The contact owns a 2015 Ford F-150. The contact drove the vehicle to a local dealer for brake service and the dealer informed the contact that all 4 lug nuts were swollen and needed to be replaced. The dealer diagnosed the vehicle and determined that the lug nuts and brake pads needed to be replaced. The vehicle was repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 104,000.

- Edgewood, WA, USA

Could not remove the lug nuts. They did not fit in the lug wrench. They had to be hammered off.

- Cedar Park , TX, USA

The contact owns a 2015 Ford F-150. The contact stated that while receiving routine tire rotation services, the contact was informed that the lug nuts had seized. The lug nuts were replaced, but the failure recurred. The vehicle was taken back to the local dealer, who informed the contact that the lug nuts had seized again. The lug nuts were replaced. The dealer informed the contact about using aftermarket lug nuts. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 54,000.

- Orient, OH, USA

While driving down the road, only 48 mph, my back rear wheel studs busted my my lug nuts came off. I have researched many forums and other F-150s have had this same problem, with the same tire. The safety of myself and my family was put into danger, with this being an unforeseen issue. There were no warning lights or check engine lights on at the time of the accident.

- Lawton , OK, USA

The contact owns a 2015 Ford F-150. The contact stated that upon taking the vehicle to the dealer for servicing, he was informed that all 24-wheel lug nuts had failed and needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 90,000.

- Carlsbad, NM, USA

The contact owns a 2015 Ford F-150. The contact took the vehicle to jannell motors Inc (2000 Washington St, hanover, MA 02339) for an oil change and tire rotation. The dealer stated that they were unable to rotate the tires because they could not remove the lug nuts without being damaged. The dealer stated that the failure was a manufacturer issue. The manufacturer was contacted and provided a case number. The vehicle was not repaired. The failure mileage was 60,000.

- Marshfield, MA, USA

The contact owns a 2015 Ford F-150. While the vehicle was undergoing an oil change and tire rotation at bob maxey Ford of howell (2798 E grand river ave, howell, mi), the technician was unable to rotate the tires due to the swollen lug nuts. The manufacturer was notified and referred the contact to NHTSA. The failure mileage was approximately 44,000.

- Howell, MI, USA