Technical Service Bulletins (TSBs) for the 1999 Taurus are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME VEHICLES MAY EXHIBIT FRONT SUSPENSION NOISE DUE TO FRONT STRUT, FRONT SWAY BAR LINKS OR SYMPTOMS SUCH AS PREMATURE REAR BRAKE PAD WEAR DUE TO SEIZED REAR BRAKE CALIPERS OR SLIDES. *TT Read More »
For 1999-2001 Taurus or Sable vehicles Safety Recall 04S17 has been issued for vehicles that are operated in high corrosion areas for an extended period, where the front coil springs could potentially fracture. Read More »
MERCURY/FORD: SAFETY RECALL REGARDING FRONT COIL SPRINGS CAN FRACTURE ON VEHICLES OPERATING FOR EXTENDED PERIODS IN HIGH CORROSION AREAS. MODEL 1999-01 TAURUS, SABLE. *PE Read More »
MERCURY/FORD: FRONT COIL SPRINGS CAN FRACTURE, AFTER OPERATING, FOR AN EXTENDED PERIOD OF TIME, IN HIGH CORROSION AREAS, MOVE MOVE PAST SPRING SEAT AND CONTACT RUPTURE FRONT TIRE, RESULTING RAPID AIR LOSS. MODEL 1999-2001 TAURUS, SABLE. Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT Read More »
SUBJECT PERTAINING TO THE SBDS RELATIVE CAM TIMING TEST WHICH HAS BEEN TEMPORARILY REMOVED FROM USE ON SOME VEHICLES DUE TO NOISE CONCERNS. *TT Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
ISSUE OF A PERCEIVED LACK OF ENGINE BRAKING AND MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH A FALSE DIAGNOSTIC TROUBLE CODE (DTC) P1138 STORED IN MEMORY MAY OCCUR ON SOME VEHICLES . *MJS Read More »
REVISED ENGINE OIL INDICATOR (DIPSTICK) GRAPHICS. THE FULL LEVEL IS BETWEEN THE MIN AN MAX. IF THE OIL READING IS BETWEEN THE MARKINGS THE LEVEL IS ACCEPTABLE, DO NOT ADD OIL. Read More »
SOME VEHICLES MAY EXHIBIT COOLING SYSTEM CONDITIONS SUCH CONTAMINATED / CORRODED COOLANT; LEAKING / DISCOLORED COOLANT OVERFLOW BOTTLES; VIBRATION FROM ENGINE; LEAKING HEATER CORE; COOLANT OVERFLOW; HIGH TEMPERATURE GAUGE READINGS, ETC. Read More »
SOME VEHICLES EQUPPED WITH 3.0L 2V VULCAN OR 4V DURATEC ENGINE MAY EXHIBIT AN EXHAUST RUST-THRU, WELD FATIGUE CONDITION BETWEEN THE TWO TOEBOARD CATALYSTS WHERE A TIE-IN BRACKET IS WELDED TO THE FORMED INLET PIPE OF THE REAR BANK TOEBOARD ... Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
SOME VEHICLES (3.0L 4 VALVE ONLY) MAY EXHIBIT A CATALYTIC CONVERTER BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEADY SPEED. *TT Read More »
CONCERNS WITH SLOW FUEL FILL AT OR ABOVE 3/4 OF A TANK / FUEL FILL NOZZLE CLICKS OFF, SLOW FUEL FILL BELOW 3/4 OF A TANK / CONTINUOUS FILL NOZZEL CLICKS OFF, FUEL GAUGE DOES NOT UPDATE AFTER FUEL FILL, AND THE LOW FUEL LIGHT ILLUMINATES ... Read More »
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT Read More »
CONCERNS WITH THE REVERSE CLUTCH LIP SEALS BECOMING RIPPED / TORN DURING REVERSE ENGAGEMENT RESULTING IN NO REVERSE OR INTERMITTENT NO REVERSE ENGAGEMENT DURING EXTREME COLD TEMPERATURES. *TT Read More »
EFFECTIVE OCTOBER 15, 1999, THE AX4S AND AX4N TRANSMISSION ASSEMBLY FOR THE CERTAIN VEHICLES ARE AVAILABLE AS A FORD QUALITY RENEWAL (FQR) ASSEMBLY. *TT Read More »
EMISSIONS RECALL FOR VEHICLES WITH A POWERTRAIN CONTROL MODULE (PCM) PREVIOUSLY PROGRAMMED WITH A CALIFORNIA SERVICE CALIBRATION - PCM RECALIBRATION. *TT Read More »
INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE POWERTRAIN CONTROL MODULE (PCM) INFORMATION CHARTS. *TT Read More »
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT Read More »
SOME VEHICLES WITH AX4S TRANSAXLE MAY EXHIBIT A DIAGNOSTIC TROUBLE CODE P0734, FLASHING TCIL, NO3-4 SHIFT OR AN OVERDRIVE BAND WEAR CONCERN. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT Read More »
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE MAY EXHIBIT ANY OR ALL OF THE FOLLOWING SYMPTOMS: DTC P0734, FLASHING TCIL, "NO 3-4 SHIFT" OR AN OVERDRIVE BAND WEAR CONCERN. *TT Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT Read More »
FOR VEHICLES THAT REQUIRE CONFIGURATION OF THE ELECTRONIC CRASH SENSOR MOUDLE TO SETTINGS OTHER THAN THE PRESET SETTINGS, THE CONFIGURATION INSTRUCTIONS WERE OMITTED FROM THE SHOP MANUAL. *TT Read More »
SERVICE TIP FOR VEHICLES BUILT 11/1/1997 - 2/15/1999 WITH SINGLE ILLUMINATED VANITY MIRROR SUN VISORS ONLY, MAY EXHIBIT A BROKEN SUNVISOR STOWAGE BRACKET. *TT Read More »
THIS BULLETIN MENTIONS THAT VEHICLES BUILT ON OR AFTER MARCH 26, 1999 WILL NO LONGER BE EQUIPPED WITH ROCK GUARD PAINT COATING ON THE ROCKER PANELS. *TT Read More »
SUBJECT REGARDING VEHICLES BUILT ON OR AFTER MARCH 26, 1999 WILL NO LONGER BE EQQUIPED WITH ROCK GUARD PAINT COATING ON THE ROCKER PANELS. *TT Read More »
SOME VEHICLES WITH 3.0L 4-VALVE ENGINES BUILT BETWEEN 12/17/97 AND 6/30/99 MAY EXHIBIT A HARD START / LONG CRANK OR A ROUGH IDLE AFTER A COLD START. *TT Read More »
SOME VEHICLES WERE CALIBRATED WITH INCREASED AIR FLOW AT CLOSED THROTTLE TO PREVENT TIP-IN BUMPS, A RESULT MAY BE REDUCED DECELERATION FEEL AND LESS ENGINE RPM REDUCTION AT CLOSED THROTTLE WITH THE VEHICLE MOVING. Read More »
SOME VEHICLES WITH 3.0L 4-VALVE ENGINES BUILT BETWEEN 12/17/97 AND 6/30/99 MAY EXHIBIT A HARD START / LONG CRANK OR A ROUGH IDLE AFTER A COLD START. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. AUDIO AND CLIMATE CONTROLS CONTINUE TO OPERATE DURING THE ICP'S LOSS OF ILLUMINATION CONDITION. Read More »
SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS NOT RESPONDING TO COMMAND FROM THE RADIO. Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
THE OWNERS GUIDE FOR CERTAIN VEHICLES INCORRECTLY STATES THAT THE ACCESSORY DELAY FEATURE WILL PROVIDE FOR RADIO AND POWER WINDOW OPERATION FOR UP TO 10 MINUTES AFTER THE IGNITION IS TURNED OFF OR UNTIL A FRONT DOOR IS OPENED. Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 3.0L 4V DURATEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P1518, INTAKE MANIFOLD RUNNER CONTROL. *TT Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
