Technical Service Bulletins (TSBs) for the 1994 F-350 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
EXPERIENCING FRONT END SHIMMY OCCURRING AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. *TT Read More »
FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. Read More »
SUSPENSION - NOISE FROM FRONT SPRING REAR HANGER - REVISED REAR SPRING HANGER INSULATOR PAD - VEHICLES EQUIPPED WITH 6000, 7000 OR 9000 LB AXLES BUILT THROUGH 10/1/97. *TW Read More »
SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:HANGER,BRACKET
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. Read More »
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. Read More »
BRAKES - AIR COMPRESSOR/AIR PUMP SUPPORT BRACKET BROKEN - VEHICLES WITH 7.0L ENGINE - ENGINE - 7.0L - ACCESSORY DRIVE BELT ROLL - NOISE - RATTLE - AIR BRAKE COMPRESSOR/AIR PUMP SUPPORT BRACKET CRACKED- VEHICLES WITH 7.0L ENGINE. Read More »
VEHICLES MAY EXPERIENCE PARKING BRAKE PEDAL WHICH GOES TO THE FLOOR WITH MINIMAL EFFORT- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/94. Read More »
INFORMATION REGARDING PARKING BRAKE CONTROL ASSEMBLY CONCERNS- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994. *MJS Read More »
PROCEDURE FOR SERVICING PARKING BRAKE- SERVICE TIP- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994. *MJS Read More »
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED. *YC Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT Read More »
A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. Read More »
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT Read More »
LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. Read More »
ON SOME VEHICLES, THE OIL MAY LEAK ONTHE SIDE OF THE FD1460 ENGINE. THIS MAY HAPPEN BECAUSE THE OIL LEVEL INDICATOR (DIPSTICK) RISES OUT OF ITS NORMAL RETAINED POSITION WHEN THE ENGINE IS RUNNING. Read More »
SOME DIESEL POWERED VEHICLES ARE EXPERIENCING DRIVE BELT TRACKING CONCERNS DUE TO FRONT END ACCESSORY DRIVE PULLEYS (FEAD) MISALIGNMENT. *TW Read More »
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION. Read More »
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT Read More »
VEHICLES WITH 7.3L DIRECT INJECTION DIESEL ENGINES MAY EXPERIENCE ONE OR MORE OF THE FOLLOWING CONDITIONS: ROUGH IDLE, STALLING HESITATION/STUMBLE, LOSS/LACK OF POWER, POOR FUEL ECONOMY EXCESSIVE OIL CONSUMPTION. Read More »
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD Read More »
ON F/B SERIES W/ FD 1060 ENGINE THERE MAY BE A CONCERN REGARDING INSUFFI- CIENT IN-CAB HEAT. TO RESOLVE THIS, THE CURRENT THERMOSTAT CAN BE REPLACED WITH A NEW LOW LEAK THERMOSTAT. THE NEEDED PARTS ARE AVAILABLE FROM CUMMIS ENGINE. Read More »
THE ENGINE COOLANT TEMP GAUGE MAY READ ON THE COLD SIDE OF THE NORMAL RANGE, OR MAY STAY BELOW NORMAL EVEN THOUGH THE ENGINE IS AT ITS PROPER OPERATING TEMP ON SOME VEHICLES. Read More »
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD Read More »
HARD STARTING OR A NO START CONCERN MAY OCCUR ON SOME VEHICLES. THIS MAY BE DUE TO DIESEL FUEL DRAINING OUT OF THE FUEL INJECTION SYSTEM BACK INTO THE FUEL TANK. Read More »
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW Read More »
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW Read More »
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT Read More »
REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. Read More »
REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. Read More »
REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. Read More »
A DRIVELINE VIBRATION/MOAN MAY OCCUR WHEN THE AUTOMATIC TRANSMISSION SHIFTS INTO CONVERTER LOCKUP MODE WHILE ACCELERATING OR CLIMBING A GRADE. *TW Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT Read More »
4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES. Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW Read More »
STALL OR NO START - FUEL SHUTDOWN SOLENOID - WIRING CHAFING ON FUEL INJECTOR LINES-VEHICLES BUILT BEFORE 10/19/94 WITH FD1060 ENGINE AND BOSCH P7100 FUEL INJECTION PUMP. *TW Read More »
STALL OR NO START - FUEL SHUTDOWN SOLENOID - WIRING CHAFING ON FUEL INJECTOR LINES-VEHICLES BUILT BEFORE 10/19/94 WITH FD1060 ENGINE AND BOSCH P7100 FUEL INJECTION PUMP. *TW Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT Read More »
INFORMATION REGARDING RANDOM HAIRLINE CRACKS, "STAR CRACKING" IN REAR SHEET MOLDING COMPOSITE (SMC) FENDERS - DUAL REAR VEHICLES OPERATING IN SEVERE DUTY CONDITIONS. *TT Read More »
LACK OF POWER - ACCELERATOR CABLE DISLODGES FROM ACCELERATOR PEDAL - VEHICLES WITH 7.0L ENGINE - VEHICLES BUILT FROM 8/1/90 THROUGH 6/3/96. *TW Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES
THE CHILD SEAT LOCKING CLIP LABEL, WHICH IDENTIFIES THE NEED FOR A LOCKING CLIP WHEN RESTRAINING A CHILD SEAT, WAS NOT INSTALLED ON THE RIGHT-HAND FRONT SEAT BELT. *TW Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
AIR CONDITIONING-LACK OF COOLING AT IDLE-A/C SYSTEM SHUTS OFF DUE TO HIGH SYSTEM PRESSURES-7.3L DI TURBO F-SERIES BUILT BEFORE 4/14/95 AND 7.3L DI TURBO ECONOLINES BUILT BEFORE 4/21/95. *SD Read More »
THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY ... Read More »
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC Read More »
