Technical Service Bulletins (TSBs) for the 2001 Windstar are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
For 1998-2003 Windstar vehicles Safety Recall 10S13 has been issued for vehicles that are operated in high corrosion areas for an extended period, where the rear axle could potentially fracture. Read More »
SOME VEHICLES THAT DISPLAY LESS THAN 5000 MILES ON THE ODOMETER MAY EXHIBIT A PULL / DRIFT WHILE DRIVING. ENGINEERING IS INVESTIGATING. *TT Read More »
FORD: SAFETY RECALL ON FRONT SUBFRAME LOWER CONTROL ARM (LCA) REAR ATTACHING FLANGE OR REAR BODY MOUNT THAT CAN SEPARATE FROM SUBFRAME IF VEHICLE IS OPERATED, FOR EXTENDED PERIOD, IN HIGH CORROSION AREAS. MODEL 1999-03 WINDSTAR. Read More »
FORD: A SAFETY RECALL HAS BEEN ISSUED ON MINIVANS WHERE LOWER CONTROL ARM (LCA) OF FRONT SUBFRAME ATTACHING REAR FLANGE OR REAR BODY MOUNT CAN SEPARATE DUE TO CORROSION. MODEL 1999-2003 WINDSTAR. Read More »
FORD: ON SOME MINIVANS, REAR AXLE WILL FRACTURE, IN HIGH CORROSION AREA, AFTER OPERATING FOR AN EXTENDED TIME PERIOD, AND VEHICLE HANDLING ABILITY WILL BE AFFECTED. MODEL 1998-2003 WINDSTAR. Read More »
FORD: SAFETY RECALL CONCERNING REAR AXLE FRACTURING IF VEHICLE IS OPERATED IN HIGH CORROSION AREAS FOR AND EXTENDED PERIOD. MODEL 1998-03 WINDSTAR. *PE Read More »
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS ... Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
SOME VEHICLES MAY SET A DIAGNOSTIC TROUBLE CODE P0442 (EVAPORATIVE EMISSION CONTROL SYSTEM LEAK DETECTED) WITH NO FUEL ODOR OR LEAKAGE PRESENT. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT Read More »
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT Read More »
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
BEEPING SOUND FROM THE INSTRUMENT PANEL WHEN DRIVING AT/OVER 75 MPH, TRACTION CONTROL OFF INDICATOR ILLUMINATE WHEN VEHICLE IS NOT EQUIPPED WITH TRACTION CONTROL, AND/OR DIAGNOSTIC TROUBLE CODE B2477 (MODULE CONFIGURATION FAILURE) STORED ... Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
TRAILER TOW ELECTRIC BRAKE SWITCH/MODULE CONNECTOR MAY BE DIFFICULT TO LOCATE IN THE VEHICLE AND FOR CERTAIN 1999-2001 VEHICLES, THE LOCATION IS NOT CLEARLY IDENTIFIED IN THE WIRING DIAGRAM MANUAL. Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
ON SOME VEHICLES, IT MAY BE POSSIBLE FOR THE RESTRAINT CONTROL MODULE (RCM) TO INADVERTENTLY ACTIVATE AN AIRBAG OR SAFETY BELT PRE-TENSIONER WHILE STARTING THE ENGINE. FORD MOTOR COMPANY WILL INSTALL A REVISED RCM. Read More »
For 1999-2003 Windstar vehicles Safety Recall 11S16 has been issued for vehicles that are operated in high corrosion areas for an extended period, where a front subframe lower control arm (LCA) rear attaching flange or rear body mount ... Read More »
FORD: SAFETY RECALL ON FRONT SUBFRAME LOWER CONTROL ARM (LCA) REAR ATTACHING FLANGE OR REAR BODY MOUNT THAT CAN SEPARATE FROM SUBFRAME IF VEHICLE IS OPERATED, FOR EXTENDED PERIOD, IN HIGH CORROSION AREAS. MODEL 1999-03 WINDSTAR. Read More »
SOME VEHICLES EQUIPPED WITH A FAMILY OR REAR SEAT ENTERTAINMENT SYSTEM MAY EXHIBIT A BROKEN RELEASE HANDLE ACTUATOR OR RELEASE PIVOT ARM IN THE CENTER CONSOLE. Read More »
SOME FLEET CUSTOMERS MAY WANT TO DISABLE THE CHILD LOCK FEATURE ON THE SLIDING DOORS AND PREVENT IT FROM BEING ACCIDENTLY RE-ACTIVATED. *TT Read More »
REPLACEMENT OF LOWER SEAT-TO-FLOOR LATCHES ON VEHICLES EQUIPPED WITH 2ND AND 3RD ROW SEATS. DEMONSTRATION / DELIVERY HOLD. COMPLIANCE RECALL 03C05. *TT Read More »
SOME VEHICLES MAY EXHIBIT INOPERATIVE/FLICKERING DOME LAMP, LAMP STAYING ON ALL THE TIME, COMING ON BY ITSELF, OR INOPERATIVE WITH ANY DOOR AJAR INPUTS TO THE DOME LAMP. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN INOPERATIVE / FLICKERING DOME LIGHT, LIGHT STAYING ON ALL THE TIME, COMING ON BY ITSELF, OR INOPERATIVE WITH ANY DOOR AJAR INPUTS TO THE DOME LIGHT. Read More »
SOME VEHICLES EQUIPPED WITH LOW TIRE PRESSURE WARNING SYSTEM, MAY ILLUMINATE THE LOW TIRE WARNING LAMP WHEN THE TIRE PRESSURES ARE ADJUSTED OR THE TIRES ARE ROTATED. *TT Read More »
SOME VEHICLES MAY EXHIBIT A LOW TIRE WARNING (LTW) LAMP ON. THIS MAY BE CAUSED BY THE INSTALLATION OF A TIRE THAT DOES NOT MATCH THE OTHER VEHICLE TIRE SIZE, DOT CODE AND / OR LOAD RANGE. Read More »
VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LAMP ILLUMINATION AND MULTIPLE DIAGNOSTIC TROUBLE CODES, MOSTLY TRANSMISSION RELATED, STORED IN MEMORY. THE TCIL LAMP WILL ALSO FLASH. *TT Read More »
