Is your defective Ford F-250 actually a LEMON?

Find out in 30 SECONDS or less if it qualifies for a REFUND or a CASH SETTLEMENT.

Print this page

10.0

really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
0 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

2022 Ford F-250 fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 2022 Ford F-250:

Unsubscribe any time. We don't sell/share your email.

2022 Ford F-250 Owner Comments

problem #7

Jan 022025

F-250

  • miles

A D V E R T I S E M E N T S

While driving on freeway, engine started to miss/hesitate. No check engine light. Miss/hesitation started to get more frequency and started smelling gas. No check engine light. Took offramp and truck died at stop sign. Pushed truck to gas station. Once out of truck, the smell of gas was prominent. Checked under hood and saw nothing unusual. Looked under truck on driver side and saw gas dripping from the transmission to the bumper under the truck. Looked under passenger side and saw more gas. Walked around to driver side, opened the driver door (which turns the fuel pump on) and saw gas spraying from under the truck. Got under the truck and determined that the supply connector on front side of fuel tank was disconnected. I reconnected the connector, clipped it locked, checked for leaks and restarted engine. There have been no further problems. Determined that approximately 10 plus gallons of gas sprayed under the truck. Approximate milage at time of incident was 6500 miles, current mileage is 6900 miles. I have purchased and plan to replace the following Ford part numbers per the Ford workshop manual which contains the connector and downstream fuel line: PC3Z 9J280, LC3Z 9S278.

- Oroville, CA, USA

problem #6

Nov 282024

F-250

  • miles
Engine started to tick and loss of power, had it hauled to ford dealership in Tulia tx to later find out that it had faulty rocker arms which is a known problem after calling around asking other dealerships if they have seen other pickups come in with the same issue! After digging further into the motor they found that the fuel system was going bad and also would have to be replaced which is also a well known issue after ford recalled 300,000 of these pickups with the same issue

- Lubbock, TX, USA

problem #5

Nov 012024

F-250

  • miles
I brought y car to the ford dealer in NOv 2024 for the open recall of reprogram integrated trailer relay module #22V193 and then they called me that the fuel pump needed to be replace because the truck al of the sudden stop working i spend over 12,000 to get the car fix and now i see the open recall for the fuel pump defective #24V-957 i would like to get a refund for the money i paid

- Lake Worth, FL, USA

problem #4

Jul 292024

F-250

  • miles

A D V E R T I S E M E N T S

The BJB fuse panel gets water in it.The vehicle produces multiple alarms and the throttle stops working. So when going down the road it goes to a idle and you can't get out of the way of other vehicle's. The ford dealership said the BJB Panels do get water in them but have not heard of them causing this problem. There was a list of alarm's from the fuse panel failure it all happened about the same time.

- La Farge, WI, USA

problem #3

Feb 232024

F-250

  • miles
ENG Light is on and losing throttle. When it loses throttle wrench light comes on. While driving on the interstate, the truck loses power and reduces speed on its own. It is difficult to maneuver to the side of road. It has been towed several times and repaired by more than one Ford dealership. We requested a buy back when the truck was under a year old and Akins Ford Winder Ga. refused to buy it back. It currently has 37,000 miles and has been sitting at the Akins dealership for two weeks. This truck could potentially cause an accident because it decelerates quickly and because of its size it is difficult to steer out of Atlanta, GA traffic. I have warned Ford Relationship director that someone will be injured in this vehicle. I was informed that I should contact NTSB and the Attorney General State of Georgia.

- Social Circle, GA, USA

problem #2

Jan 172024

F-250

  • miles
Multiple times, when engaging the throttle, it's as if all power from the engine is cut for a few seconds before it kicks back in.

- Nesbit, MS, USA

problem #1

Sep 252023

F-250

  • miles
Driving down a busy highway and my truck starts lurching and losing power and then just dies in the road. I had to wait a few minutes and the truck would start up. There were no warnings or lights initially. This happened three times. After the third time it would no longer start, and a solid check engine light appeared after the third time. The check engine light did not present itself the first two times. According to the dealer service department the fuel pump quit working. Based on the time of day, the traffic was horrific, and I was almost rear ended when the truck stopped in the middle of the road.

- Cibolo, TX, USA

Not what you are looking for?