Technical Service Bulletins (TSBs) for the 2001 Explorer are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems.
All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT Read More »
POSTAL FLEET VEHICLES EQUIPPED WITH 4.0L FE ENGINE MAY EXHIBIT A LOW OIL PRESSURE GAUGE READING, CHECK ENGINE LIGHT ON AND SOMETIMES UPPER OR LOWER ENGINE NOISE. *TT Read More »
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
SOME VEHICLES BUILT BEFORE APRIL 23, 2001 MAY EXHIBIT A HARD START/LONG CRANK AFTER SITTING FOR AN HOUR OR MORE DUE TO FUEL SYSTEM CONTAMINATION. *TT Read More »
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE BETWEEN 2000 - 3000 RPM (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT Read More »
FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. Read More »
SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). Read More »
SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. Read More »
LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. Read More »
SOME 4.0L VEHICLES WITH A4WD BUILT PRIOR TO 9/13/99 MAY EXHIBIT A VIBRATION / PULSATION AT 0-45 MPH ON DRY PAVEMENT UNDER LIGHT TO MODERATE ACCELERATION IN 4 AUTO MODE WHICH MAY CHARACTERISTIC WITH THE CONTROL TRAC 4X4 SYSTEM. Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
SOME 4X4 VEHICLES MAY EXHIBIT A HIGH-PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT AXLE AREA OF THE VEHICLE AT SPEEDS FROM 16 TO 64 KM/H (10 TO 40 MPH). *TT Read More »
WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT Read More »
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. Read More »
SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN ... Read More »
SOME VEHICLES MAY EXHIBIT ONE OR ALL POWER WINDOWS INOPERATIVE, ALL OR ONE OF THE POWER DOOR LOCKS INOPERATIVE OR ALLTHE POWER DOOR LOCKS CYCLING UN-COMMANDED. *TT Read More »
SOME VEHICLES MAY EXHIBIT REPEAT SERVICE FOR AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODE B1994 (DRIVER SIDE AIR BAG CIRCUIT RESISTANCE HIGH) AND / OR B1998 (PASSENGER SIDE AIR BAG CIRCUIT RESISTANCE HIGH). Read More »
ON SOME VEHICLES, THE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) BLOWS COLD AIR FROM THE FLOOR DUCTS ON VEHICLES PRODUCED BEFORE 9/30/2000 ONLY. *TT Read More »
SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT Read More »
SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OR CHECK ENGINE LAMP (MIL) ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT Read More »
CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT Read More »
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) ACCOMPANIED BY A DIAGNOSTIC TROUBLE CODE (DTC) P0741 AND IN SOME CASES P1728. *TT Read More »
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION MAY EXHIBIT THE TCIL ON WITH DIAGNOSTIC TROUBLE CODE P0741 (TORQUE CONVERTER CLUTCH SYSTEM PERFORMANCE OR STUCK OFF) IN CONTINUOUS MEMORY. *JB Read More »
SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0351 THROUGH P0354 POSSIBLE WITH NO DRIVEABILITY CONCERNS PRESENT. Read More »
SOME VEHICLES EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0351, P0352, P0353 AND / OR P0354 IN SELF TEST WITH NO DRIVEABILITY CONCERNS PRESENT. Read More »
SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 THROUGH P0354 POSSIBLE WITH NO DRIVEABILITY CONCERNS PRESENT. Read More »
SOME VEHICLES MAY EXHIBIT THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL STRT-UP AFTER SEVERAL HOURS OF COLD SOAK. *JB Read More »
SOME VEHICLES EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH POSSIBLE DIAGNOSTIC TROUBLE CODES (DTC) P0351, P0352, P0353 AND / OR P0354 IN SELF TEST WITH NO DRIVEABILITY CONCERNS PRESENT. Read More »
