Technical Service Bulletins (TSBs) for the 1997 F-250 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. Read More »
SUSPENSION - NOISE FROM FRONT SPRING REAR HANGER - REVISED REAR SPRING HANGER INSULATOR PAD - VEHICLES EQUIPPED WITH 6000, 7000 OR 9000 LB AXLES BUILT THROUGH 10/1/97. *TW Read More »
CUSTOMER MAY COMPLAIN THAT THE RAYBESTOS ELECTRONIC BRAKE CONTROLLER DOES NOT WORK, WORKS INCORRECTLY, WORKS INTERMITTENTLY, PULSES THE 4-WAY FLASHERS, AND / OR INTERFERS WITH ANTILOCK BRAKES OPERATION. Read More »
A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN HELPING TO RESOLVE PULL OR DRIFT CONDITIONS. *TT Read More »
A GRABBING CONDITION AND / OR SQUEAL NOISE FROM THE REAR BRAKES DURING FIRST FEW BRAKE APPLICATIONS AFTER RAINFALL AND / OR WHILE BRAKES ARE COLD. *TT Read More »
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
BRAKES - AIR COMPRESSOR/AIR PUMP SUPPORT BRACKET BROKEN - VEHICLES WITH 7.0L ENGINE - ENGINE - 7.0L - ACCESSORY DRIVE BELT ROLL - NOISE - RATTLE - AIR BRAKE COMPRESSOR/AIR PUMP SUPPORT BRACKET CRACKED- VEHICLES WITH 7.0L ENGINE. Read More »
SERVICE BRAKES, AIR:SUPPLY:LOW PRESSURE WARNING:SWITCH
THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED. *YC Read More »
SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. Read More »
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT Read More »
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT Read More »
LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. Read More »
VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW Read More »
THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT Read More »
SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR Read More »
SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT Read More »
SOME VEHICLES WITH HIGHER ODOMETER READINGS MAY EXPERIENCE A HESITATION ON ACCELERATION JUST OFF IDLE AND MISFIRE COMPLAINTS WITH MALFUNCTION INDICATOR LALMP ( MIL ) ON. *YC Read More »
SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION. Read More »
THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. Read More »
EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT Read More »
SOME VEHICLES MAY EXPERIENCE AN INTERMITTENT STALL CONDITION AFTER A LONG DECELERATION WHEN USING THE M1 OR M2 GEAR ON THE E40D OR WHEN USING A LOWER GEAR WITH THE M50D FOR ENGINE BRAKING. *TT Read More »
TRANSMISSION- E4OD- HARSH/DELAYED 2-3 UPSHIFTS- VEHICLES WITH 7.3L DIESEL AND 49-STATE CALIBRATION- F-SERIES BUILT THROUGH 2/3/97 AND ALL 1996 E-350. *JD Read More »
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. Read More »
SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT Read More »
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD Read More »
CHECK ENGINE LIGHT - DTC P1450 - CHECK FOR MOLD FLASHING CAUSING A FLOW RESTRICTION IN THE 90 DEGREE ELBOW EVAP LINE COMING OUT OF THE CANNISTER ASSEMBLY AND GOING TO THE FUEL TANK . *TW Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD Read More »
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
FOR CUSTOMER CONCERNS OF STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OF EXCESSIVE FUEL PRESSURE. *JD Read More »
STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OR EXCESSIVE FUEL PRESSURE AND/OR MIL ACTIVATION WITH DTCS. *JD Read More »
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. Read More »
FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. Read More »
FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. Read More »
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ Read More »
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW Read More »
EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT Read More »
FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. Read More »
VEHICLES BUILT WITH 4R70W TRANSMISSIONS BEARING A PREFIX OF F7 MUST BE OVERHAULED OR REPLACED WITH A NEW ASSEMBLY AS NO FQR ASSEMBLIES ARE AVAILABLE. *TW Read More »
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT Read More »
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. Read More »
SOME SUPER DUTY 7.3L E4OD AND 7.3L 4R100 VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT Read More »
SOME HEAVY DUTY AND SUPER DUTY VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT Read More »
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. Read More »
SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC Read More »
1997 F SERIES TRUCKS EQUIPPED WITH TRANSMISSIONS BEARING F7 PREFIXES DO NOT HAVE ASSEMBLIES AVAILABLE -REPAIR BY OVERHAUL OR USE NEW ASSEMBLY. *TW Read More »
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS Read More »
SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC Read More »
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. Read More »
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. Read More »
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT Read More »
SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND GOES AWAY WHEN OPERATING IN 4X4 MODE. *TT Read More »
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT Read More »
A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT Read More »
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
SOME TEXAS DEPARTMENT OF TRANSPORTATION (DOT) TRUCKS MAY ENCOUNTER A RADIO FREQUENCY INTERFERENCE (RFI) CONDITION WHEN USING HAND HELD TWO-WAY RADIOS IN THE RANGE OF 47.18 MHZ. *TT Read More »
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT Read More »
INFORMATION REGARDING A NEW SERVICE PART THAT HAS BEEN RELEASED FOR THE LICENSE PLATE LIGHT CIRCIUT WHICH WILL REDUCE THE COST OF REPAIR. *MJS Read More »
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT Read More »
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT Read More »
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT Read More »
REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT Read More »
THIS ONLINE BULLETIN ADDRESSES CONCERNS WITH CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT Read More »
DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ Read More »
A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT Read More »
SOME VEHICLES MAY EXHIBIT AN ENGINE BUCK, SURGE, OR JERK (ALSO KNOWN AS HITCHING / HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT Read More »
SOME CALIFORNIA 7.3L ENGINE EQUIPPED VEHICLES MAY EXHIBIT A BUCK / SURGE / JERK (ALSO KNOWN AS HITCHING) DURING HIGHWAY DRIVING AT SPEEDS 40 MPH OR GREATER WITH THE CRUISE CONTROL ENGAGED. *TT Read More »
LACK OF POWER - ACCELERATOR CABLE DISLODGES FROM ACCELERATOR PEDAL - VEHICLES WITH 7.0L ENGINE - VEHICLES BUILT FROM 8/1/90 THROUGH 6/3/96. *TW Read More »
SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT Read More »
SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT Read More »
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT Read More »
VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. Read More »
SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT Read More »
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY ... Read More »
HOTLINE CONTACT ID NUMBER ON OASIS. A NINE DIGIT CONTACT NUMBER IS ATTACHED TO THE OASIS INFORMATION WHEN A VIN AND SYMPTOM CODE IS ENTERED INTO OASIS. *YC Read More »
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC Read More »
THE SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES 4X4 LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD Read More »
AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNTIONING HAS BEEN DELAYED TO LATE FEBRUARY FORM THE ORIGINAL JANUARY 1997 DATE. *JD Read More »
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD Read More »
