Technical Service Bulletins (TSBs) for the 2006 F-150 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
FRONT TIRE WEAR ON INSIDE AND/OR OUTSIDE EDGE. *TT RAPID FEATHERING WEAR OF FRONT TIRES. *TT RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES. *TT Read More »
LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. Read More »
FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. Read More »
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. Read More »
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ Read More »
SOME 2004-2014 F-150 AND 2006-2008 MARK LT VEHICLES EQUIPPED WITH FOUR-WHEEL DRIVE (4WD) MAY EXHIBIT NOISY OR ENGAGED FRONT HUBS WHEN OPERATING IN TWO-WHEEL DRIVE (2WD) MODE. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. Read More »
ROUSH/FORD: VEHICLES MANUFACTURED BY ROUSH WITH AN INTERCOOLED ROUSH CHARGER HAVE AN OPPORTUNITY FOR AN UPGRADE TO AN ENHANCED PCM CALIBRATION. NOT ALL F150 ROUSHCHARGED VEHICLES WILL BE AFFECTED BY THESE VARIATIONS. Read More »
FORD TRUCK SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN THE CASE OF THE ROUSHCHARGER FOR THE F-150, THE TRUCKS CALIBRATION ENHANCEMENTS HAS BEEN DEVELOPED TO BETTER ACCOMMODATE REGIONAL VARIATIONS IN PREMIUM FUEL ... Read More »
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. Read More »
ROUSH/FORD: VEHICLES MANUFACTURED BY ROUSH WITH AN INTERCOOLED ROUSH CHARGER HAVE AN OPPORTUNITY FOR AN UPGRADE TO AN ENHANCED PCM CALIBRATION. NOT ALL F150 ROUSHCHARGED VEHICLES WILL BE AFFECTED BY THESE VARIATIONS. Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. Read More »
FORD: THERE MAY BE CHAFFING ON A WIRE HARNESS BETWEEN THE CLOCKSPRING AND DRIVER AIRBAG WHICH CAUSE THE AIRBAG WARNING LIGHT TO COME ON. *RM Read More »
FORD: THERE MAY BE CHAFFING ON A WIRE HARNESS BETWEEN THE CLOCKSPRING AND DRIVER AIRBAG WHICH CAUSE THE AIRBAG WARNING LIGHT TO COME ON. *RM Read More »
FORD: THERE MAY BE CHAFFING ON A WIRE HARNESS BETWEEN THE CLOCKSPRING AND DRIVER AIRBAG WHICH CAUSE THE AIRBAG WARNING LIGHT TO COME ON. *RM Read More »
FORD: SOME 2006-2008 F-150 LARIAT, XLT, AND FX4 VEHICLES (EXCLUDING HARLEY DAVIDSON AND XL) MAY EXHIBIT A WHISTLE NOISE FROM THE GRILLE AREA WHEN TRAVELING AT HIGHWAY SPEEDS OF 65MPH AND GREATER. Read More »
FORD: SOME 2006-2008 F-150 LARIAT, XLT, AND FX4 VEHICLES (EXCLUDING HARLEY DAVIDSON AND XL) MAY EXHIBIT A WHISTLE NOISE FROM THE GRILLE AREA WHEN TRAVELING AT HIGHWAY SPEEDS OF 65MPH AND GREATER. Read More »
20 INCH AND 22 INCH HIGH PERFORMANCE TIRES MAY EXHIBIT A VIBRATION IN STEERING WHEEL AND/OR SEAT WHILE DRIVING THE VEHICLE AFTER IT HAS BEEN PARKED FOR A FEW HOURS. *TT Read More »
