Technical Service Bulletins (TSBs) for the 2004 F-150 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
FRONT TIRE WEAR ON INSIDE AND/OR OUTSIDE EDGE. *TT RAPID FEATHERING WEAR OF FRONT TIRES. *TT RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES. *TT Read More »
FORD MOTOR COMPANY HAS MADE A DESIGN CHANGE TO THE FRONT BRAKE LINE(S) ON ALL F-150'S BUILD 11/29/04 AND LATER. RANCHO PRODUCT ADVISORY BULLETIN. *TT Read More »
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
LACK OF POWER WITH THE MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODE (DTC) P2106 (THROTTLE ACTUATOR CONTROL SYSTEM - FORCED LIMITED POWER) STORED AND ANTI-LOCK BRAKE SYSTEM LIGHTS ON. Read More »
LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. Read More »
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. Read More »
LOW POWER - COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED - OIL LEAK AT COLD SIDE CAC CONNECTIONS - 6.0L ENGINE - VEHICLES BUILT 12/15/2003 THROUGH 4/1/2004. *TT Read More »
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. Read More »
ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. Read More »
1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP. *NJ Read More »
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. Read More »
MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP. VARIOUS MODELS INCLUDING 2005 SUPER DUTY F-SERIES, EXCURSION, EXPEDITION, EXPLORER, MOUNTAINEER AND AVIATOR. *TT Read More »
SOME 2004-2014 F-150 AND 2006-2008 MARK LT VEHICLES EQUIPPED WITH FOUR-WHEEL DRIVE (4WD) MAY EXHIBIT NOISY OR ENGAGED FRONT HUBS WHEN OPERATING IN TWO-WHEEL DRIVE (2WD) MODE. FOLLOW THE SERVICE PROCEDURE STEPS TO CORRECT THE CONDITION. Read More »
SOME VEHICLES BUILT BEFORE 9/16/03 EQUIPPED WITH A 4.6L/5.4L ENGINE AND 4R75E TRANSMISSION MAY EXHIBIT THE TRANSMISSION CONCERN INDICATOR LAMP (TCIL) ON WITH DIAGNOSTIC TROUBLE CODE P0733 (3RD GEAR RATIO ERROR) AND/OR P0734 (4TH GEAR ... Read More »
FORD TRUCK SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN THE CASE OF THE ROUSHCHARGER FOR THE F-150, THE TRUCKS CALIBRATION ENHANCEMENTS HAS BEEN DEVELOPED TO BETTER ACCOMMODATE REGIONAL VARIATIONS IN PREMIUM FUEL ... Read More »
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. Read More »
CHATTER, SHUDDER, A BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNS ON VEHICLES EQUIPPED WITH THE 9.75 INCH OR 8.8 INCH LIMITED SLIP REAR AXLE. *TT Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
MALFUNCTION INDICATOR LAMP (MIL) AND ELECTRONIC THROTTLE CONTROL (ETC) LAMPS ON WITH BOTH DIAGNOSTIC TROUBLE CODE (DTC) P2106 AND P2135. *TT Read More »
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
FORD: THERE MAY BE CHAFFING ON A WIRE HARNESS BETWEEN THE CLOCKSPRING AND DRIVER AIRBAG WHICH CAUSE THE AIRBAG WARNING LIGHT TO COME ON. *RM Read More »
5.4L B-FUEL ENGINE MAY EXHIBIT A NO START CONDITION WHEN PROGRAMMING PASSIVE ANTI-THEFT SYSTEM (PATS) KEYS. *TT THIS OASIS UPDATES OASIS 16914 DATED 06/01/2003. *TT Read More »
FORD: THERE MAY BE CHAFFING ON A WIRE HARNESS BETWEEN THE CLOCKSPRING AND DRIVER AIRBAG WHICH CAUSE THE AIRBAG WARNING LIGHT TO COME ON. *RM Read More »
FORD: THERE MAY BE CHAFFING ON A WIRE HARNESS BETWEEN THE CLOCKSPRING AND DRIVER AIRBAG WHICH CAUSE THE AIRBAG WARNING LIGHT TO COME ON. *RM Read More »
AN ALUMINUM-BACKED BUTYL PAD MAY HAVE BEEN ADDED TO THE INSIDE SURFACE OF THE RIGHT HAND SIDE BOX OUTER PANEL IN FRONT OF THE TAIL LAMP. CUSTOMER SATISFACTION PROGRAM 04B23. BUTYL PAD REMOVAL. *TT SUPPLEMENT #1. *TT SUPPLEMENT #2. Read More »
FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. Read More »
