Technical Service Bulletins (TSBs) for the 1998 Taurus are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME VEHICLES MAY EXHIBIT FRONT SUSPENSION NOISE DUE TO FRONT STRUT, FRONT SWAY BAR LINKS OR SYMPTOMS SUCH AS PREMATURE REAR BRAKE PAD WEAR DUE TO SEIZED REAR BRAKE CALIPERS OR SLIDES. *TT Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT Read More »
SUBJECT PERTAINING TO THE SBDS RELATIVE CAM TIMING TEST WHICH HAS BEEN TEMPORARILY REMOVED FROM USE ON SOME VEHICLES DUE TO NOISE CONCERNS. *TT Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY ... Read More »
SOME VEHICLES MAY EXHIBIT COOLING SYSTEM CONDITIONS SUCH CONTAMINATED / CORRODED COOLANT; LEAKING / DISCOLORED COOLANT OVERFLOW BOTTLES; VIBRATION FROM ENGINE; LEAKING HEATER CORE; COOLANT OVERFLOW; HIGH TEMPERATURE GAUGE READINGS, ETC. Read More »
COOLING SYSTEM CONCERNS SUCH AS: STUCK THERMOSTAT; VIBRATION OR THUMPING FROM ENGINE'; LEAKING RADIATOR OR HEATER CORE; COOLANT SMELL; ... ;LACK OF HEAT. *TT Read More »
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
SOME VEHICLES EQUPPED WITH 3.0L 2V VULCAN OR 4V DURATEC ENGINE MAY EXHIBIT AN EXHAUST RUST-THRU, WELD FATIGUE CONDITION BETWEEN THE TWO TOEBOARD CATALYSTS WHERE A TIE-IN BRACKET IS WELDED TO THE FORMED INLET PIPE OF THE REAR BANK TOEBOARD ... Read More »
SOME VEHICLES (3.0L 4 VALVE ONLY) MAY EXHIBIT A CATALYTIC CONVERTER BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEADY SPEED. *TT Read More »
SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF FUEL AND FOR AN EXTENDED PERIOD OF TIME. *TT Read More »
SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF FUEL AND FOR AN EXTENDED PERIOD OF TIME. *TT Read More »
CONCERNS OF A POSSIBLE CHAFING OF THE FUEL PUMP ASSEMBLY WIRES RESULTING IN AN OPEN FUSE AND/OR INOPERABLE FUEL PUMP ASSEMBLY OR A NO START CONDITION. *YC Read More »
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT Read More »
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. Read More »
SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT Read More »
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT Read More »
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT Read More »
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT Read More »
FOR VEHICLES THAT REQUIRE CONFIGURATION OF THE ELECTRONIC CRASH SENSOR MOUDLE TO SETTINGS OTHER THAN THE PRESET SETTINGS, THE CONFIGURATION INSTRUCTIONS WERE OMITTED FROM THE SHOP MANUAL. *TT Read More »
SERVICE TIP FOR VEHICLES BUILT 11/1/1997 - 2/15/1999 WITH SINGLE ILLUMINATED VANITY MIRROR SUN VISORS ONLY, MAY EXHIBIT A BROKEN SUNVISOR STOWAGE BRACKET. *TT Read More »
A CONDITION MAY EXIST WHERE REDUCED DECELERATION FEEL AND LESS ENGINE RPM REDUCTION AT CLOSED THROTTLE WITH THE VEHCLE MOVING; SPEED CONTROL NOT RESPONDING QUICKLY WHEN SWITCHED TO OFF OR DECEL MAY ALSO BE NOTED. Read More »
SOME VEHICLES WITH 3.0L 4-VALVE ENGINES BUILT BETWEEN 12/17/97 AND 6/30/99 MAY EXHIBIT A HARD START / LONG CRANK OR A ROUGH IDLE AFTER A COLD START. *TT Read More »
SOME VEHICLES WERE CALIBRATED WITH INCREASED AIR FLOW AT CLOSED THROTTLE TO PREVENT TIP-IN BUMPS, A RESULT MAY BE REDUCED DECELERATION FEEL AND LESS ENGINE RPM REDUCTION AT CLOSED THROTTLE WITH THE VEHICLE MOVING. Read More »
SOME VEHICLES WITH 3.0L 4-VALVE ENGINES BUILT BETWEEN 12/17/97 AND 6/30/99 MAY EXHIBIT A HARD START / LONG CRANK OR A ROUGH IDLE AFTER A COLD START. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. AUDIO AND CLIMATE CONTROLS CONTINUE TO OPERATE DURING THE ICP'S LOSS OF ILLUMINATION CONDITION. Read More »
SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS NOT RESPONDING TO COMMAND FROM THE RADIO. Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 3.0L 4V DURATEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P1518, INTAKE MANIFOLD RUNNER CONTROL. *TT Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
