Takata recall. I was driving down the road and my truck shut off randomly my overdrive light started flashing after this and continued to flash and still shuts off so I replaced my fuel filter, cps sensor and it still shuts off. It's like I'm goin down the road and it stalls. It does it more than once when I'm driving I just shut it off and start it again.

- Marietta, OH, USA

01/2016: Vehicle was being driven home from work when there was a loss of engine power. Vehicle was able to roll to a stop in the parking lot of a church. Later it was determined this resulted from failure of #7 cylinder injector unit, believed to have failed due to delamination inside of fuel tank. About 02/23/2014, 207980 miles: Fuel tank had been removed and internal screens cleared due to the engine stalling while driving prior to injector failure. Internal pick-up tube screens were blocked with delamination material from the inside of the tank. Two new fuel pumps had been purchased and installed prior to cleaning the internal pick-up screens. I have receipts for work and parts relating to the fuel system problem.

- Lincolnton, NC, USA

While inspecting my vehicle for fuel strap recall 11S21, it was noted that the frame of my F150 was rusted through at the location where the new strap would be installed. My Ford dealer told me that they could not replace the recalled strap until the frame was repaired (at my expense). Ford does not repair the frame under the recall, only replaces the strap. I feel that Ford should do the frame repair as part of the recall, as the strap was less rusty than the frame. The straps, in my opinion, were of similar quality as the frame, only thinner metal. My truck has been very well maintained, but the undercarriage has been rusting excessively since new. I own much older Ford vehicles with no such issue; my opinion is that Ford sourced poor quality materials when building these model year trucks. I also have rust holes in the transmission dipstick tube and exhaust manifolds. No reason for this excessive corrosion, since I have been diligent about maintaining this truck. My 1982 Ford van has no such issues, and it has not been cared for as well as this truck. Thanks for your help.

- Rising Sun, MD, USA

Ford recall 11S21 gas tank strap recall performed at lucas Ford in burlinton NJ. They said the strap pulled through rotted frame and Ford said because the recall only says they have to replace rusted straps they will not repair. They told them to put new straps on leaving rear one not connected. If this is a safety recall this is a fail as my truck could still have the tank drop and burst into flames. This is the same as Toyota recall for poorly treated frames just Ford was allowed to only replace 20 dollars straps that probably aren't even the problem.

- Browns Mills, NJ, USA

Driving my 1999 Ford F350 diesel down the highway, approximately 50 mph, heard a thump and loud scraping noise. Could not pull over due to traffic, pulled over when traffic cleared, around another 100 feet. I got out and looked around and under truck, to discover fuel tank was dragging along the highway. Rear fuel tank strap had broken.

- Aitkin, MN, USA

The contact owns a 1999 Ford F-350. While the vehicle was undergoing routine maintenance, the mechanic noticed that the fuel straps were disconnected and covered with rust. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 122,000. Updated 10/28/2014 updated 04/21/2015

- North Olmsted, OH, USA

Fuel tank now leaks after the Ford dealer replaced the straps (11S21 recall). They said they will not cover the tank replacement even though the tank did not leak before they replaced the straps!

- Chesterfield , MI, USA

Failure of gas tank strap causing fuel tank to fall.

- Angola, NY, USA

While driving, there was a loud explosion, then engine was running rough and loud. Mechanic stated that due to a faulty design, the #7 spark plug had been shot from the engine, damagine the ignition coil and allowing fuel to spray from the injectors onto the now loose spark plug. Mechanic stated I was lucky this did not result in an engine fire. Engine is Ford 5.4L V8. Mechanic explained that the design of the engine means that the aluminum heads have approx. Half as many threads as a normal spark plug, meaning that this is a frequent occurrence and Ford is aware of the fire risk but has chosen not to address.

- Redmond, WA, USA