This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Level 2 charging fails on warm days if charging above 9kw. I am unable to charge my car on days above 80-90 degrees using my 9.6kw (40 amp) Level 2 charger, as the cars internal will get so hot to the point where it overheats, and force stops charging. Occasionally, I will come back to my car while charging and find it's charging at a much lower speed then it should be. Hyundai claims to have a TSB to fix this issue, but it only neuters the cars charging ability, it doesn't actually fix the ability of the car to charge at 40 or 48 amps on a warm way.
I turned on the car and immediately got a "check electric vehicle system" error, and then shortly after a "stop vehicle and check power supply" error. I located a nearby dealership to diagnose and repair the vehicle, and called a tow truck to take it there. My car is parked in a garage in an alley. After the tow truck arrives in the alley, I turn on the car and get the same errors, and pull into the alley. As I'm pulling into the alley, the car start behaving very eratically, not responding well to the accelerator or steering wheel, and then within a couple minutes the display goes blank, completely black, with some white glitchy pixels periodically. Thankfully, I had already put the car into neutral at this point so the car could be pulled onto the flatbed tow truck. Once the displays stopped working, the car was completely unresponsive. I was unable to lock or unlock doors by using physical buttons on doors or remote buttons on my key. The power trunk lift gate would not open. In the world of cell-phones, they would say my car was "bricked." Completely unresponsive to any input, and the display still black with occasional white glitching flashing across display. The dealership's diagnostics was that there was a malfunction in the Integrated Charging Control Unit (ICCU). They replaced the ICCU and the 12 volt battery and I received the car back from the dealership. Everything seems fully operational again.
I was driving and could go no faster than 30 mph. I was very close to a dealership (a few blocks) and was able to make it there before the entire car turned off. An electrical error displayed on the dashboard before it shut down.
The Hyundai Ioniq 5 advertises quick charging via level 2 (240v) supporting nearly 10 amps. Hyundai has acknowledged by issuing a TSB this year that the charging port overheats at high amperage and causes charging to cease before the battery reaches the intended state of charge. The TSB addresses the issue by slowing the rate of charge substantially when the port overheats. As a result, owners are unable to "refuel (charge)" the vehicle at the advertised rates. In addition to the overheating charge port posing a potential hazard, the result is that an uninformed owner may not have necessary charge to reach their destination.
Ioniq 5 continuously fails to complete charging when on level-2 EVSE. Charging port and plug feel extremely warm to the touch, even in cool ambient weather. Multiple UL-listed charge cables yield similar results, while working perfectly well with other EVs.
- Alexandria, VA, USA
Search CarComplaints.com for these popular complaint phrases...
My partner was driving my car on Tuesday, May 23, 2023 and received a "Check Electrical Vehicle System" warning. Within 30 minutes of receiving that warning, the maximum speed on the car was throttled to 20 mph and shortly after that, the car stopped working entirely. Thankfully, my partner was on a residential street when all this occurred and was able to move to safety; however, had any of this happened in a highway driving scenario, the results could have been catastrophic. My car was towed to a dealership that same evening and it has been with the service department since then. The two parts on backorder they are waiting on on the ICCU Assembly and a High Voltage Fuse. Upon searching for other Hyundai IONIQ 5 owners with similar issues, various internet forums are filled with reports of similar things happening. At this point, I have been told this part is on backorder for potentially up to 6-9 months and after repeated calls with the dealership and the corporate office, Hyundai has not acknowledged the extent of this issue, the potential safety concerns, nor offered any relief for being without my, basically brand new, car for the remainder of this year.
This is an electric vehicle that features -??iPedal-?? driving, what Hyundai refers to as one-pedal driving. The main safety issue is that when you decelerate using one pedal, which is a fairly aggressive deceleration, the brake lights do not come on unless you lift your foot entirely from the accelerator or apply the brake pedal (which one would rarely do in iPedal mode). Hyundai needs to rethink their concept of operations for how their brake lights should operate. People are at risk of getting rear-ended. I didn-??t realize this was how the vehicle operated until I was almost rear-ended today. Please push them to fix this issue.
I received a warning on my dashboard while driving "Check electric vehicle system". A few minutes later I received the message "Stop vehicle and check power supply". My car would not go faster than 20 MPH, and I had it towed to the dealership. They said it was an ICCU issue and the part was on nationwide backorder. My car has been at the dealership for 41 days.
On 24 May 2023, I heard a "pop" sound when starting my Ioniq5 and immediately received warnings directing me to stop the vehicle and check the battery system. The car was taken to the dealer on the same day and is still out of service. The dealer notified me that the problem is due to an "ICCU" issue and that parts are backordered and they do not have an estimated date for the receipt of parts or repair.
Started vehicle and heard a loud pop with immediate amber warning to check electrical system with 12 volt battery and EV electrical system warning lights illuminated. While driving to dealerships, vehicle slowed abruptly at Highway speed and warning message said to stop vehicle immediately. Towed to dealership with probable bad integrated charging control unit and high voltage fuse blown. Seems to be an issue with many ioniq 5s. Recall this vehicle!
The 12-volt battery that controls everything in the car stopped being recharged by the 800volt battery, eventually causing the car to suddenly lose power and slow to 22 mph on the freeway. I was able to pull over 3 lanes and exit what was fortunately an uncrowded freeway. The car would not exceed 22 mph and soon stopped altogether and could not be moved. The main 800volt battery was at 56% charge, as the 12-volt battery went to 0%. The car was towed to the dealer. After inspection the dealer has confirmed that the ICCU system has failed and must be replaced, with a long back order and still no delivery date after 5 weeks. There were warning messages that appeared before the vehicle lost power, saying to check the battery electrical system. There should have been a warning that said -??stop driving immediately as the electrical system is failing, and the car may stop even though the main battery is still well charged.-??
While driving vehicle, car had sudden and rapid loss of power that resulted in significant decrease in speed. Vehicle was nearly in a rear-end Collision due to sudden drop in speed. The car is currently being inspected by the Hyundai dealership with reported failure of the ICCU.
Likely ICCU failure incapacitated vehicle while in motion on highway. Vehicle decelerated uncontrollably and would not re-accelerate. Shortly thereafter 12v battery warning appeared and vehicle was no longer operable. Series of warning lights. -??check electric vehicle system-?? upon car starting, -??Stop vehicle and check power supply-?? shortly after starting drive, "12v battery very low" immediately before vehicle went completely dead.
A few minutes into my drive I heard a loud POP from under the rear seat and then an orange EV system warning message flashed on the display. The vehicle slowed down and I couldn-??t maintain speed above about 25mph. Shortly after the first orange alert, the red -??Stop vehicle and check power supply-?? message popped up on the screen along with an emergency warning sound. The vehicle was towed by Hyundai Roadside Assistance to the nearest certified dealer, which took 1 week to diagnose the car. They just confirmed it was an ICCU (Integrated Charging Control Unit) failure and would require a replacement ICCU and high voltage fuse, which are on backorder with no definitive delivery date.
On 4/24/23, without an prior warning vehicle suddenly became undrivable. Received message: "Stop vehicle and check power supply". Car could lim along < 25mph for short distances. This condition along with indifferent Hyundai roadside assist left me stranded out of state for 5 hours before telling me to find my own way to tow the car. Car is at dealership with a diagnosed ICCU/ICCU fuse issue. To date I am being told that the parts are on back order for 2-3 weeks. Based upon online posts by others with this issue, this is not a realistic expectation. To date, Hyundai has yet to offer substitute transporation, relief from monthly paments, and reimbursement of all expenses incurred as a result of the loss of this vehicle.
Suddenly whilst driving, I heard a soft "pop" and emergency alert sound and message were displayed. Car lost almost all power, but was able to move forward at 12mph to park in a safe place. Car became fully inoperable and required a flatbed tow to dealership. Was diagnosed as an ICCU problem (associated with both 12v battery failure and possible bluetooth related battery drain). Car has been in shop for 6 weeks, waiting on parts. No ETA from Hyundai. If this had occurred 3 minutes later I would have been driving at high speed on the interstate in morning commute traffic. Prior to the "pop" there was no warnings or errors or problems - car worked perfectly.
On March/17/2023 @24962 miles Integrated Charge Control Unit failure + 30 AMP Fuse. Hyundai Corporate said parts back order May---June/2023 time frame. 3 inch orange circle came up on my dash with red triangle saying PULL OVER IMMEDIATELY! I was two blocks from dealership and with no problems drive to the service advisor where it died in front of them. Service advisor guessed that the pop I heard just before the circle appeared was the fuse and I drove in on the 12volt battery. I am in the Buy Back process with Hyundai Corporate Case#21170992
After a few minutes of driving, the vehicle presented a warning "Check Electric Vehicle System" and then got really slow. We were able to limp back home, where it is now parked. Hyundai has not had availability to diagnose the issue.
I was driving to my parents house when suddenly a message popped up on my driver screen saying that the electrical system has a problem. Driving a little more to reach my parents house and it starts saying to stop and check power supply. We ended up making it to my parents house and decided that it was unsafe to drive anymore with the error message going off. I called a tow truck to tow it back to our dealership in Fremont. When the tow came, I thought we could drive it on the bed but turns out the vehicle wouldn't start. We jumped the 12V battery and found that we could put it in neutral and somewhat drive it until it drained the external battery used to jump the 12V battery. With the car stuck halfway on the bed, we managed to put it in neutral and pull the car up using the tow's harness. Took it to the dealer and after a few days they said a fuse blew and that something called the ICCU was bad and needed to be replaced.
We were driving vehicle on a neighborhood street with a speed limit of 45 miles per hour. When we got a "High voltage fault warning" from the car. I continued to drive about 10 second more and got a second warning. A different series of warnings appeared the last one being "please pull over and check your electrical system". We pulled into a neighborhood street, turned off the car. We decided to try to make it home which was less than 1/2 mile. Once I restarted the car, both messages cycled through the dashboard. Then the car lost the ability to accelerate past 25 miles per hour, no matter how much I stepped on the throttle.
A D V E R T I S E M E N T S
- Mullica Hill, NJ, USA