss which was the reason for the failure of the engine. There were no indicator lights noting low oil pressure or the engine is overheating, the engine lite came on in the morning and just like in A MANNER OF COUPLE OF HRS the engine started the symptoms noted above. The dealer ship gave Hyundai's complaint line, but after reading the problems associated with the Engines with the sante fe what is the point to call them?
Engine made a loud pinging noise. No warning lights appeared. I had it towed to dealer and they said that metal shavings were in the oil and the engine is shot and needs to be replaced. Car had 95,400 miles. Hyundai denied warranty because I was second owner after ignoring me for approximately one month and they never did reply to me directly, only to the dealer. How can so many Hyundai engines not last for over 100,000 miles?
Took 2017 Sante Fe to dealer for a oil change and to look into an intermittent hard shift from a stop. During test drive dealer stated car engine warning light came on and vehicle stalled, mechanic was able to steer vehicle to side of road, vehicle would not restart, after several hours they informed me that engine had seized and would need to be replaced.
The contact owns a 2017 Hyundai Santa Fe. The contact stated while his wife was driving and approaching a red traffic light, the light turned green and the driver depressed the accelerator pedal and the vehicle started shaking abnormally and loss motive power, and stalled without warning. The driver attempted to restart the vehicle, but the vehicle would not restart. The contact arrived at the scene and attempted to jump-start the vehicle however, the vehicle failed to start up. The contact had the vehicle towed to a local dealer who inspected the vehicle and diagnosed the failure as bearing failure which caused the shaking and stalling of the vehicle. The vehicle was not repaired due to the cost of the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 79,000.
The engine is consuming oil. After 1500 miles since my last oil change the oil DOES NOT show up on the oil stick. I have bought 3 brand new Hyundai Santa Fe's and 1 used Sonata, and NEVER had problems, except for my 2017 Santa Fe Sport, which I purchased at Dondelinger Hyundai in Baxter, Minnesota. I have also had to replace the backup camera. I have been to this dealer 4 times with no resolve! Please help!!
Smelled smoke at a stop light. Continued when light turned green. Pulled over about 30 car lengths later because smoke was coming in the vents. Jumped out of car and ran. Within 2 minutes, entire front engine was completely engulfed in flames. No indicator light came on before. Car was driving perfect.
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving at various speeds, the check engine warning light illuminated and the vehicle shifted into limp mode, causing the speed to be reduced to 20 mph. The vehicle was taken to the local dealer who was unable to duplicate the failure. The mechanic was unable to retrieve a fault code. Additionally, while driving at speeds above 60 mph, the 2nd-row captain seats shook and vibrated abnormally. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.
Vehicle began burning through 3-4 quartz of oil every 1,000 miles after vehicle got close to 75K miles. When the issue first began, the cause was unknown. After running multiple oil consumption tests, it is now believed to be an engine deficiency.
Car started to whine when started, then I was at about 30 mph it made a high ping noise like something fell out and the car shut off, never started again, mechanic said engine blown
A D V E R T I S E M E N T S
- Falls Church, VA, USA