Technical Service Bulletins (TSBs) for the 2007 Santa Fe are official communications between Hyundai & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
HYUNDAI: POWER STEERING GEAR BOX YOKE KIT INSTALLATION PROCEDURE. IF VEHICLE EXHIBITS A SLIGHT RATTLE NOISE ORIGINATING FROM THE STEERING GEAR BOX WHEN TURNING RIGHT ON UNEVEN ROAD SURFACES, REPLACE THE SUPPORT YOKE AND YOKE SPRING WITH ... Read More »
HYUNDAI: POWER STEERING GEAR BOX YOKE KIT INSTALLATION PROCEDURE. IF VEHICLE EXHIBITS A SLIGHT RATTLE NOISE ORIGINATING FROM THE STEERING GEAR BOX WHEN TURNING RIGHT ON UNEVEN ROAD SURFACES, REPLACE THE SUPPORT YOKE AND YOKE SPRING WITH ... Read More »
HYUNDAI: DTC P2135/P0638 OR COLD ENGINE RPM FLUCTUATION; TPS REPLACEMENT AND ECM UPDATE. SOME 2.7L, 3.3L OR 3.8L ENGINES IN MODELS IDENTIFIED IN THE APPLICABILITY LIST MAY EXPERIENCE ONE OR MORE OF THE CONDITIONS LISTED. Read More »
HYUNDAI: SOME VEHICLES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC (ELECTRONIC THROTTLE CONTROL) SYSTEM RELATED DTC P2135 ( FORCED LIMITED POWER) OR DTC P0638 (POWER MANAGEMENT). Read More »
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). Read More »
HYUNDAI: WIRE ATTACHMENT-ENGINE ROOM JUNCTION BOX. VEHICLES EQUIPPED WITH THE FULLY AUTOMATIC TEMPERATURE CONTROL (FATC) A OR THE MANUAL HVAC SYSTEM WITH THE OPTIONAL TRIP COMPUTER MAY DISPLAY AN INCORRECT OUTSIDE TEMPERATURE READING. Read More »
HYUNDAI: (SERVICE CAMPAIGN T83). SOME VEHICLES EQUIPPED WITH A TEMPERATURE CONTROL DISPLAY MAY SHOW AN INCORRECT OUTSIDE TEMPERATURE READING. Read More »
HYUNDAI: MIL ON DTC P2135 OR P0638 OR COLD ENGINE RPM FLUCTUATION- TPS REPLACEMENT & ECM UPDATE. SOME VEHICLES MAY EXPERIENCE EITHER SLIGHT ENGINE RPM FLUCTUATION AT COLD WARM UP OR MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC ... Read More »
HYUNDAI: SOME VEHICLES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC (ELECTRONIC THROTTLE CONTROL) SYSTEM RELATED DTC P2135 OR DTC P0638. *PE Read More »
HYUNDAI: MIL ON DTC P2135 OR P0638 OR COLD ENGINE RPM FLUCTUATION- TPS REPLACEMENT & ECM UPDATE. SOME VEHICLES MAY EXPERIENCE EITHER SLIGHT ENGINE RPM FLUCTUATION AT COLD WARM UP OR MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC ... Read More »
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). Read More »
"THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. Read More »
"THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. Read More »
HYUNDAI: REAR HUB BEARING REPLACEMENT 4WD. THE PROCEDURE TO REPLACE THE REAR HUB BEARINGS ON CERTAIN SANTA FE VEHICLES. THE PROCEDURE INCLUDES INSTALLATION INSTRUCTIONS FOR DUST COVERS INCLUDED IN THE REPLACEMENT HUB BEARING KIT. Read More »
HYUNDAI: ON CERTAIN VEHICLES, FRONT VALVE COVER GASKET AND ALTERNATOR NEEDS INSPECTION AND IF NECESSARY, WILL BE REPLACED DUE TO ENGINE OIL LEAKAGE FROM FRONT CYLINDER BANK VALVE COVER GASKET NEAR WHERE CYLINDER HEAD AND TIMING COVER ... Read More »
HYUNDAI: INFORMATION PROCEDURE REGARDING REPLACEMENT OF ALTERNATOR DUE TO OIL CONTAMINATION, LH (FRONT) CYLINDER HEAD COVER GASKET, RESULTING IN NO ALTERNATOR OUTPUT, NO START, NO CRANK OR LOSS OF POWER. MODEL 2007-09 SANTA FE. Read More »
HYUNDAI: WIRE ATTACHMENT-ENGINE ROOM JUNCTION BOX. VEHICLES EQUIPPED WITH THE FULLY AUTOMATIC TEMPERATURE CONTROL (FATC) A OR THE MANUAL HVAC SYSTEM WITH THE OPTIONAL TRIP COMPUTER MAY DISPLAY AN INCORRECT OUTSIDE TEMPERATURE READING. Read More »
HYUNDAI: (SERVICE CAMPAIGN T83). SOME VEHICLES EQUIPPED WITH A TEMPERATURE CONTROL DISPLAY MAY SHOW AN INCORRECT OUTSIDE TEMPERATURE READING. Read More »
HYUNDAI: (SERVICE CAMPAIGN T85). CONDUCTING A SERVICE CAMPAIGN TO UPDATE THE ECU SOFTWARE ON CERTAIN VEHICLES. REFLASH THE ECU WITH THE APPROPRIATE FILE LISTED IN THE CHARTS IN THIS TSB. Read More »
HYUNDAI SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. STOP LAMP SWITCH REPLACEMENT (CAMPAIGN 092). THIS BULLETIN DESCRIBES THE PROCEDURE TO REMOVE, REPLACE, AND ADJUST THE STOP LAMP SWITCH. Read More »
HYUNDAI SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. STOP LAMP SWITCH REPLACEMENT (CAMPAIGN 092). THIS BULLETIN DESCRIBES THE PROCEDURE TO REMOVE, REPLACE, AND ADJUST THE STOP LAMP SWITCH. Read More »
HYUNDAI: REAR HUB BEARING REPLACEMENT 4WD. DESCRIBES THE PROCEDURE TO REPLACE THE REAR HUB BEARINGS ON CERTAIN VEHICLES. THE PROCEDURE INCLUDES INSTALLATION INSTRUCTIONS FOR DUST COVERS INCLUDED IN THE REPLACEMENT HUB BEARING KIT. Read More »
HYUNDAI: SOME VEHICLES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC (ELECTRONIC THROTTLE CONTROL) SYSTEM RELATED DTC P2135 ( FORCED LIMITED POWER) OR DTC P0638 (POWER MANAGEMENT). Read More »
