Print this page

NHTSA — Fuel System, Gasoline: Storage: Tank Assembly: Filler Pipe And Cap Problems

4.3

definitely annoying
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
26,400 miles

About These NHTSA Complaints:

This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.

So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.

1997 Ford F-150 fuel system problems

fuel system problem

Find something helpful? Spread the word.
Get notified about new defects, investigations, recalls & lawsuits for the 1997 Ford F-150:

Unsubscribe any time. We don't sell/share your email.

1997 Ford F-150 Owner Comments

problem #5

Sep 282011

F-150 4WD 8-cyl

  • miles

A D V E R T I S E M E N T S

1997 Ford F-150. Consumer writes in concerning safety recall 11V385000 regarding fuel tanks the consumer stated the fuel tank straps were replaced on September 28, 2011. Prior to the replacement, the consumer did not have any problems fueling his tank. After the straps were replaced, he started having problems with fuel leaking on the ground after filling the tank. The consumer returned to the dealer. An inspection revealed a crack on the filler neck on the tank. The dealer stated they were not responsible as they only replaced the straps. The hose clamps, fuel tank and filler spout were rusted.

- Richfield, MN, USA

Add Complaint
problem #4

Oct 012003

(reported on)

F-150 8-cyl

  • Automatic transmission
  • 132,000 miles
The consumer stated fuel leaked from the gas tank. The vehicle was serviced and the technician stated the filler tube was rusted at the tank 360 degrees around and 100% through.

- Crown Point, IN, USA

Add Complaint
problem #3

Jul 242000

(reported on)

F-150

  • miles
Fuel tank assembly: Filler tube has cracked, causing the gas to leak. Dealer has been contacted.

- Philladelphia, PA, USA

Add Complaint
problem #2

Jun 232000

F-150

  • miles
Due to a design flaw fuel filler tube cracked, causing fuel to leak. Also, engine check light came on, and vehicle overheated.

- Festus, MO, USA

Add Complaint
problem #1

Nov 241998

(reported on)

F-150

  • miles
Rubber hose that is connected to the filler tube which goes into the fuel tank is leaking fuel around the frame.

- St Augustine, FL, USA

Add Complaint

Not what you are looking for?