This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Ford extended warranty on 3.8 L engine for 1995 model due to engine failure caused by defective gasket sets. However, is not doing so for like failure on 1996 model 3.8 L engines. Engine seized on our vehicle with approximately 48000 miles despite maintenance and timing chain gasket set replacement an approximately $1200 repair.
The sub-frame broke where the strut arm connects in the front( in area of the strut arm bushings. At first thought that the noise was from at loose heat shield. Strut arm rattles everytime van iecounters rough pavement. The speedometer just went haywire. Needle bounces all over the place. Have found other people on the internet with the same speedometer problem. I feel that both of these failures are a saftey issue. Ford motor doesn't.
Had just pulled out onto the street then heard a snap. Checked, and noticed left rear wheel had kicked out sideways and was hitting the mud flap. Rear frame holding rear axle had broken in half. Rear axle needed to be strapped up before vehicle was towed to dealership.
Trailing arm attached to the body of rear axle fractured while driving at low speed. No evidence of any impact to the trailing arm or body of the rear axle. Dealer / manufacturer notified, and informed consumer that warranty expired, and vehicle was not covered under a recall.
A popping noise was coming from the front end. Four bolts and mounts attached to the frame had deteriorated and needed to be replaced. Ford manufacturer states the vehicle was out of warranty and cannot duplicate the problem.
Had the sub-frame insulator replaced twice. Had new ABS brakes put on vehicle. The rotors were cut twice. The subframe bushing thread loader was worn down. Tie rods replaced twice, and the struts were replaced twice also.
A D V E R T I S E M E N T S
- Swampscott, MA, USA