Took my car to the dealership for an oil change and tire rotation. The technician told me they cannot get the tires off to rotate them because the tire lug nuts were swollen. He asked me if I wanted to replace them. I agreed after he said that if I were to get a flat tire it would be hard to get it off to fix it. Basically, this issue became a safety one. I never had an issue with swollen lug nuts with previous cars I had own. Thank you for gathering these type of issues.

- Fort Eustis , VA, USA

When taking my car in for regular servicing, I was told that the tires could not be rotated because of swollen lug nuts. My vehicle has 11,777 miles. Without proper tire rotation, I cannot effectively drive safely without risk to myself and others. So, I opted to have the lug nuts replaced in fear of future problems should I need to remove a tire. Not being a mechanic, I have no idea what constitutes the look or feel of swollen lug nuts. My car was serviced on March 12 and 13, 2024 at the cost of $381.86 (lug nuts: $257.35)

- Las Vegas, NV, USA

Car was taking him for a recall on brake lines. Dealer phoned me and suggested that they replace the Lugnuts because they are a two piece. They are swollen and it-??s a safety issue. I agreed to have them replace them at my cost because there is no warranty on these defective Lugnuts I see that this is an ongoing issue that Ford has known for quite a while. I think they should reimburse the people for the money they have spent on the dealer charges or just warranty them for the rest people that come in with the same issue. I also believe that my dealer is way over charging 10 Lugnuts will be about $100 for me to pay whereas I can buy a set of 20 of them online for under $20. I think this is outrageous.

- New Hartford, CT, USA

2015 Ford Fusion. Consumer writes in regard to faulty lug nuts. The consumer is requesting to be reimbursed for the faulty lug nuts.

- Newtonville, MA, USA

The contact owns a 2015 Ford Fusion. The contact stated that the lug nuts on all four wheels were corroded and swollen. The contact was concerned that in the event of a flat tire or blowout, the lug wrench would be unable to remove the swollen lug nuts. The vehicle was taken to the dealer where it was diagnosed that all the lug nuts needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

- Blandon, PA, USA

The contact owns a 2015 Ford Fusion. The contact stated that the driver-??s side front tire lost air and became flat, but the independent mechanic was unable to remove the wheel from the vehicle due to the lug nuts being swollen. The vehicle was later taken to the local dealer who replaced the lug nuts. The cause of the failure was not determined. The manufacturer was not yet contacted. The failure mileage was 48,000.

- Athens, GA, USA