This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
The contact owns a 2021 Ford F-150. The contact stated that while the vehicle was parked, the steering wheel seized. The contact stated that the failure occurred while it was a cold on a low temperature morning. There were no warning lights illuminated. The contact stated that the vehicle was turned on and warmed up and eventually the steering wheel became operable. The vehicle was taken to the local dealer, where it was diagnosed that the steering rack needed to be replaced due to water intrusion. The vehicle was not repaired. The contact made the manufacturer aware of the failure and a case was opened. The failure mileage was approximately 50,000.
The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed and making a turn, the vehicle made a clicking sound. The contact stated that the steering assist fault warning light was displayed. The vehicle was taken to the dealer where it was diagnosed that the steering gear needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 84,000.
3.6.2021 - Ford F150 purchased at Battlefield Ford (Ourisman Ford), Manassus VA / registered in CT 7.27.21 -?" inspected by Torrington Ford, Torrington CT for rubbing sound front left side, nothing found / 6,325 miles 2.10.22 -?" inspected for same issue / nothing found / 16,000 miles 7.27.22 -?" inspected for same issue / nothing found / 24,000 miles 12.24.2022 -?" -??Catastrophic failure-?? of front differential / 34,369 miles. On Christmas Eve 2022 myself, husband and son were driving to family in NY when the truck very quickly started to make a severe grinding sound, became unable to steer, loss of control, and started to produce smoke & fire under the hood. We immediately stopped and got out unharmed. Fire was dripping out of the bottom of the truck and smoke/fire under the hood. We were lucky. Firetrucks came but were unable to do anything. The truck's wheels completely seized up - the tow truck had to skid it onto the flatbed. Repaired at Simmons-Rockwell Ford, Hallstead, PA. Complete new front differential and damaged parts in proximity to the failure (pinion gear, axle shaft, etc). 12.16.2023 -?" Again hearing a sound in front left side while driving; bring to the shop for inspection. Shop confirms front differential is failing again, per Torrington Ford, (where all maintenance and repairs were completed, except for the first failed front differential in PA). Advise not to drive for safety reasons. 52,922 miles. With both front differential failures - no warning lights or messages. Symptoms - a slight rubbing/grinding noise in the front left side of vehicle; -??rough-?? sound while driving. 1st front differential -?" inspected at 6,000 miles, 16,000 miles, and 24,000 miles. Failed at 34,369 miles. 2nd front differential -?" inspected at 52,922 miles, failing differential, advised not to drive. Dec 2023 -?" Buy-back claim filed with Ford Motor Co. Denied - "outside of the 18-month warranty period for VA Lemon Law". Clearly, safety is not a guiding tenet for Ford Motor Co.
The power steering assist lamp went on and the vehicle steering became very hard to steer while driving my wife was driving and could have gotten in a bad accident the ford motor company has made recalls for this same issue in other vehicles and i believe that my vehicle should be in that recall as well i have a 2021 f150 xlt 2.7 liter engine and i want my vehicle to be inspected and repaired because the for motor company has put faulty parts in this vehicle as well it is only 2 years old i shouldnt be having this issue.please launch an investigation to have this vehicle added to the list that needs a recall on power steering assist fault power steering.
The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the steering wheel became firm, and difficult to maneuver the vehicle. The power steering fault warning light illuminated. The vehicle was taken to an independent mechanic where the contact was informed of NHTSA Campaign Number: 21V407000 (Steering). The contact was then advised to take the vehicle to the dealer. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in the recall and advised to call the NHTSA Hotline. The failure mileage was approximately 53,000.
- Leander, TX, USA
Search CarComplaints.com for these popular complaint phrases...
In April 2023, while driving to work, at least a dozen error messages were displayed on the instrument cluster. When I arrived at work and was driving at a slower speed, I noticed some irregular feedback in the steering wheel and quickly realized the power steering was intermittently disabling itself. The truck had just rolled over 30k miles at this point and was well within the manufacturer's warranty period. I took the truck to the dealer for repair and got the truck back within a few days and was told it was repaired. The very next morning while driving to work again, the same problem ensued again with a dozen error messages and the power steering intermittently disabling itself. I took the truck bad to the dealer, contacted Ford customer care, and they got an engineering team to help work the problem. The service advisor also told me there were 3 other vehicles at their dealer with the same problem. After more than 30 days of being at the dealer for repair, the truck was returned to me again. Everything seemed to be fine for a couple months and then it returned again with many error messages and power steering failures. On Monday this week I started to pull out in traffic and the power steering disabled and caused me to cross the 2-lane road into oncoming traffic.
The contact owns a 2021 Ford F-150. The contact stated while driving approximately 45 MPH, the "Electrical Default, Service Engine Soon and Engine Coolant Overheating" messages were displayed. Also, the temperature gauge indicated that the engine had overheated, and steam was coming from under the hood. The vehicle began to lose power and the power steering malfunctioned. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 16,000.
I bought the vehicle new. The first time I took it to get an oil change, the mechanic came out to show me that the bell housing bolts were falling out. We tightened them up. I was having issues with the smell of breaks burning so I took it to a ford dealership but told them to check the bolts as well. I told them it would shake some when approaching 80 mph. They didn't find anything wrong. And nothing was said about the shaking. At 51k miles, my family was on vacation. My nephew noticed the front passenger wheel was about to blow out when we had stopped. Putting on the spare I started recording the change because the lug nuts were extremely loose. The tires have never been rotated or changed these issues were from the factory. I reached out to Ford, they told me to take it back to a shop which I have scheduled. It's pointless, this truck is a death trap and Ford doesn't seem to care at all about the level of safety this was for me and my family.
When Blue Cruise is activated and the vehicle takes a semi sharp turn it does not straighten back out and attempts to continue into oncoming traffic. Does not seem to happen on the interstate, I believe its because the curves are not as sharp. This is a frequent issue that happens continuously. Brought it to the attention of the dealer when I had the recall performed. They recommended a tech ride with me to reproduce it, but it was not offered at time of pickup. You can completely take over steering, but there is resistance. I just want this to be reported and hopefully a resolution comes up at some point.
I was pulling into my spot at work and the power steering assist light and pre collision assist lights cam on along with advance trac. At this point I had no power steering. Luckily I was basically stopped. I cycled the key on and off twice and it finally went back to normal. Then later that same day I started the truck up and proceeded to leave from work and the seatbelt restraint light, abs system, and tpms stopped working and I was notified of the faults via ford pass. The lights then went away right after. I have a service apt 9/29 at the dealer to see what is going on but I-??d like to get this documented in case it becomes a recurring issue. Thanks
A D V E R T I S E M E N T S
- Shelburne Falls, MA, USA