The contact's wife owns a 2023 Ford Explorer. The contact stated while driving at various speeds, there was an abnormal knocking sound coming from the front end of the vehicle. The vehicle was taken to the dealer, where it was determined that the front struts had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred several times. The dealer replaced the front struts three times; however, the failure persisted. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 24V091000(Suspension, Steering); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 2,000.

- Filer, ID, USA

The right front suspension collapsed after crossing railroad tracks at less than 10 mph, causing the vehicle to collapse and deploying all four airbags causing Minor injuries. A higher rate of speed would have caused severe injuries and possible fatalities. Ford has sent field engineers to examine the vehicle and pulled data from the rcm stating starting speed of 4.4 mph and 17.7 mph at time of impact. No collision and nothing in road way. THE Insurance company has the vehicle at a total loss and initially denied my claim, stating manufacturer defect, which I agree with. Ford has since denied my claim returning the liability to the insurance. No warning lights, or symptoms before the incident

- Lagrange, KY, USA

There is a load knocking noise coming from the front suspension. I have taken the vehicle in 3 times to Ford and after I drive off the lot the issue is gone. But after driving for a few days the issue returns. There is a loud clicking noise as well when you back up the vehicle coming from the front suspension.

- Enterprise, AL, USA

The contact owns a 2023 Ford Explorer. The contact stated there was an unknown part loosened at the front of the vehicle. While driving at unknown speeds, there was an abnormal rattling noise detected from the strut that had become louder over time. There were no warning lights illuminated. The vehicle was taken to the local dealer, where the front-end bolts were tightened. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The contact related the failure to NHTSA Campaign Number: 24V091000 (Suspension, Steering). The approximate failure mileage was 3,000.

- Fredericksburg, VA, USA