This data is from the NHTSA — the US gov't agency tasked with vehicle safety. Complaints are spread across multiple & redundant categories, & are not organized by problem.
So how do you find out what problems are occurring? For this NHTSA complaint data, the only way is to read through the comments below. Any duplicates or errors? It's not us.
Since we bought our car, it has had a rattle upon startup. This was originally a recall, which we got repaired, but this repair did not make the rattle go away. I then had a transmission problem and had to have the transmission overhauled due to it having violent, jerky, unpredictable shifting between gears. When I mentioned the rattle again while they were fixing the transmission, they said that it-??s a known problem with Ford cam phasers around our model year. They informed me that the fix offered in the recall was an electronic fix, but the actual parts need to be replaced and the recall didn-??t cover that. The parts replacement was almost $4000, and from my research, not replacing these parts can cause the engine to stop functioning properly over time. In the past two weeks, I have been getting safety notices from my car that there are timing issues that need to be serviced. Contacting Ford did not help as there is no active recall for this problem. From my research, there is an active lawsuit open against Ford for this cam phaser problem with my year model car. Overall, cam phasers play a critical role in enhancing the efficiency, performance, and reliability of 10-speed engines by enabling precise control over the engine-??s valve timing. However, after just replacing my transmission we cannot afford to pay another $4000 for this error. Ford said they cannot help unless there is a recall on the vehicle.
I am writing to urgently request the initiation of a safety investigation concerning a serious and potentially widespread defect in Ford vehicles, specifically related to the center console-??s metal chrome trim on limited models. I own a Ford Expedition, purchased in October 2019, and have encountered a severe issue where the chrome plating on the center console has begun peeling away, forming sharp, dangerous shards that have already caused significant injury to myself and my children. Despite numerous attempts to resolve this issue through Ford-??s customer service since first discovering the defect in 2020, the response has been dismissive, labeling the condition as "normal wear and tear." This is despite the fact that the sharp edges of the peeling chrome required medical attention on multiple occasions. The severity of this defect goes far beyond cosmetic degradation and enters the realm of serious safety hazard. Furthermore, this issue does not appear to be isolated. An examination of online consumer forums and resale platforms such as eBay reveals similar complaints from other Ford owners who note identical peeling issues in the same model and in analogous locations on the console. Historical precedence shows that similar defects in past models, like the Ford Explorer, have led to recalls. It is alarming that Ford has not only failed to recognize the defect as a legitimate safety concern but has also continued to sidestep responsibility even after the original factory warranty expired. This lack of accountability for a defect that directly impacts the physical safety of passengers and drivers is unacceptable. Given the potential risk to consumers and the apparent recurrence of this issue across multiple vehicles, I implore the NHTSA to initiate a thorough investigation into this matter. It is imperative that a recall be considered to prevent further injuries and ensure that Ford addresses this serious safety flaw promptly and effectively.
We bought a 2019 Ford expedition max xlt. On a trip we kept having problems with it jumping out of gear and it felt like the transmission was going to fall out. We looked it up and found several complaints on this same problem with the 2019 models although I can't find any recalls that would have fixed the problem.
There is an open recall with no remedy since February 2, 2024. The remedy should already be available, so I'm filing a complaint of remedy not available in timely manner.
The center console cup holder collapsed. It was a driving distraction and could have resulted in injury. We now have a have an open hole in the center of our car.
- Austin, TX, USA
Search CarComplaints.com for these popular complaint phrases...
Drain Plug in Moon Roof has been repaired 15 times over 4 years for blockage. The blockage is causing the Floorboard of the passenger side vehicle to become soaked, causing a musty, moldy, mildew smell in the car. I don't park under any trees and car is garaged frequently.
2019 Ford Expedition engine rattles on cold start, while driving at highway speeds, loss of engine power, and when Auto start/stop engages, it will, at times, "catch" and turn vehicle off due to lack of engine power- it will then flash a warning message stating driver must shift to park, then restart vehicle. Cam Phaser/Cam shaft wears prematurely, thus, not allowing it to open and close valves related to the crankshaft and pistons, which in turn poses a risk to both the vehicle operator as well as drivers on the road. Safety is a put at risk due to the cam phaser adjusting the camshaft so the car responds to low RPM- This causes reduced engine power and potential stalling- which is a major concern when driving any vehicle, especially on freeways with small children in the car. This problem has been confirmed by a dealing, specifically a dealer services manager, who stated "its a very known issue and somehow hasn't been recalled yet". The vehicle has been inspected a ford service manager The first known symptom is the rattle sound upon cold start, then other symptoms arose such as the lack of engine power, stalling, and auto start/stop not working correctly. The only "warning" is that of the auto start/stop malfunction that offers upon stalling (at a stop speed), this does not include stalling when at highway speeds.
My Expedition Windshield fluid leaks into my front passenger floor rug. Safety issue can-??t clean windshield without fluid in the tank as it is leaking into front passenger floor rug.
In the past year, the horn has gone off several times when car was locked and no one in it. Recently the horn stopped working with the key fob when locking the car and then this past week the horn has completely stopped working. This has been a faulty horn from the beginning and after doing a bit of research I see that others have had the same issue. This can become a safety issue as I realized it when someone cut in front of me and the horn did not work.
When the vehicle has the auto start-stop activated it will randomly kill the engine entirely when you go to drive forward from an auto start-stop stop. You then need to put the vehicle in park and restart the engine. I've taken this into the dealership twice now for this issue, as the first time they tried to fix it with a new battery, which did not fix the issue. It's currently at Ford Service being inspected again. This is unsafe as drivers behind you would be expecting you to move forward when traffic signals allow, and after they see your rear brake lights go off when you try to accelerate.
The chrome interior trim on the center console (around the drink holder and shifter, as well as the smaller compartments) in the limited edition is defective and edges are lifting to the point that razor sharp edges are exposed and have cut open my hands, as well as the hands of my children. I asked them to replace it under my warranty and they declined. This part is defective and there are reports of others experiencing this online. The material used seems to be lifting and is not adhering properly. The part started lifting around 36,000 miles and continues to lift. The edge, again, is extremely sharp. WE have continually cut ourselves just reaching to grab a drink.
While driving down the road, my vehicle suddenly drops from a higher gear down to 2nd. When this happens, the RPMs jump very high and the engine revs very high. While this is happening, I have no control and I can't use the gas pedal and am losing speed. The vehicle seems to be stalling. There are two messages that flash on the screen. "Shift system fault" and "see Manual". Neither are in the manual. I have taken it to Ford and after a day, they said nothing is wrong and collect almost $200. I took it in before my 75,000-mile transmission warranty was out. They said they have never heard of such a problem. I have now research it have found many people with the same on expeditionforum.com. It happens on a daily basis now and it's my only car and my learner car for my 15 year old. It WILL cause an accident. I did finally get it on videa and will make another attempt with FORD next week.
The Sync 3 System (APIM module) is faulty. Causing phone to connect/disconnect constantly, radio controls are delayed for 30 sec pauses or greater, changing from radio to climate will superimpose both categories on top of one another. Navigation sometimes just loads and loads and never comes on. The steering wheel controls create an even longer delay. I went to my local Ford dealer and had a master reset done which did not change the issues and was told that one or both of the modules is not working right "Malfunctioning " Latest updates to both the Sync and Navigation were preformed after the factory reset with no improvement to the system. With new state laws requiring hands free phone usage having the phone connect/disconnect constantly poses a very large safety problem. Also not being able to rely on the system to preform basic functions in a reasonable period of time causes your eyes to leave the road unnecessarily while driving.
Vehicle was placed in park, shut off, and exited. Vehicle was parked on a hill. Several minutes later vehicle started rolling down a hill; narrowly missing a young girl. Vehicle came to rest on its own without sustaining damage. Vehicle should not have been able to move while in park and shut off.
At approximately 13K miles began experiencing a stuttering or unsteady acceleration through 3rd, 4th, and 5th gears. Dealer performed a factory reset on vehicle cpu and advised 2K miles of learning were required. Now at 19K miles, unsteady acceleration through same gears is accompanied by a vibration and grumbling noise. This noise has become steadily more pronounced and the unsteady acceleration is worse.
Caught fire after using factory installed remote starter. A few days prior to the fire, the cruise control stopped working, after the cruise control stopped working, we received two warning lights on the dash display, service advance trac and hill decent control fault. I took photos of the dash warning and attempted to schedule a service appointment with the dealership, however the fire occurred before we could get it serviced. Ford sent their fire investigators to inspect vehicle, but we never received any explanation for the cause of the fire or a copy of their findings. The fire not only destroyed the Expedition, but also caught our attached garage on fire, which caused us to also loose another vehicle along with the majority of our house hold contents. This fire occurred on an early morning while most of our family was sleeping. We could have been killed! in addition to the photos attached, I also took a brief video of the fire as the fire department was arriving on scene.
This model of Ford Expedition advertises that infant car seats, convertible car seats, booster seats, and high back booster seats could be accommodated in 4 of their seats. However, the third row has automatic seat folding and headrest folding features which make it impossible to remove the third row headrests. When placing a high back booster seat in one of the third rows, the seat does not sit flush in accordance with the car seat instructions because the headrest is not flush with the seat. Since you cannot remove the headrest, there is no possible way to safely install this particular type of car seat. In my conversation with Ford they are now aware of the problem, but are unwilling to make any changes or purchase the car back. I purchased the car 3 months ago in anticipation of having a 3rd child. It is required that I put a high back booster seat safely in the 3rd row to accommodate my children, yet I cannot do that safely. I am taking the car with the seat to the police station tomorrow to see if they can put in writing that there is no way to safely install the seat.
Trailer brakes do not work below 11 mph. Manual states braking force is reduced. Tests by owner and dealer on 3 different trailers and an emulator show that trailer brakes are effectively disabled below 11 mph. This is a massive safety issue. We narrowly avoided an accident driving drown a gravel road, could not stop, trailer pushed us until trailer brakes were manually engaged. Ford Corp stated to dealership that this is "normal for this vehicle". see attached image.
My wife and I were making a left turn at an intersection when the vehicle stalled in the intersection while making the turn. An alert appeared on the dashboard "anti-collision alert" flashed on the dash and disappeared. Then another message appeared "drive mode not available". an orange wrench indicator light lit at the bottom of dashboard next to the odometer. The vehicle was not shifting correctly and as we drove further, the car shifted through the gears slowly and slowly and gradually. We drove the vehicle straight to the bell Ford dealership in phoenix. We dropped the vehicle off at the dealership. The dealership service department called me the next day and said they could not find anything wrong with the vehicle. I had described what happened to us, but they said nothing was recorded in the vehicle diagnostic system or black box. We have had the vehicle at the dealership for over 3 weeks now and they have had their mechanic driving the vehicle and said they are unable to replicate the issue. We do not feel safe in the vehicle now. We are not sure what to do now as the dealership says it is not eligible under the lemon law for a buyback.
A D V E R T I S E M E N T S
- Linden, TX, USA