- July 22: Ford EcoBoost Lawsuit Continues Even Though Recall Was Issued news | 0 days ago
- July 20: Cops Ordered to Pay Ford $12,000 in Explorer Carbon Monoxide Lawsuit news | 2 days ago
- July 6: Ford Appeals $1.7 Billion Roof-Crush Verdict news | 16 days ago
- July 5: Ford F-650 and F-750 Recall Issued Over Tie Rods recalls | 17 days ago
- July 3: Recall: Ford Mustang Steering Wheels Are Haunted recalls | 19 days ago
Ford TSB #SSM 52295
2022 Ford F-150 Lightning
TSB Document:
Affected Component: POWER TRAIN
- Summary
- Some 2021-2023 F-150 and 2023-2024 Expedition/Navigator vehicles equipped with a 3.5L EcoBoost engine may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine-to-transmission spacer plate (separator plate). To correct this condition, remove the transmission and flexplate and inspect the engine-to-transmission spacer plate and torque converter studs for wear/damage. If wear/damage is found, replace engine-to-transmission spacer plate. Refer to Workshop Manual (WSM) Section 303-01 Engine - 3.5L EcoBoost (BM), Removal and Installation, Crankshaft Rear Seal. When reinstalling the starter motor, be sure the starter is flush with the engine-to-transmission spacer plate prior to tightening the studbolts. Failure to do so may result in damaging newly installed engine-to-transmission spacer plate.
Click a tab for more information.