Technical Service Bulletins (TSBs) for the 1999 F-350 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SOME VEHICLES MAY REQUIRE ADJUSTMENT TO THE FRONT END ALIGNMENT SETTINGS TO ADDRESS TIRE-WEAR OR VEHICLE DIRECTIONAL SENSITIVITY CONCERNS. *TT Read More »
A SLOW RELEASE OF THE HUBS, AT TIMES, WHICH MAY BE REGARDED A NOT NORMAL BY THE OPERATOR. SLOW RELEASE OF THE HUBLOCKS IS NOT CONSIDERED ABNORMAL FOR THIS SYSTEM. Read More »
CLEAR GEL-LIKE SUBSTANCE IN THE HYDRAULIC BRAKE MASTER CYLINDER RESERVOIR. THIS SUBSTANCE IS A SILICONE BASE LUBRICANT USED DURING ASSEMBLY OF THE MASTER CYLINDER. *TT Read More »
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT Read More »
SOME VEHICLES MAY EXHIBIT EARLY WEAR OF THE INNER BRAKE PAD ON THE REAR DISC BRAKES WHEN OPERATED IN MUD, SLUSH, DIRT, OR OTHER SEVERE CONDITIONS. *TT Read More »
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAT GASKET AREA. *TT Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINE MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES BUILT 7/1998 TO 6/1999 EQUIPPED WITH A 4.6 / 5.4L WINDSOR BUILT ENGINES MAY EXHIBIT AN OIL LEAK FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME SUPER DUTY TRUCKS EQUIPPED WITH THE 7.3L DIT ENGINE MAY EXHIBIT A LACK OF POWER AND / OR A WHISTLE NOISE COMING FROM THE ENGINE COMPARTMENT. *TT Read More »
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT Read More »
INFORMATION ON DIAGNOSING 7.3L DIT VEHICLES BUILT PRIOR TO 4/1/99 EXHIBITING A TURBOCHARGER NOISE, EXHAUST NOISE, OR OIL / SOOT PRESENCE ON REAR OF ENGINE OR TURBOCHARGER. *TT Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT Read More »
SOME HEAVY DUTY AND SUPER DUTY VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT Read More »
A TEMPORARY TECHNICLA ASSISTANCE HOTLINE HAS BEEN ESTABLISHED TO HELP WITH DIAGNOSTICS AND / OR MECHANICAL CONCERNS WITH THE NEW VENTURE TRANSFER CASE ON SOME VEHICLES. *YC Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT Read More »
SOME DUAL REAR WHEEL VEHICLES WITH 6.8 / 7.3L ENGINES BUILT BEFORE 6/10/98 MAY EXHIBIT A CHATTER NOISE FROM THE REAR AXLE DURING TURNS. *TT Read More »
SOME DUAL REAR WHEEL VEHICLES WITH 6.8 / 7.3L ENGINES BUILT BEFORE 6/10/98 MAY EXHIBIT A CHATTER NOISE FROM THE REAR AXLE DURING TURNS. *TT Read More »
SOME VEHICLES EQUIPPED WITH 10.50-INCH RING GEAR, FULL-FLOATING REAR AXLES MAY EXHIBIT A LEAK AT THE OUTBOARD END OF THE AXLE SHAFT(S). *TT Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
SOME VEHICLES EQUIPPED WITH EITHER THE TRAILER TOWING PACKAGE OR CHASSIS CAB MAY EXHIBIT VARIOUS TRAILER RELATED ELECTRICAL CONDITIONS. INSTRUCTIONS ON INSTALLING THE TRAILER TOWING RELAYS AND FUSES ARE PROVIDED IN THE TRAILER TOWING KIT. Read More »
SOME VEHICLES EQUIPPED WITH EITHER THE TRAILER TOWING PACKAGE OR CHASSIS CAB MAY EXHIBIT VARIOUS TRAILER RELATED ELECTRICAL CONDITIONS SUCH AS: BACKUP LIGHTS INOPERATIVE, TRAILER BATTERY FEED INOPERATIVE OR ELECTRIC BRAKE POWER ... Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT Read More »
INFORMATION REGARDING A NEW SERVICE PART THAT HAS BEEN RELEASED FOR THE LICENSE PLATE LIGHT CIRCIUT WHICH WILL REDUCE THE COST OF REPAIR. *MJS Read More »
THIS BULLETIN STATES THAT WHEN REMOVING THE A/C COMPRESSOR ON CERTAIN VEHICLES, THE REAR MOST ATTACHING BOLT INTERFERES WITH THE CHASSIS CROSS MEMBER. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 7.3L DIT HAVE A STRATEGY THAT INCLUDES A COLD WEATHER IDLE KICKER FEATURE WHICH, UNDER CERTAIN CONDITIONS WILL AUTOMATICALLY ELEVATE THE IDLE SPEED AFTER 130 SECONDS OF IDLING AT COLD TEMPERATURES. Read More »
SOME DUAL REAR WHEEL VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF THE CENTER WHEEL ORNAMENT FALLING OFF WHILE DRIVING. ALSO THEY HAVE CONCERNS OF HAVING DIFFICULTIES INSTALLING THE CENTER ORNAMENT ON VEHICLES WITH ALUMINUM WHEELS. Read More »
VEHICLE EQUIPED WITH EITHER MANUAL OR ELECTRONIC SHIFT 4X4 SYSTEM MAY EXHIBIT A VIBRATION OR A RATCHETING NOISE FROM THE FRONT OF THE VEHICLE. ANOTHER SYMPTOM MAY BE DESCRIBED AS FRONT HUBLOCKS NOT RELEASING. Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT Read More »
ON SOME SUPER DUTY VEHICLES, THE CUPHOLDER MAY NOT FULLY RETRACT INTO THE CUPHOLDER INSTRUMENT PANEL OPENING, NOT ALLOWING THE CUPHOLDER FINISH PANEL TO FIT FLUSH WITH THE INSTRUMENT PANEL. Read More »
