Technical Service Bulletins (TSBs) for the 1995 F-150 are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
SUSPENSION - NOISE FROM FRONT SPRING REAR HANGER - REVISED REAR SPRING HANGER INSULATOR PAD - VEHICLES EQUIPPED WITH 6000, 7000 OR 9000 LB AXLES BUILT THROUGH 10/1/97. *TW Read More »
SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:HANGER,BRACKET
W/ HYDRAULIC BRAKES & TILT HOOD, HYDRAULIC FLUID MAY LEAK FROM THE BRAKE PUMP RESERVOIR. TSB 95-10-13 PROVIDED A RESERVOIR SUPPORT BRACKET TO MINIMIZE LEAKAGE. IT WAS DETERMINED THAT THIS REPAIR WAS NOT ENTIRELY EFFECTIVE. Read More »
A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN RESOLVING BRAKE PULL OR DRIFT CONCERNS. *AK Read More »
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. Read More »
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. Read More »
BRAKES - AIR COMPRESSOR/AIR PUMP SUPPORT BRACKET BROKEN - VEHICLES WITH 7.0L ENGINE - ENGINE - 7.0L - ACCESSORY DRIVE BELT ROLL - NOISE - RATTLE - AIR BRAKE COMPRESSOR/AIR PUMP SUPPORT BRACKET CRACKED- VEHICLES WITH 7.0L ENGINE. Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT Read More »
ON SOME VEHICLES, THE OIL MAY LEAK ONTHE SIDE OF THE FD1460 ENGINE. THIS MAY HAPPEN BECAUSE THE OIL LEVEL INDICATOR (DIPSTICK) RISES OUT OF ITS NORMAL RETAINED POSITION WHEN THE ENGINE IS RUNNING. Read More »
ENGINE COMPARTMENT NOISE - BUZZING OR KNOCKING - RIGHT FRONT OF ENGINE - AFTER STARTING - 4.9L ENGINES - F SERIES BUILT FROM 8/1/94 THROUGH 10/15/95 - ECONOLINES BUILT FROM 8/15/94 THROUGH 10/15/95. Read More »
VEHICLES WITH 7.3L DIRECT INJECTION DIESEL ENGINES MAY EXPERIENCE ONE OR MORE OF THE FOLLOWING CONDITIONS: ROUGH IDLE, STALLING HESITATION/STUMBLE, LOSS/LACK OF POWER, POOR FUEL ECONOMY EXCESSIVE OIL CONSUMPTION. Read More »
HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD Read More »
ON F/B SERIES W/ FD 1060 ENGINE THERE MAY BE A CONCERN REGARDING INSUFFI- CIENT IN-CAB HEAT. TO RESOLVE THIS, THE CURRENT THERMOSTAT CAN BE REPLACED WITH A NEW LOW LEAK THERMOSTAT. THE NEEDED PARTS ARE AVAILABLE FROM CUMMIS ENGINE. Read More »
THE ENGINE COOLANT TEMP GAUGE MAY READ ON THE COLD SIDE OF THE NORMAL RANGE, OR MAY STAY BELOW NORMAL EVEN THOUGH THE ENGINE IS AT ITS PROPER OPERATING TEMP ON SOME VEHICLES. Read More »
HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD Read More »
HARD STARTING OR A NO START CONCERN MAY OCCUR ON SOME VEHICLES. THIS MAY BE DUE TO DIESEL FUEL DRAINING OUT OF THE FUEL INJECTION SYSTEM BACK INTO THE FUEL TANK. Read More »
NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW Read More »
MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW Read More »
VEHICLES EQUIPPED WITH ENGINES MANUFACTURED BETWEEN 10/11/94 AND 10/21/94 MAY HAVE LOOSE PRESSURE PLATE BOLTS, CAUSING SLIPPING CLUTCH, START-UP CHATTER OR GEAR CLASH. *TW Read More »
POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT Read More »
SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT Read More »
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. Read More »
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT Read More »
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. Read More »
REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. Read More »
SOME E4OD TRANSMISSIONS W/ BUILD DATES 5B03 (FEB. 3, 1995) AND 5E31 (MAY 31, 1995) MAY HAVE A VALVE, IN THE PUMP, THAT RESTRICTS FLUID FLOW (FIG 1). THIS VALVE MAY BECOME STUCK IN THE VALVE BORE AND RESTRICT LUBRICATION. Read More »
AUXILIARY POWERTRAIN CONTROL MODULE (APCM) - 7.3L DIT - AVAILABLE FOR AMBULANCES TOW TRUCKS, AND OTHER VEHICLES REQUIRING MANUAL THROTTLE CONTROL. *SD Read More »
ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD Read More »
SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT Read More »
4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES. Read More »
JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE Read More »
A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW Read More »
STALL OR NO START - FUEL SHUTDOWN SOLENOID - WIRING CHAFING ON FUEL INJECTOR LINES-VEHICLES BUILT BEFORE 10/19/94 WITH FD1060 ENGINE AND BOSCH P7100 FUEL INJECTION PUMP. *TW Read More »
STALL OR NO START - FUEL SHUTDOWN SOLENOID - WIRING CHAFING ON FUEL INJECTOR LINES-VEHICLES BUILT BEFORE 10/19/94 WITH FD1060 ENGINE AND BOSCH P7100 FUEL INJECTION PUMP. *TW Read More »
AUXILIARY POWERTRAIN CONTROL SYSTEM (APCS) - ENGINE IDLE SPEED DOES NOT ADJUST 7.3L DI TURBO. ENGINE IDLE SPEED DOES NOT ADJUST - 7.3L DI TURBO-SHORTED OR OPEN CIRCUIT TO AUXILIARY POWERTRAIN CONTROL SYSTEM (APCS). Read More »
SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT Read More »
GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW Read More »
WHEN DIAGNOSING AN AIR BAG LAMP FLASH-OUT CODE 33 (PASSENGER SIDE AIR BAG HIGH RESISTANCE OR OPEN) ON A 1994-1996 F150 OR BRONCO THAT IS NOT EQUIPPED WITH A PASSENGER SIDE AIR BAG, CHECK FOR PROPER GROUND FROM PIN 7, CIRCUIT 629, AT THE ... Read More »
HEADLAMP OR WHEEL ALIGNMENT REQUIRED BECAUSE OF SPECIAL BODIES ADDED TO INCOMPLETE VEHICLES (E/F SERIES CHASSIS CABS) OR BECAUSE OF SPECIAL EQUIPMENT INSTALLATION (MODIFICATION CONVERSION) AFTER THE VEHICLE LEAVES THE ASSEMBLY PLANT IS ... Read More »
LACK OF POWER - ACCELERATOR CABLE DISLODGES FROM ACCELERATOR PEDAL - VEHICLES WITH 7.0L ENGINE - VEHICLES BUILT FROM 8/1/90 THROUGH 6/3/96. *TW Read More »
LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE. Read More »
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES
SPECIAL FIELD ACTION 96L11 - AUDIO GUIDES PLACED IN THE MOUNTAINEERS DID NOT INCLUDE INSTRUCTIONS FOR THE OPERATION OF THE OPTIONAL JBL/LUXURY AUDIO SYSTEM - THE WARRANTY INFORMATION BOOKLETS IN THE AFFECTED E AND F SERIES TRUCKS DO NOT ... Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
A/C COMPRESSOR MAY BE DAMAGED DUE TO THE OVERALL LENGTH OF THE HOSE BETWEEN THE ACCUMULATOR AND THE COMPRESSOR. THE HOSE MAY NOT BE ADEQUATE TO TO ALLOW FOR ENGINE MOVEMENT. *TW Read More »
THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY ... Read More »
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC Read More »
